Nissan Juke (2016 year). Service Repair Manual — part 1
ACC-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
ACC
A
ACC
N
O
P
CONTENTS
ACCELERATOR CONTROL SYSTEM
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precautions for Removing Battery Terminal . . .....
REMOVAL AND INSTALLATION . . . .
ACCELERATOR CONTROL SYSTEM . . . ..
Exploded View . . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . . .
Revision: November 2015
2016 JUKE
ACC-2
< PRECAUTION >
PRECAUTIONS
PRECAUTION
PRECAUTIONS
Precautions for Removing Battery Terminal
INFOID:0000000012959279
When disconnecting the battery terminal, pay attention to the following.
• Always use a 12V battery as power source.
• Never disconnect battery terminal while engine is running.
• When removing the 12V battery terminal, turn OFF the ignition
switch and wait at least 30 seconds.
• For vehicles with the engine listed below, remove the battery termi-
nal after a lapse of the specified time:
NOTE:
ECU may be active for several tens of seconds after the ignition switch is turned OFF. If the battery terminal
is removed before ECU stops, then a DTC detection error or ECU data corruption may occur.
• After high-load driving, if the vehicle is equipped with the V9X engine, turn the ignition switch OFF and wait
for at least 15 minutes to remove the battery terminal.
NOTE:
• Turbocharger cooling pump may operate in a few minutes after the ignition switch is turned OFF.
• Example of high-load driving
- Driving for 30 minutes or more at 140 km/h (86 MPH) or more.
- Driving for 30 minutes or more on a steep slope.
• For vehicles with the 2-batteries, be sure to connect the main battery and the sub battery before turning ON
the ignition switch.
NOTE:
If the ignition switch is turned ON with any one of the terminals of main battery and sub battery discon-
nected, then DTC may be detected.
• After installing the 12V battery, always check "Self Diagnosis Result" of all ECUs and erase DTC.
NOTE:
The removal of 12V battery may cause a DTC detection error.
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT
PRE-TENSIONER"
INFOID:0000000012199342
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system includes seat belt switch inputs and dual stage front air bag modules. The SRS
system uses the seat belt switches to determine the front air bag deployment, and may only deploy one front
air bag, depending on the severity of a collision and whether the front occupants are belted or unbelted.
Information necessary to service the system safely is included in the “SRS AIR BAG” and “SEAT BELT” of this
Service Manual.
WARNING:
Always observe the following items for preventing accidental activation.
• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision that would result in air bag inflation, it is recommended that all maintenance
and repair be performed by an authorized NISSAN/INFINITI dealer.
• Improper repair, including incorrect removal and installation of the SRS, can lead to personal injury
caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag Module,
see “SRS AIR BAG”.
D4D engine
: 20 minutes
YS23DDT
: 4 minutes
HRA2DDT
: 12 minutes
YS23DDTT
: 4 minutes
K9K engine
: 4 minutes
ZD30DDTi
: 60 seconds
M9R engine
: 4 minutes
ZD30DDTT
: 60 seconds
R9M engine
: 4 minutes
V9X engine
: 4 minutes
YD25DDTi
: 2 minutes
SEF289H
Revision: November 2015
2016 JUKE
PRECAUTIONS
ACC-3
< PRECAUTION >
C
D
E
F
G
H
I
J
K
L
M
A
ACC
N
P
O
• Never use electrical test equipment on any circuit related to the SRS unless instructed to in this Ser-
vice Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or harness
connectors.
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS
WARNING:
Always observe the following items for preventing accidental activation.
• When working near the Air Bag Diagnosis Sensor Unit or other Air Bag System sensors with the
ignition ON or engine running, never use air or electric power tools or strike near the sensor(s) with
a hammer. Heavy vibration could activate the sensor(s) and deploy the air bag(s), possibly causing
serious injury.
• When using air or electric power tools or hammers, always switch the ignition OFF, disconnect the
battery or batteries, and wait at least 3 minutes before performing any service.
Revision: November 2015
2016 JUKE
ACC-4
< REMOVAL AND INSTALLATION >
ACCELERATOR CONTROL SYSTEM
REMOVAL AND INSTALLATION
ACCELERATOR CONTROL SYSTEM
Exploded View
INFOID:0000000012199343
Removal and Installation
INFOID:0000000012199344
REMOVAL
1. Remove instrumentpanel lower cover driver side.
2. Disconnect accelerator pedal position sensor harness connector.
3. Loosen mounting bolts, and remove accelerator pedal assembly.
CAUTION:
• Never disassemble accelerator pedal assembly. Never remove accelerator pedal position sensor
from accelerator pedal assembly.
• Avoid impact from dropping etc. during handling.
• Be careful to keep accelerator pedal assembly away from water.
INSTALLATION
Note the following, and install in the reverse order of removal.
• Insert the locating pin while inserting the locating hook in to the break pedal bracket. Tighten mounting bolts
to accelerator pedal assembly.
CAUTION:
Never squeeze the locating hook into the break pedal bracket when inserting the locating pin into the
hole on the brake pedal bracket side.
1.
Accelerator pedal assembly
2.
Brake pedal bracket
A. Locating hook
B. Locating pin
: N·m (kg-m, in-lb)
JPBIA5259GB
Revision: November 2015
2016 JUKE
ACCELERATOR CONTROL SYSTEM
ACC-5
< REMOVAL AND INSTALLATION >
C
D
E
F
G
H
I
J
K
L
M
A
ACC
N
P
O
Inspection
INFOID:0000000012199345
INSPECTION AFTER INSTALLATION
• Check accelerator pedal moves smoothly within the whole operation range when it is fully depressed and
released.
• Check accelerator pedal securely returns to the fully released position.
• For the electrical inspection of accelerator pedal position sensor. Refer to
EC-518, "Component Inspection"
,
EC-522, "Component Inspection"
EC-528, "Component Inspection"
.
CAUTION:
When harness connector of accelerator pedal position sensor is disconnected, perform “ACCELERA-
TOR PEDAL RELEASED POSITION LEARNING”. Refer to following. Refer to
Revision: November 2015
2016 JUKE
AV
AV-1
DRIVER INFORMATION & MULTIMEDIA
C
D
E
F
G
H
I
J
K
L
M
B
SECTION
AV
A
O
P
CONTENTS
AUDIO, VISUAL & NAVIGATION SYSTEM
DISPLAY AUDIO
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precautions for Removing Battery Terminal . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Commercial Service Tools . . . . . . . . . ....
SYSTEM DESCRIPTION . . . . . . . ..
COMPONENT PARTS . . . . . . . . . .
Component Parts Location . . . . . . . . . ....
Component Description . . . . . . . . . . .....
SYSTEM . . . . . . . . . . . . . . . .
System Description . . . . . . . . . . . . .
DIAGNOSIS SYSTEM (AUDIO UNIT) . . . .
Description . . . . . . . . . . . . . . . ..
On Board Diagnosis Function . . . . . . . . .
ECU DIAGNOSIS INFORMATION . . . ..
AUDIO UNIT . . . . . . . . . . . . . ...
Reference Value . . . . . . . . . . . . . .
WIRING DIAGRAM . . . . . . . . . ..
DISPLAY AUDIO . . . . . . . . . . . .
Wiring Diagram . . . . . . . . . . . . . ...
BASIC INSPECTION . . . . . . . . ...
DIAGNOSIS AND REPAIR WORKFLOW . . .
Work Flow . . . . . . . . . . . . . . . ...
DTC/CIRCUIT DIAGNOSIS . . . . . . .
POWER SUPPLY AND GROUND CIRCUIT .
AUDIO UNIT . . . . . . . . . . . . . . . ...
AUDIO UNIT : Diagnosis Procedure . . . . . ...
MICROPHONE SIGNAL CIRCUIT . . . . .
Diagnosis Procedure . . . . . . . . . . . ...
STEERING SWITCH SIGNAL A CIRCUIT . ...
Description . . . . . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
STEERING SWITCH SIGNAL B CIRCUIT . ...
Description . . . . . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
STEERING SWITCH SIGNAL GND CIRCUIT ...
Description . . . . . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
Component Inspection . . . . . . . . . . . .
CAMERA IMAGE SIGNAL CIRCUIT . . . .
Description . . . . . . . . . . . . . . . ...
Diagnosis Procedure . . . . . . . . . . . ...
SYMPTOM DIAGNOSIS . . . . . . . ..
AUDIO SYSTEM . . . . . . . . . . . ...
Symptom Table . . . . . . . . . . . . . ...
NORMAL OPERATING CONDITION . . . ...
Description . . . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
AUDIO UNIT . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . . .
FRONT DOOR SPEAKER . . . . . . . .
Revision: November 2015
2016 JUKE
AV-2
Removal and Installation . . . . . . . . . ....
REAR DOOR SPEAKER . . . . . . . . ...
Removal and Installation . . . . . . . . . ....
TWEETER . . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ....
MICROPHONE . . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . ....
STEERING SWITCH . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
REAR VIEW CAMERA . . . . . . . . . ..
Removal and Installation . . . . . . . . . ....
Adjustment . . . . . . . . . . . . . . . ..
USB CONNECTOR AND AUX JACK . . . ...
Removal and Installation . . . . . . . . . ....
ANTENNA BASE . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
ANTENNA FEEDER . . . . . . . . . . ..
Feeder Layout . . . . . . . . . . . . . ....
AUDIO WITH NAVIGATION
PRECAUTION . . . . . . . . . . . .
PRECAUTIONS . . . . . . . . . . . . .
Precautions for Removing Battery Terminal . . ...
Precaution for Trouble Diagnosis . . . . . . ...
Precaution for Harness Repair . . . . . . . ...
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . .
Commercial Service Tools . . . . . . . . . ..
SYSTEM DESCRIPTION . . . . . . .
COMPONENT PARTS . . . . . . . . . ...
Component Parts Location . . . . . . . . . .
Component Description . . . . . . . . . . ..
SYSTEM . . . . . . . . . . . . . . . .
System Description . . . . . . . . . . . . .
Fail-Safe (Around View Monitor Control Unit) . . .
DIAGNOSIS SYSTEM (NAVI CONTROL
UNIT) . . . . . . . . . . . . . . . . ..
On Board Diagnosis Function . . . . . . . . .
CONSULT Function . . . . . . . . . . . ....
DIAGNOSIS SYSTEM (AROUND VIEW MON-
ITOR CONTROL UNIT) . . . . . . . . . .
CONSULT Function . . . . . . . . . . . .
ECU DIAGNOSIS INFORMATION . . . .
NAVI CONTROL UNIT . . . . . . . . . ..
Reference Value . . . . . . . . . . . . . .
DTC Index . . . . . . . . . . . . . . . ...
AROUND VIEW MONITOR CONTROL UNIT ...
Reference Value . . . . . . . . . . . . . .
Fail-Safe (Around View Monitor Control Unit) . . .
DTC Inspection Priority Chart . . . . . . . . .
DTC Index . . . . . . . . . . . . . . . ...
WIRING DIAGRAM . . . . . . . . .
NAVIGATION SYSTEM . . . . . . . . . .
Wiring Diagram . . . . . . . . . . . . . ...
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORKFLOW . .
NAVIGATION SYSTEM . . . . . . . . . . ...
NAVIGATION SYSTEM : Work Flow . . . . .
AROUND VIEW MONITOR SYSTEM . . . . . .
AROUND VIEW MONITOR SYSTEM : Work Flow
.
INSPECTION AND ADJUSTMENT . . . . ..
ADDITIONAL SERVICE WHEN REPLACING NAVI
CONTROL UNIT . . . . . . . . . . . . . ..
ADDITIONAL SERVICE WHEN REPLACING
NAVI CONTROL UNIT : Description . . . . . .
ADDITIONAL SERVICE WHEN REPLACING
AROUND VIEW MONITOR CONTROL UNIT . . .
CONFIGURATION (NAVI CONTROL UNIT) . . ...
CONFIGURATION (NAVI CONTROL UNIT) : De-
scription . . . . . . . . . . . . . . . . .
CONFIGURATION (NAVI CONTROL UNIT) :
Special Repair Requirement . . . . . . . . .
CONFIGURATION (AROUND VIEW MONITOR
CONTROL UNIT) . . . . . . . . . . . . . .
CONFIGURATION (AROUND VIEW MONITOR
CONTROL UNIT) : Work Procedure . . . . . .
PREDICTIVE COURSE LINE CENTER POSITION
ADJUSTMENT . . . . . . . . . . . . . .
PREDICTIVE COURSE LINE CENTER POSI-
TION ADJUSTMENT : Description . . . . . ...
PREDICTIVE COURSE LINE CENTER POSI-
TION ADJUSTMENT : Work Procedure . . . ...
CALIBRATING CAMERA IMAGE (AROUND VIEW
MONITOR) . . . . . . . . . . . . . . . ...
Revision: November 2015
2016 JUKE
AV
AV-3
C
D
E
F
G
H
I
J
K
L
M
B
A
O
P
CALIBRATING CAMERA IMAGE (AROUND
VIEW MONITOR) : Description . . . . . . . .
CALIBRATING CAMERA IMAGE (AROUND
VIEW MONITOR) : Work Procedure . . . . . .
DTC/CIRCUIT DIAGNOSIS . . . . . ...
C1A03 VEHICLE SPEED SENSOR . . . . .
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
C1A39 STEERING ANGLE SENSOR . . . ..
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U0122 ABS ACTUATOR AND ELECTRIC
UNIT (CONTROL UNIT) . . . . . . . . ...
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U0416 ABS ACTUATOR AND ELECTRIC
UNIT (CONTROL UNIT) . . . . . . . . ...
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U0428 STEERING ANGLE SENSOR . . . ..
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U1000 CAN COMM CIRCUIT . . . . . . ...
NAVI CONTROL UNIT . . . . . . . . . . .
NAVI CONTROL UNIT : Description . . . . . .
NAVI CONTROL UNIT : DTC Logic . . . . . ..
NAVI CONTROL UNIT : Diagnosis Procedure . .
AROUND VIEW MONITOR CONTROL UNIT . . .
AROUND VIEW MONITOR CONTROL UNIT :
Description . . . . . . . . . . . . . . .
AROUND VIEW MONITOR CONTROL UNIT :
DTC Logic . . . . . . . . . . . . . . . .
AROUND VIEW MONITOR CONTROL UNIT :
Diagnosis Procedure . . . . . . . . . . .
U1010 CONTROL UNIT (CAN) . . . . . .
NAVI CONTROL UNIT . . . . . . . . . . .
NAVI CONTROL UNIT : DTC Logic . . . . . ..
AROUND VIEW MONITOR CONTROL UNIT . . .
AROUND VIEW MONITOR CONTROL UNIT :
Description . . . . . . . . . . . . . . .
AROUND VIEW MONITOR CONTROL UNIT :
DTC Logic . . . . . . . . . . . . . . . .
AROUND VIEW MONITOR CONTROL UNIT : Di-
agnosis Procedure . . . . . . . . . . . .
U111A REAR CAMERA IMAGE SIGNAL CIR-
CUIT . . . . . . . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U111B SIDE CAMERA RH IMAGE SIGNAL
CIRCUIT . . . . . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U111C FRONT CAMERA IMAGE SIGNAL
CIRCUIT . . . . . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U111D SIDE CAMERA LH IMAGE SIGNAL
CIRCUIT . . . . . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1200 NAVI CONTROL UNIT . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
U1217 NAVI CONTROL UNIT . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
U1229 NAVI CONTROL UNIT . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
U1232 STEERING ANGLE SENSOR . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1244 GPS ANTENNA . . . . . . . . ...
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1258 SATELLITE RADIO ANTENNA . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1263 USB . . . . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1264 AMP. . . . . . . . . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U12AA CONFIGURATION ERROR . . . .
DTC Logic . . . . . . . . . . . . . . . ..
U12AB ANTENNA . . . . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U12AC NAVI CONTROL UNIT . . . . . ...
DTC Logic . . . . . . . . . . . . . . . ..
U12AD NAVI CONTROL UNIT . . . . . ...
DTC Logic . . . . . . . . . . . . . . . ..
U12AE NAVI CONTROL UNIT . . . . . ...
DTC Logic . . . . . . . . . . . . . . . ..
U12AF NAVI CONTROL UNIT . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Revision: November 2015
2016 JUKE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст