Nissan Juke (2016 year). Service Repair Manual — part 488
LU-36
< UNIT DISASSEMBLY AND ASSEMBLY >
[MR EXCEPT FOR NISMO RS MODELS]
OIL PUMP
• Loosen bolts in the reverse order of the numerical order as
shown in the figure.
INSTALLATION
Note the following, and install in the reverse order of removal.
Oil Pump
CAUTION:
Never reuse O-ring. Always replace it with a new one.
• Tighten the mounting bolts in numerical order as shown in the fig-
ure.
Oil Pump Sprocket
• Install the oil pump sprocket (1) in the direction shown in the figure.
Oil Pump Drive Chain Tensioner
• Fix the tensioner surface at the most compressed position using a
stopper pin (A), and then install it.
• After installing the oil pump drive chain tensioner (1), securely pull
out the stopper pin (
).
Inspection
INFOID:0000000012197503
INSPECTION AFTER INSTALLATION
1. Use the oil level gauge and check that the oil level is within the standard. Refer to
JSBIA5727ZZ
JSBIA5727ZZ
A
: Identification mark
: Engine front
JSBIA5729ZZ
JPBIA4401ZZ
Revision: November 2015
2016 JUKE
OIL PUMP
LU-37
< UNIT DISASSEMBLY AND ASSEMBLY >
[MR EXCEPT FOR NISMO RS MODELS]
C
D
E
F
G
H
I
J
K
L
M
A
LU
N
P
O
2. Start the engine. Check for fuel leakage.
3. Stop the engine. After stopping it, leave it for 10 minutes or more.
4. Check the engine oil level again, and fill with engine oil if necessary. Refer to
Revision: November 2015
2016 JUKE
LU-38
< SERVICE DATA AND SPECIFICATIONS (SDS)
[MR EXCEPT FOR NISMO RS MODELS]
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Periodical Maintenance Specification
INFOID:0000000012197504
ENGINE OIL CAPACITY (APPROXIMATE)
Unit: (US qt, lmp qt)
Engine Oil Pressure
INFOID:0000000012197505
NOTE:
Oil pump unit performance [oil: 0W-20, oil temp: 80
°
C (176
°
F)]
Drain and refill
With oil filter change
4.3 (4-4/8, 3-6/8)
Without oil filter change
4.1 (4-3/8, 3-5/8)
Dry engine (Overhaul)
5.2 (5-4/8, 4-5/8)
Discharge pressure
[kPa (kg/cm
2
, psi) / rpm]
Approx.110 (1.122, 15.95) / 600
Approx.320 (3.264, 46.4) / 2000
Discharge amount
[liters (US qt, Imp qt)/min]
/ rpm
7.3 (7-6/8, 6-3/8) or more / 600
29.8 (31-4/8, 26-2/8) or more / 2000
Regulator valve opening pressure/
Engine speed
[kPa (kg/cm
2
, psi) / rpm]
During low oil pressure control
(no lord driving)
150 - 200 (1.53 - 2.04, 21.75 -
29.0)
During low oil pressure control
(high lord driving)
290 - 370 (2.958 - 3.774, 42.05 -
53.65)
Revision: November 2015
2016 JUKE
MA-1
MAINTENANCE
C
D
E
F
G
H
I
J
K
L
M
B
MA
SECTION
MA
N
O
A
CONTENTS
MAINTENANCE
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
Commercial Service Tool . . . . . . . . . . ..
PERIODIC MAINTENANCE . . . . . . ..
GENERAL MAINTENANCE . . . . . . . .
Explanation of General Maintenance . . . . . ....
PERIODIC MAINTENANCE . . . . . . . .
Introduction of Periodic Maintenance . . . . . ....
RECOMMENDED FLUIDS AND LUBRI-
CANTS . . . . . . . . . . . . . . . .
Fluids and Lubricants . . . . . . . . . . . ..
SAE Viscosity Number . . . . . . . . . . .
Anti-Freeze Coolant Mixture Ratio . . . . . . ..
ENGINE MAINTENANCE (MR FOR NISMO
RS MODELS) . . . . . . . . . . . . . .
DRIVE BELT . . . . . . . . . . . . . . . ..
DRIVE BELT : Exploded View . . . . . . . .
DRIVE BELT : Inspection . . . . . . . . . .
DRIVE BELT : Adjustment . . . . . . . . . ..
ENGINE COOLANT . . . . . . . . . . . . ...
ENGINE COOLANT : Inspection . . . . . . . .
ENGINE COOLANT : Draining . . . . . . . .
ENGINE COOLANT : Refilling . . . . . . . .
ENGINE COOLANT : Flushing . . . . . . . ...
RADIATOR CAP . . . . . . . . . . . . . .
RADIATOR CAP : Inspection . . . . . . . . ..
RADIATOR . . . . . . . . . . . . . . . .
RADIATOR : Inspection . . . . . . . . . . ..
FUEL LINES . . . . . . . . . . . . . . . ..
FUEL LINES : Inspection . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . . . .
AIR CLEANER FILTER : Removal and Installation
AIR CLEANER FILTER : Inspection (Viscous Pa-
per Type) . . . . . . . . . . . . . . . . .
ENGINE OIL . . . . . . . . . . . . . . . ...
ENGINE OIL : Draining . . . . . . . . . . .
ENGINE OIL : Refilling . . . . . . . . . . .
OIL FILTER . . . . . . . . . . . . . . . .
OIL FILTER : Removal and Installation . . . . ...
OIL FILTER : Inspection . . . . . . . . . . ..
SPARK PLUG . . . . . . . . . . . . . . .
SPARK PLUG : Removal and Installation . . . ...
SPARK PLUG : Inspection . . . . . . . . . ..
EVAP VAPOR LINES . . . . . . . . . . . .
EVAP VAPOR LINES : Inspection . . . . . . ...
ENGINE MAINTENANCE (MR EXCEPT FOR
NISMO RS MODELS) . . . . . . . . . ...
DRIVE BELT . . . . . . . . . . . . . . . ..
DRIVE BELT : Exploded View . . . . . . . . .
DRIVE BELT : Inspection . . . . . . . . . .
DRIVE BELT : Adjustment . . . . . . . . . ...
ENGINE COOLANT . . . . . . . . . . . . ...
ENGINE COOLANT : Inspection . . . . . . . .
ENGINE COOLANT : Draining and Filling . . . ...
ENGINE COOLANT : Flushing . . . . . . . .
RADIATOR CAP . . . . . . . . . . . . . .
RADIATOR CAP : Radiator Cap Inspection . . .
FUEL LINES . . . . . . . . . . . . . . . ...
FUEL LINES : Inspection . . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . . . .
AIR CLEANER FILTER : Removal and Installation
Revision: November 2015
2016 JUKE
MA-2
ENGINE OIL . . . . . . . . . . . . . . . ..
ENGINE OIL : Draining . . . . . . . . . . ...
ENGINE OIL : Refilling . . . . . . . . . . ...
OIL FILTER . . . . . . . . . . . . . . . ...
OIL FILTER : Removal and Installation . . . . ..
OIL FILTER : Inspection . . . . . . . . . . .
SPARK PLUG . . . . . . . . . . . . . . ...
SPARK PLUG : Removal and Installation . . . ..
SPARK PLUG : Inspection . . . . . . . . . .
EVAP VAPOR LINES . . . . . . . . . . . ....
EVAP VAPOR LINES : Inspection . . . . . . ..
CHASSIS MAINTENANCE . . . . . . . .
EXHAUST SYSTEM . . . . . . . . . . . . ..
EXHAUST SYSTEM : Inspection . . . . . . ...
CVT FLUID (RE0F10B) . . . . . . . . . . . .
CVT FLUID (RE0F10B) : Inspection . . . . . ...
CVT FLUID (RE0F10D) . . . . . . . . . . . .
CVT FLUID (RE0F10D) : Inspection . . . . . ..
GEAR OIL (RS6F94R) . . . . . . . . . . . ..
GEAR OIL (RS6F94R) : Inspection . . . . . ....
GEAR OIL (RS6F94R) : Draining . . . . . . ...
GEAR OIL (RS6F94R) : Refilling . . . . . . ....
GEAR OIL (RS6F52H) . . . . . . . . . . . ..
GEAR OIL (RS6F52H) : Inspection . . . . . ....
GEAR OIL (RS6F52H) : Draining . . . . . . ...
GEAR OIL (RS6F52H) : Refilling . . . . . . ....
CLUTCH FLUID . . . . . . . . . . . . . ....
CLUTCH FLUID : Inspection . . . . . . . . ..
TRANSFER OIL . . . . . . . . . . . . . ....
TRANSFER OIL : Inspection . . . . . . . . ..
TRANSFER OIL : Draining . . . . . . . . . .
TRANSFER OIL : Refilling . . . . . . . . . ..
REAR PROPELLER SHAFT . . . . . . . . . .
REAR PROPELLER SHAFT : Inspection . . . ...
REAR DIFFERENTIAL GEAR OIL . . . . . . ...
REAR DIFFERENTIAL GEAR OIL : Inspection . ..
REAR DIFFERENTIAL GEAR OIL : Draining . . .
REAR DIFFERENTIAL GEAR OIL : Refilling . . .
WHEELS (BONDING WEIGHT TYPE) . . . . . .
WHEELS (BONDING WEIGHT TYPE) : Wheel
Balance Adjustment . . . . . . . . . . . ....
WHEELS (BONDING WEIGHT TYPE) : Tire Rota-
tion . . . . . . . . . . . . . . . . . . ..
BRAKE FLUID LEVEL AND LEAKS . . . . . ....
BRAKE FLUID LEVEL AND LEAKS : Inspection ...
BRAKE LINES AND CABLES . . . . . . . . ..
BRAKE LINES AND CABLES : Inspection . . . .
BRAKE FLUID . . . . . . . . . . . . . . ...
BRAKE FLUID : Changing . . . . . . . . . ..
DISC BRAKE . . . . . . . . . . . . . . . .
DISC BRAKE : Inspection . . . . . . . . . ...
DISC BRAKE : Front Disc Brake . . . . . . .
DISC BRAKE : Rear Disc Brake . . . . . . . .
STEERING GEAR AND LINKAGE . . . . . . ...
STEERING GEAR AND LINKAGE : Inspection . ..
AXLE AND SUSPENSION PARTS . . . . . . ...
AXLE AND SUSPENSION PARTS : Inspection . .
DRIVE SHAFT . . . . . . . . . . . . . . ...
DRIVE SHAFT : Inspection . . . . . . . . . .
BODY MAINTENANCE . . . . . . . . . .
LOCKS, HINGES AND HOOD LATCH . . . . . .
LOCKS, HINGES AND HOOD LATCH : Lubricat-
ing . . . . . . . . . . . . . . . . . . ...
SEAT BELT, BUCKLES, RETRACTORS, AN-
CHORS AND ADJUSTERS . . . . . . . . . ..
SEAT BELT, BUCKLES, RETRACTORS, AN-
CHORS AND ADJUSTERS : Inspection . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ..
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
DRIVE BELT (MR FOR NISMO RS MODELS) . . .
DRIVE BELT (MR FOR NISMO RS MODELS) :
Drive Belt . . . . . . . . . . . . . . . .
DRIVE BELT (MR EXCEPT FOR NISMO RS MOD-
ELS) . . . . . . . . . . . . . . . . . . ...
DRIVE BELT (MR EXCEPT FOR NISMO RS
MODELS) : Drive Belt . . . . . . . . . . . .
ENGINE COOLANT (MR FOR NISMO RS MOD-
ELS) . . . . . . . . . . . . . . . . . . ...
ENGINE COOLANT (MR FOR NISMO RS MOD-
ELS) : Periodical Maintenance Specification . . ..
ENGINE COOLANT (MR EXCEPT FOR NISMO RS
MODELS) . . . . . . . . . . . . . . . . ..
ENGINE OIL (MR FOR NISMO RS MODELS) . . ..
ENGINE OIL (MR FOR NISMO RS MODELS) :
Periodical Maintenance Specification . . . . . .
ENGINE OIL (MR EXCEPT FOR NISMO RS MOD-
ELS) . . . . . . . . . . . . . . . . . . ...
ENGINE OIL (MR EXCEPT FOR NISMO RS
MODELS) : Periodical Maintenance Specification ...
Revision: November 2015
2016 JUKE
MA-3
C
D
E
F
G
H
I
J
K
L
M
B
MA
N
O
A
SPARK PLUG (MR FOR NISMO RS MODELS) . ...
SPARK PLUG (MR FOR NISMO RS MODELS) :
Spark Plug . . . . . . . . . . . . . . . ...
SPARK PLUG (MR EXCEPT FOR NISMO RS
MODELS) . . . . . . . . . . . . . . . . ...
SPARK PLUG (MR EXCEPT FOR NISMO RS
MODELS) : Spark Plug . . . . . . . . . . .
ROAD WHEEL . . . . . . . . . . . . . . ...
ROAD WHEEL : Road Wheel . . . . . . . . ..
Revision: November 2015
2016 JUKE
MA-4
< PREPARATION >
PREPARATION
PREPARATION
PREPARATION
Special Service Tool
INFOID:0000000012200174
The actual shapes of TechMate tools may differ from those of special service tools illustrated here.
Commercial Service Tool
INFOID:0000000012200175
Tool number
(TechMate No.)
Tool name
Description
KV10115801
(J 38956)
Oil filter wrench
Removing and installing oil filter
a: 64.3 mm (2.531 in)
S-NT375
Tool name
Description
Power tool
Loosening nuts and bolts
Spark plug wrench
Removing and installing spark plug
a : 14 mm (0.55 in)
Radiator cap tester
Checking radiator and radiator cap
Radiator cap tester adapter
Adapting radiator cap tester to radiator cap
and radiator filler neck
a: 28 (1.10) dia.
b: 31.4 (1.236) dia.
c:41.3 (1.626) dia.
Unit: mm (in)
PBIC0190E
JPBIA0399ZZ
PBIC1982E
S-NT564
Revision: November 2015
2016 JUKE
GENERAL MAINTENANCE
MA-5
< PERIODIC MAINTENANCE >
C
D
E
F
G
H
I
J
K
L
M
B
MA
N
O
A
PERIODIC MAINTENANCE
GENERAL MAINTENANCE
Explanation of General Maintenance
INFOID:0000000012200176
General maintenance includes those items which should be checked during the normal day-to-day operation
of the vehicle. They are essential if the vehicle is to continue operating properly. The owners can perform
checks and inspections themselves or have their
NISSAN
dealers do them.
OUTSIDE THE VEHICLE
The maintenance items listed here should be performed from time to time, unless otherwise specified.
INSIDE THE VEHICLE
The maintenance items listed here should be checked on a regular basis, such as when performing periodic maintenance, cleaning the vehicle,
etc.
Item
Reference page
Tires
Check the pressure with a gauge often and always prior to long distance trips. Adjust
the pressure in all tires, including the spare, to the specified pressure. Check carefully
for damage, cuts or excessive wear.
Wheel nuts
When checking the tires, make sure no nuts are missing, and check for any loose nuts.
Tighten if necessary.
—
Tire rotation
Tires should be rotated every 5,000 miles (8,000 km).
Tire Pressure Monitor-
ing System (TPMS)
transmitter compo-
nents
Replace the TPMS transmitter grommet seal, valve core and cap when the tires are
replaced due to wear or age.
Wheel alignment and
balance
If the vehicle should pull to either side while driving on a straight and level road, or if
you detect uneven or abnormal tire wear, there may be a need for wheel alignment. If
the steering wheel or seat vibrates at normal highway speeds, wheel balancing may
be needed. For additional information regarding tires, refer to “lmportant Tire Safety
Information” (US) or “Tire Safety Information” (Canada) in the NISSAN Warranty Infor-
mation Booklet.
(2WD)
(AWD)
Windshield
Clean the windshield on a regular basis. Check the windshield at least every six
months for cracks or other damage. Repair as necessary.
—
Windshield wiper
blades
Check for cracks or wear if they do not wipe properly.
—
Doors and engine
hood
Check that all doors and the engine hood operate smoothly as well as the back door,
trunk lid and back hatch. Also make sure that all latches lock securely. Lubricate if nec-
essary. Make sure that the secondary latch keeps the hood from opening when the pri-
mary latch is released.
When driving in areas using road salt or other corrosive materials, check lubrication
frequently.
Lamps
Make sure that the headlamps, stop lamps, tail lamps, turn signal lamps, and other
lamps are all operating properly and installed securely. Also check headlamp aim.
Clean the headlamps on a regular basis.
—
Item
Reference page
Warning lamps and
chimes
Make sure that all warning lamps and chimes are operating properly.
—
Windshield wiper and
washer
Check that the wipers and washer operate properly and that the wipers do not streak.
—
Windshield defroster
Check that the air comes out of the defroster outlets properly and in sufficient quantity
when operating the heater or air conditioning.
—
Steering wheel
Check that it has the specified play. Check for changes in the steering condition, such
as excessive play, hard steering or strange noises.
Free play: Less than 35 mm (1.38 in)
—
Revision: November 2015
2016 JUKE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст