Nissan Juke (2016 year). Service Repair Manual — part 2
AV-4
U12B0 POWER SUPPLY VOLTAGE . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
U12B1 POWER SUPPLY VOLTAGE . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
U1304 CAMERA IMAGE CALIBRATION . ...
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1305 CONFIG UNFINISH . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
POWER SUPPLY AND GROUND CIRCUIT ...
NAVI CONTROL UNIT . . . . . . . . . . . .
NAVI CONTROL UNIT : Diagnosis Procedure . ..
AROUND VIEW MONITOR CONTROL UNIT . . ..
AROUND VIEW MONITOR CONTROL UNIT : Di-
agnosis Procedure . . . . . . . . . . . . .
MICROPHONE SIGNAL CIRCUIT . . . . ..
Description . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
CAMERA IMAGE SIGNAL CIRCUIT . . . ...
Description . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
STEERING SWITCH SIGNAL A CIRCUIT . ..
Description . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
Component Inspection . . . . . . . . . . ...
STEERING SWITCH SIGNAL B CIRCUIT . ..
Description . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
Component Inspection . . . . . . . . . . ...
STEERING SWITCH GROUND CIRCUIT . ...
Description . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
Component Inspection . . . . . . . . . . ...
SYMPTOM DIAGNOSIS . . . . . . .
NAVIGATION SYSTEM . . . . . . . . ...
Symptom Table . . . . . . . . . . . . . .
HANDS-FREE PHONE SYMPTOMS . . . ..
Symptom Table . . . . . . . . . . . . . .
NORMAL OPERATING CONDITION . . . ..
Description . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . ..
NAVI CONTROL UNIT . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
FRONT DOOR SPEAKER . . . . . . . ...
Removal and Installation . . . . . . . . . ...
REAR DOOR SPEAKER . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
TWEETER . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
WOOFER . . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
ANTENNA BASE . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
GPS ANTENNA . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
MICROPHONE . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
AROUND VIEW MONITOR CONTROL UNIT ..
Removal and Installation . . . . . . . . . ...
FRONT CAMERA . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
REAR CAMERA . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . ...
SIDE CAMERA . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . ...
STEERING ANGLE SENSOR . . . . . . ..
Exploded View . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
STEERING SWITCH . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ..
Removal and Installation . . . . . . . . . ...
USB CONNECTOR AND AUX JACK . . . ..
Removal and Installation . . . . . . . . . ...
ANTENNA FEEDER . . . . . . . . . . .
Feeder Layout . . . . . . . . . . . . . ...
INTEGRATED CONTROL SYSTEM
PRECAUTION . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . .
Precautions for Removing Battery Terminal . . .
SYSTEM DESCRIPTION . . . . . . ..
COMPONENT PARTS . . . . . . . . . ..
Component Parts Location . . . . . . . . ...
Component Description . . . . . . . . . .
Multi Display Unit . . . . . . . . . . . . ..
Revision: November 2015
2016 JUKE
AV
AV-5
C
D
E
F
G
H
I
J
K
L
M
B
A
O
P
SYSTEM . . . . . . . . . . . . . . ...
INTEGRATED CONTROL SYSTEM . . . . . ...
INTEGRATED CONTROL SYSTEM : System De-
scription . . . . . . . . . . . . . . . . .
HANDLING PRECAUTION . . . . . . . ..
Integrated Control System . . . . . . . . .
DIAGNOSIS SYSTEM (MULTI DISPLAY
UNIT) . . . . . . . . . . . . . . . .
CONSULT Function . . . . . . . . . . . ..
ECU DIAGNOSIS INFORMATION . . .
MULTI DISPLAY UNIT . . . . . . . . . .
Reference Value . . . . . . . . . . . . ...
DTC Inspection Priority Chart . . . . . . . ...
DTC Index . . . . . . . . . . . . . . . .
WIRING DIAGRAM . . . . . . . . .
INTEGRATED CONTROL SYSTEM . . . .
Wiring Diagram . . . . . . . . . . . . . .
BASIC INSPECTION . . . . . . . . .
DIAGNOSIS AND REPAIR WORK FLOW . ..
Work Flow . . . . . . . . . . . . . . . .
DTC/CIRCUIT DIAGNOSIS . . . . . ...
U1000 CAN COMM CIRCUIT . . . . . . ...
Description . . . . . . . . . . . . . . .
DTC Logic . . . . . . . . . . . . . . . .
Diagnosis Procedure . . . . . . . . . . . .
U1010 CONTROL UNIT (CAN) . . . . . .
Description . . . . . . . . . . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1402 ENGINE SPEED SIGNAL . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1405 ENGINE TORQUE SIGNAL . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1406 BOOST PRESSURE INPUT . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1412 LONG ACC INPUT . . . . . . . ..
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
U1413 TRANS ACC INPUT . . . . . . .
DTC Logic . . . . . . . . . . . . . . . ..
Diagnosis Procedure . . . . . . . . . . . .
POWER SUPPLY AND GROUND CIRCUIT ..
MULTI DISPLAY UNIT . . . . . . . . . . . .
MULTI DISPLAY UNIT : Diagnosis Procedure . ..
SYMPTOM DIAGNOSIS . . . . . . .
INTEGRATED CONTROL SYSTEM . . . ...
Symptom Table . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . .
MULTI DISPLAY UNIT . . . . . . . . .
Exploded View . . . . . . . . . . . . . ...
Removal and Installation . . . . . . . . . ...
Revision: November 2015
2016 JUKE
AV-6
< PRECAUTION >
[DISPLAY AUDIO]
PRECAUTIONS
PRECAUTION
PRECAUTIONS
Precaution for Supplemental Restraint System (SRS) "AIR BAG" and "SEAT BELT
PRE-TENSIONER"
INFOID:0000000012202450
The Supplemental Restraint System such as “AIR BAG” and “SEAT BELT PRE-TENSIONER”, used along
with a front seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. This system includes seat belt switch inputs and dual stage front air bag modules. The SRS
system uses the seat belt switches to determine the front air bag deployment, and may only deploy one front
air bag, depending on the severity of a collision and whether the front occupants are belted or unbelted.
Information necessary to service the system safely is included in the “SRS AIR BAG” and “SEAT BELT” of this
Service Manual.
WARNING:
Always observe the following items for preventing accidental activation.
• To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death in
the event of a collision that would result in air bag inflation, it is recommended that all maintenance
and repair be performed by an authorized NISSAN/INFINITI dealer.
• Improper repair, including incorrect removal and installation of the SRS, can lead to personal injury
caused by unintentional activation of the system. For removal of Spiral Cable and Air Bag Module,
see “SRS AIR BAG”.
• Never use electrical test equipment on any circuit related to the SRS unless instructed to in this Ser-
vice Manual. SRS wiring harnesses can be identified by yellow and/or orange harnesses or harness
connectors.
PRECAUTIONS WHEN USING POWER TOOLS (AIR OR ELECTRIC) AND HAMMERS
WARNING:
Always observe the following items for preventing accidental activation.
• When working near the Air Bag Diagnosis Sensor Unit or other Air Bag System sensors with the
ignition ON or engine running, never use air or electric power tools or strike near the sensor(s) with
a hammer. Heavy vibration could activate the sensor(s) and deploy the air bag(s), possibly causing
serious injury.
• When using air or electric power tools or hammers, always switch the ignition OFF, disconnect the
battery or batteries, and wait at least 3 minutes before performing any service.
Precautions for Removing Battery Terminal
INFOID:0000000012947019
When disconnecting the battery terminal, pay attention to the following.
• Always use a 12V battery as power source.
• Never disconnect battery terminal while engine is running.
• When removing the 12V battery terminal, turn OFF the ignition
switch and wait at least 30 seconds.
• For vehicles with the engine listed below, remove the battery termi-
nal after a lapse of the specified time:
NOTE:
ECU may be active for several tens of seconds after the ignition switch is turned OFF. If the battery terminal
is removed before ECU stops, then a DTC detection error or ECU data corruption may occur.
• After high-load driving, if the vehicle is equipped with the V9X engine, turn the ignition switch OFF and wait
for at least 15 minutes to remove the battery terminal.
NOTE:
D4D engine
: 20 minutes
YS23DDT
: 4 minutes
HRA2DDT
: 12 minutes
YS23DDTT
: 4 minutes
K9K engine
: 4 minutes
ZD30DDTi
: 60 seconds
M9R engine
: 4 minutes
ZD30DDTT
: 60 seconds
R9M engine
: 4 minutes
V9X engine
: 4 minutes
YD25DDTi
: 2 minutes
SEF289H
Revision: November 2015
2016 JUKE
AV
PRECAUTIONS
AV-7
< PRECAUTION >
[DISPLAY AUDIO]
C
D
E
F
G
H
I
J
K
L
M
B
A
O
P
• Turbocharger cooling pump may operate in a few minutes after the ignition switch is turned OFF.
• Example of high-load driving
- Driving for 30 minutes or more at 140 km/h (86 MPH) or more.
- Driving for 30 minutes or more on a steep slope.
• For vehicles with the 2-batteries, be sure to connect the main battery and the sub battery before turning ON
the ignition switch.
NOTE:
If the ignition switch is turned ON with any one of the terminals of main battery and sub battery discon-
nected, then DTC may be detected.
• After installing the 12V battery, always check "Self Diagnosis Result" of all ECUs and erase DTC.
NOTE:
The removal of 12V battery may cause a DTC detection error.
Revision: November 2015
2016 JUKE
AV-8
< PREPARATION >
[DISPLAY AUDIO]
PREPARATION
PREPARATION
PREPARATION
Commercial Service Tools
INFOID:0000000012202452
Tool name
Description
Power tool
Loosening screws
PBIC0191E
Revision: November 2015
2016 JUKE
AV
COMPONENT PARTS
AV-9
< SYSTEM DESCRIPTION >
[DISPLAY AUDIO]
C
D
E
F
G
H
I
J
K
L
M
B
A
O
P
SYSTEM DESCRIPTION
COMPONENT PARTS
Component Parts Location
INFOID:0000000012202453
Component Description
INFOID:0000000012202454
1.
Front door speaker LH
2. Rear door speaker LH
3. Rear view camera
4.
Rear door speaker RH
5. Antenna rod
6.
Antenna base (antenna amp. and
satellite radio antenna)
7.
Front door speaker RH
8. Microphone
9. Tweeter LH
10. Steering switch
11. USB connector and AUX jack
12. Tweeter RH
13. Audio unit
JSNIA7983ZZ
Part name
Description
Audio unit
• Controls audio system and hands-free phone system functions.
• Sound signals are output to each speaker.
Steering switch
• Operation for audio and hands-free phone are possible.
• Steering switch signal (operation signal) is output to audio unit.
Front door speaker
• Inputs sound signal from audio unit.
• Outputs mid and low range sounds.
Tweeter
• Inputs sound signal from audio unit.
• Outputs high range sounds.
Rear door speaker
• Inputs sound signal from audio unit.
• Outputs high, mid and low range sounds.
Antenna base
A radio antenna base integrated with radio antenna amp. and satellite radio antenna is adopted.
ANTENNA AMP.
• Radio signal received by rod antenna is amplified and transmitted to audio unit.
• Power (antenna amp. ON signal) is supplied from audio unit.
SATELLITE RADIO ANTENNA
• Receives satellite radio waves and outputs it to audio unit.
Microphone
• Used for hands-free phone operation.
• Microphone signal is transmitted to audio unit.
• Power (microphone VCC) is supplied from audio unit.
Revision: November 2015
2016 JUKE
AV-10
< SYSTEM DESCRIPTION >
[DISPLAY AUDIO]
COMPONENT PARTS
USB connector and AUX jack
• Sound signal of auxiliary input is transmitted to audio unit.
• Sound signal of USB input is transmitted to audio unit.
Rear view camera
• Camera power supply is input from audio unit.
• The image of vehicle rear view is transmitted to audio unit.
Part name
Description
Revision: November 2015
2016 JUKE
AV
SYSTEM
AV-11
< SYSTEM DESCRIPTION >
[DISPLAY AUDIO]
C
D
E
F
G
H
I
J
K
L
M
B
A
O
P
SYSTEM
System Description
INFOID:0000000012202455
AUDIO SYSTEM
The audio system consists of the following components:
• Audio unit
• Front door speakers
• Rear door speakers
• Tweeters
• Steering wheel audio control switches
• USB interface
• AUX in jack
• Antenna amp.
• Rod antenna
• Satellite radio.
When the audio system is on, AM/FM signals received by the rod antenna are amplified by the antenna amp.
and sent to the audio unit. The audio unit then sends audio signals to the front door speakers and rear door
speakers.
Refer to Owner's Manual for audio system operating instructions.
USB INTERFACE FUNCTION
• iPod
®
or music files in USB memory can be played.
• Sound signals are transmitted from USB interface to the audio unit and output to each speaker.
• iPod
®
is recharged when connected to USB interface.
iPod
®
is a trademark of Apple inc., registered in the U.S. and other countries.
HANDS-FREE PHONE SYSTEM
• Bluetooth
®
control is built into audio unit.
• The connection between cellular phone and audio unit is performed with Bluetooth
®
communication.
• The voice guidance signal is input from the audio unit and output to the front speakers when operating the
cellular phone.
When A Call Is Originated
JSNIA8041GB
Revision: November 2015
2016 JUKE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст