Nissan X-Trail 32. Manual — part 1552
LU-44
< REMOVAL AND INSTALLATION >
[R9M]
OIL PUMP
OIL PUMP
Exploded View
INFOID:0000000010994267
Removal and Installation
INFOID:0000000010994268
REMOVAL
1.
Remove oil pan (lower). Refer to
Oil strainer
O-ring
Oil pump
Oil pump drive chain
Crankshaft sprocket (oil pump drive
chain)
. Comply with the installation proce-
dure when tightening. Refer to
44, "Removal and Installation"
: N·m (kg-m, ft-lb)
: N·m (kg-m, in-lb)
: Always replace after every disassembly.
: Should be lubricated with oil.
JPBIA6962GB
OIL PUMP
LU-45
< REMOVAL AND INSTALLATION >
[R9M]
C
D
E
F
G
H
I
J
K
L
M
A
LU
N
P
O
2.
Remove oil strainer with the following procedure:
• Remove oil strainer mounting bolt
.
• Remove oil strainer
3.
Remove oil pump with the following procedure:
• Remove oil pump bolts
.
• Disengage oil pump with sprocket assembly from oil pump
drive chain.
• Remove oil pump.
INSTALLATION
CAUTION:
• Before crank the engine, rotate crankshaft by hand to be sure that oil pump chain is correctly install
on the oil pump sprocket.
1.
Install oil pump with the following procedure:
a.
Install oil pump.
CAUTION:
Check that oil pump chain is correctly install on the oil
pump sprocket.
b.
Tighten oil pump mounting bolts
in two steps.
c.
Install oil strainer.
CAUTION:
Never reuse oil strainer gasket.
d.
Tighten oil stainer bolt
.
2.
Install oil pan (lower). Refer to
a.
E1BIA0659ZZ
1st step: 5.0 N·m (0.51 kg-m, 44 in-lb)
2nd step: 25.0 N·m (2.6 kg-m, 18 ft-lb)
E1BIA0659ZZ
LU-46
< SERVICE DATA AND SPECIFICATIONS (SDS)
[R9M]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Periodical Maintenance Specification
INFOID:0000000010783331
ENGINE OIL CAPACITY (APPROXIMATE)
Unit:
(lmp qt)
Engine Oil Pressure
INFOID:0000000010783332
Unit: kPa (bar, kg/cm
2
, psi)
*: Engine oil temperature at 80
°
C (176
°
F)
Drain and refill
With oil filter change
5.5 (4-7/8)
Without oil filter change
5.1 (4-1/2)
Dry engine (Overhaul)
6.6 (5-7/8)
Engine speed
Approximate discharge pressure*
Idle speed
More than 70 (0.7, 0.7, 10)
1,750 rpm
More than 150 (1.5, 1.5 , 22)
4,000 rpm
More than 360 (3.6, 3.7 , 52)
MA-1
MAINTENANCE
C
D
E
F
G
H
I
J
K
L
M
B
MA
SECTION
MA
N
O
A
CONTENTS
MAINTENANCE
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
PERIODIC MAINTENANCE . . . . . . ..
GENERAL MAINTENANCE . . . . . . . .
General Maintenance . . . . . . . . . . . ....
PERIODIC MAINTENANCE . . . . . . . .
Periodic Maintenance . . . . . . . . . . . ....
RECOMMENDED FLUIDS AND LUBRI-
CANTS . . . . . . . . . . . . . . . .
Fluids and Lubricants . . . . . . . . . . . ..
SAE Viscosity Number . . . . . . . . . . .
Engine Coolant Mixture Ratio . . . . . . . . .
ENGINE MAINTENANCE (MR20DD) . . . .
DRIVE BELTS . . . . . . . . . . . . . . ...
DRIVE BELTS : Exploded View . . . . . . . ..
DRIVE BELTS : Inspection . . . . . . . . . .
DRIVE BELTS : Adjustment . . . . . . . . .
ENGINE COOLANT . . . . . . . . . . . . ...
ENGINE COOLANT : Inspection . . . . . . . .
ENGINE COOLANT : Draining . . . . . . . .
ENGINE COOLANT : Refilling . . . . . . . .
ENGINE COOLANT : Flushing . . . . . . . ...
RADIATOR CAP . . . . . . . . . . . . . .
RADIATOR CAP : Inspection . . . . . . . . ..
RADIATOR . . . . . . . . . . . . . . . .
RADIATOR : Inspection . . . . . . . . . . ..
FUEL LINES . . . . . . . . . . . . . . . ..
FUEL LINES : Inspection . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . . . .
AIR CLEANER FILTER : Removal and Installation
.
AIR CLEANER FILTER : Inspection (Dry Paper
Type) . . . . . . . . . . . . . . . . . ...
ENGINE OIL . . . . . . . . . . . . . . . ...
ENGINE OIL : Draining . . . . . . . . . . .
ENGINE OIL : Refilling . . . . . . . . . . .
OIL FILTER . . . . . . . . . . . . . . . .
OIL FILTER : Removal and Installation . . . . ...
OIL FILTER : Inspection . . . . . . . . . . ..
SPARK PLUG . . . . . . . . . . . . . . .
SPARK PLUG : Removal and Installation . . . ...
SPARK PLUG : Inspection . . . . . . . . . ..
EVAP VAPOR LINES . . . . . . . . . . . .
EVAP VAPOR LINES : Inspection . . . . . . ...
ENGINE MAINTENANCE (QR25DE) . . . .
DRIVE BELTS . . . . . . . . . . . . . . .
DRIVE BELTS : Exploded View . . . . . . . ..
DRIVE BELTS : Inspection . . . . . . . . . ..
DRIVE BELTS : Adjustment . . . . . . . . .
ENGINE COOLANT . . . . . . . . . . . . ...
ENGINE COOLANT : Inspection . . . . . . . .
ENGINE COOLANT : Draining . . . . . . . .
ENGINE COOLANT : Refilling . . . . . . . . .
ENGINE COOLANT : Flushing . . . . . . . .
RADIATOR CAP . . . . . . . . . . . . . .
RADIATOR CAP : Inspection . . . . . . . . ..
RADIATOR . . . . . . . . . . . . . . . . .
RADIATOR : Inspection . . . . . . . . . . ...
FUEL LINES . . . . . . . . . . . . . . . ...
FUEL LINES : Inspection . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст