Fiat Tipo 5Door / Tipo Station Wagon (2018 year). Manual — part 12
Thousands of miles
9
18
27
36
45
54
63
72
81
90
Thousands of kilometres
15
30
45
60
75
90
105
120
135
150
Years
1
2
3
4
5
6
7
8
9
10
Replace the toothed timing drive belt (1.4 16V 95 HP
E6 versions / 1.4 16V 95 HP E4 versions / 1.4 T-jet
120 HP versions / 1.4 T-jet 120 HP LPG versions)
(4)
Replace the accessory drive belt(s) (1.4 16V 95 HP
E6 versions / 1.4 16V 95 HP E4 versions / 1.4 T-jet
120 HP versions / 1.4 T-jet 120 HP LPG versions)
(4)
Replace the accessory drive belt(s) (1.6 E.TorQ
E6 versions / 1.6 E.TorQ E4 versions)
Replace the air cleaner cartridge (1.4 16V 95 HP
E6 versions / 1.4 16V 95 HP E4 versions / 1.4 T-jet
120 HP versions / 1.4 T-jet 120 HP LPG versions)(8)
Replace the air cleaner cartridge (1.6 E.TorQ E6 versions /
1.6 E.TorQ E4 versions)(8)
Replace the oxygen sensor (1.4 16V 95 HP E4 versions /
1.6 E.TorQ E4 versions)(9)
Change the brake fluid
(10)
(4) The maximum mileage is 120,000 km. The belt must be replaced every 6 years, regardless of distance travelled. If the vehicle is used in heavy conditions (dusty
areas, especially severe weather conditions, very low or very high temperatures for extended periods, urban driving, long periods of idling), the maximum mileage
is 60,000 km. The belt must be replaced every 4 years regardless of the mileage.
(8) If the vehicle is used in dusty areas, you are advised to change this filter every 15,000 km.
(9) This operation must be performed if the vehicle is used in one of the following countries: Algeria, Bahrain, Angola, Bolivia, Cameroon, Congo, El Salvador,
Ethiopia, Philippines, Gabon, Ghana, Jordan, Guatemala, Honduras, Kenya, Libya, Madagascar, Malawi, Mali, Mauritania, Mozambique, Panama, Peru, Uganda,
Zambia, Zimbabwe.
(10) The brake fluid replacement has to be done every two years, irrespective of the mileage.
184
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Thousands of miles
9
18
27
36
45
54
63
72
81
90
Thousands of kilometres
15
30
45
60
75
90
105
120
135
150
Years
1
2
3
4
5
6
7
8
9
10
Replace the filter inside the pressure regulator (1.4 T-Jet
120 HP LPG versions)
Replace the paper filter (LPG in gaseous state) (1.4 T-Jet
120 HP LPG versions)
Replace the passenger compartment cleaner(8) (o) (
●)
(8) If the vehicle is used in dusty areas, you are advised to change this filter every 15,000 km.
(o) Recommended operations
(
●) Obligatory operations
185
-------------------------------------------------------------------------------------------------------------------------------------------------------------
SCHEDULED SERVICING PLAN (Diesel versions)
WARNING: Once you have carried out the last intervention in the table, continue with the scheduled servicing, maintaining the
frequency indicated in the plan by marking each operation with a dot or dedicated note. Warning: simply restarting the
maintenance from the start of the plan may cause the allowed interval to be exceeded for some operations!
Thousands of miles
12
24
36
48
60
72
84
96
108
120
Thousands of kilometres
20
40
60
80
100
120
140
160
180
200
Years
1
2
3
4
5
6
7
8
9
10
Check tyre condition/wear and adjust pressure, if
necessary. Check quick tyre repair kit recharge
conditions/expiry date (if provided)
Check operation of lighting system (headlights, direction
indicators, hazard warning lights, boot, passenger
compartment, glove compartment, instrument panel
warning lights, etc.)
Check and, if necessary, top up fluid levels(1) (2)
Check exhaust emissions
Use the diagnosis socket to check operation of engine
control, emissions and engine oil deterioration system (the
latter, where provided)(3)
(1) Always only use the liquids shown in the handbook for topping up after having checked that the system is not damaged.
(2) Consumption of additive for emissions (UREA) depends on the condition of use of the vehicle and is indicated by a warning light and message on the instrument
panel (for versions/markets, where provided).
(3) If the "remaining percentage of efficient engine oil" detected by the vehicle diagnostics is lower than or equal to 20%, it is advisable to replace the engine oil and
engine filter in order to avoid another service operation after a short time.
186
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Thousands of miles
12
24
36
48
60
72
84
96
108
120
Thousands of kilometres
20
40
60
80
100
120
140
160
180
200
Years
1
2
3
4
5
6
7
8
9
10
Visually inspect conditions of: exterior bodywork,
underbody protection, pipes and hoses (exhaust, fuel
system, brakes), rubber elements (gaiters, sleeves,
bushes, etc.)
Check windscreen and rear window wiper blade
position/wear
Check operation of the windscreen wiper/washer system
and adjust jets, if necessary
Check cleanliness of bonnet and luggage compartment
locks, cleanliness and lubrication of linkage
Check handbrake lever travel and adjust, if necessary
Visually inspect condition and wear of front and rear disc
brake pads (4) and condition of pad wear indicator
Visually inspect condition and wear of the rear drum brake
lining(4)
Visually inspect the condition of the toothed timing belt
(1.6 Multijet 120 HP / 115 HP versions)(5)
Visually inspect condition of the accessory drive belt(s)(5)
(4) For versions/markets, where provided
(5) The maximum mileage is 120,000 km. The belt must be replaced every 6 years, regardless of distance travelled. If the vehicle is used in heavy conditions (dusty
areas, especially severe weather conditions, very low or very high temperatures for extended periods, urban driving, long periods of idling), the maximum mileage
is 60,000 km. The belt must be replaced every 4 years regardless of the mileage.
187
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Thousands of miles
12
24
36
48
60
72
84
96
108
120
Thousands of kilometres
20
40
60
80
100
120
140
160
180
200
Years
1
2
3
4
5
6
7
8
9
10
Check tension of accessory drive belt (versions without
automatic tensioner)
Check the electro-hydraulic actuator oil level and top up, if
necessary (1.6 Multijet 120 HP versions with dual-clutch
automatic transmission / 115 HP versions with dual-clutch
automatic transmission)(6)
Change engine oil and replace oil filter (versions with DPF)
(7)
Replace the toothed timing belt (1.6 Multijet 120 HP /
115 HP versions)
(5)
Replace accessory drive belt/s
(5)
Replace the fuel filter cartridge (1.3 Multijet 95 HP
versions)(8)
Replace the fuel filter cartridge (1.6 Multijet 120 HP /
115 HP versions)(8)
(6) Check to be carried out every year for cars on the road in countries with particularly severe climates (cold countries).
(7) The actual interval for changing the oil and replacing the engine oil filter depends on the car usage conditions and is signalled by the warning light or message (if
present) in the instrument panel. In any case, it must never exceed 2 years. Where the car is used mostly in urban settings you need to replace the engine oil
filter every year.
(5) The maximum mileage is 120,000 km. The belt must be replaced every 6 years, regardless of distance travelled. If the vehicle is used in heavy conditions (dusty
areas, especially severe weather conditions, very low or very high temperatures for extended periods, urban driving, long periods of idling), the maximum mileage
is 60,000 km. The belt must be replaced every 4 years regardless of the mileage.
(8) If the vehicle runs on fuel with quality below the relevant European specification, this filter must be replaced every 20,000 km
188
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Thousands of miles
12
24
36
48
60
72
84
96
108
120
Thousands of kilometres
20
40
60
80
100
120
140
160
180
200
Years
1
2
3
4
5
6
7
8
9
10
Replace air cleaner cartridge(9)
Change the brake fluid
(10)
Replace the passenger compartment cleaner(9) (o) (
●)
(9) If the vehicle is used in dusty areas, this cleaner must be replaced every 20,000 km.
(10) The brake fluid replacement has to be done every two years, irrespective of the mileage.
(o) Recommended operations
(
●) Obligatory operations
189
-------------------------------------------------------------------------------------------------------------------------------------------------------------
REGULAR CHECKS
Every 1,000 km or before long trips
check and, if necessary, top up:
engine coolant level;
brake fluid level;
windscreen washer fluid level;
tyre inflation pressure and condition;
operation of lighting system
(headlights, direction indicators, hazard
warning lights, etc.);
operation of windscreen wash/wipe
system and positioning/wear of wiper
blades;
check and top up additive level for
AdBlue® Diesel emissions (UREA) (for
versions/markets, where provided);
Every 3,000 km, check and top up if
required: engine oil level.
DEMANDING USE OF THE
CAR
If the car is used mainly under one of
the following conditions:
dusty roads;
short, repeated journeys (less than
7-8 Km) at sub-zero outdoor
temperatures;
engine often idling or driving long
distances at low speeds or long periods
of inactivity;
the following checks must be carried
out more often than indicated in the
Scheduled Servicing Plan:
check front disc brake pad condition
and wear;
check cleanliness of bonnet and
luggage compartment locks,
cleanliness and lubrication of linkage;
visually inspect conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust/fuel system/brakes) and
rubber elements (gaiters/sleeves/
bushes, etc.);
check battery charge and battery
fluid level (electrolyte);
visually inspect conditions of the
accessory drive belts;
check and, if necessary, change
engine oil and replace oil filter;
check and, if necessary, replace
pollen filter;
check and, if necessary, replace air
cleaner;
Restore additive level for
AdBlue®
Diesel emissions (UREA) (for
versions/markets, where applicable),
when the warning light comes on or the
message on the instrument panel
appears;
190
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
ENGINE COMPARTMENT
CHECKING LEVELS
165) 166)
72)
1.4 16V 95 HP E6 version
1. Brake fluid
2. Battery
3. Windscreen/rear window washer fluid 4. Engine coolant
5. Engine oil dipstick
6. Engine oil
cap/filler
205
09026J0001EM
191
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.4 16V 95 HP E4 version
1. Brake fluid
2. Battery
3. Windscreen/rear window washer fluid
4. Engine coolant
5. Engine oil dipstick
6. Engine
oil cap/filler
206
P09026J002
192
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.4 T-Jet 120 HP version
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
207
P1030198-000-000
193
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.4 T-Jet 120 HP LPG version
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
208
PGL000021
194
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.6 E.Torq E6 version
(where provided)
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
209
09026J0004EM
195
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.6 E.Torq E4 version
(where provided)
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
210
P09026J001
196
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.6 16V Multijet / 1.6 16V Multijet ECO without UREA
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
211
09026J0003EM
197
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.6 16V Multijet / 1.6 16V Multijet ECO version with UREA
1. Brake fluid 2. Battery 3. Windscreen/rear window washer fluid 4. Engine coolant 5. Engine oil dipstick 6. Engine oil
cap/filler
212
09026J0006EM
198
SER
VICING
AND
CARE
-------------------------------------------------------------------------------------------------------------------------------------------------------------
1.3 Multijet 95 HP version
1. Brake fluid
2. Battery
3. Windscreen/rear window washer fluid 4. Engine coolant
5. Engine oil dipstick 6. Engine oil
cap/filler
213
09026J0002EM
199
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст