Suzuki Grand Vitara JB416 / JB420. Manual — part 405
9M-1 Exterior Trim:
Body, Cab and Accessories
Exterior Trim
Repair Instructions
Roof Drip Molding Removal and Installation (If Equipped)
S5JB0A9D06005
*
1
3
2
4
4
6
5
5
[A]
[B]
a
a
b
b
c
5
5
5
4
I5JB0A9D0001-02
[A]: Molding Cap Removal
Remove cap by pushing in arrow direction shown on cap and then pulling in
alphabetical order indicated in figure.
4. Roof carrier bracket
[B]: Molding Cap Installation
Be sure to direct arrow mark of left side molding cap to vehicle forward and
arrow mark of right side molding cap to vehicle rearward.
5. Roof drip molding cap
1. Roof drip front molding
6. Roof drip molding clip (Push-in type)
2. Roof drip center molding
*: 5 door model only
3. Roof drip rear molding
Exterior Trim: 9M-2
Roof Rail Removal and Installation (If Equipped)
S5JB0A9D06007
1
2
3
4
4
4*
5
5
5*
I5JB0A9D0002-03
1. Roof rail
3. Roof drip molding clip (Push-in type)
5. Roof rail bolt
2. Roof drip front molding
4. Roof rail cap
*: 5 door model only
9M-3 Exterior Trim:
Splash Guard Removal and Installation (If Equipped)
S5JB0A9D06006
A
*
A
A
B
A
A
A
A
A
B
1
**
2
A
A
A
A
A
A
A
A
A
A
A
3**
A
A
A
A
A
A
4
4
I5JB0A9D0003-02
1. Side sill splash guard
3. Rear door splash guard
*: 3 door model only
2. Front door splash guard
4. Cap
**: 5 door model only
Table of Contents 10- i
10
Section 10
CONTENTS
Control Systems
Precautions . . . . . . . . . . . ...10-1
Precautions. . . . . . . . . . . . . . ... 10-1
Precautions for Control Systems. . . . . . . 10-1
Cruise Control System. . . . . . .. 10A-1
General Description . . . . . . . . . . ...10A-1
Cruise Control System Construction . . . . . 10A-1
Components and Functions of Cruise Control
System . . . . . . . . . . . . . . . 10A-2
Cancel Conditions of Cruise Control System . 10A-3
Schematic and Routing Diagram. . . . . ..10A-3
Cruise Control System Input / Output Diagram ..10A-3
Cruise Control System Wiring Diagram . . . 10A-4
Diagnostic Information and Procedures. . ..10A-5
Cruise Control System Symptom Diagnosis . .10A-5
Inspection of Cruise Control System Circuit. ..10A-6
Repair Instructions . . . . . . . . . . . 10A-8
Cruise Control Switch Removal and
Installation. . . . . . . . . . . . . ...10A-8
Cruise Control Switch Inspection . . . . . ..10A-8
CPP Switch (for Cruise Control) Removal and
Installation. . . . . . . . . . . . . ...10A-8
Clutch Pedal Position (CPP) Switch (for
Cruise Control) Inspection and Adjustment . 10A-9
Stop (Brake) Lamp Switch Removal and
Installation. . . . . . . . . . . . . ...10A-9
Stop (Brake) Lamp Switch Inspection . . . ...10A-9
ECM Removal and Installation. . . . . . ..10A-9
Specifications. . . . . . . . . . . . . .10A-9
Tightening Torque Specifications. . . . . ..10A-9
Body Electrical Control System . . ... 10B-1
Precautions. . . . . . . . . . . . . . .10B-1
Precautions in Diagnosing Trouble . . . . ...10B-1
General Description . . . . . . . . . . ...10B-1
BCM General Description . . . . . . . . . 10B-1
CAN Communication System Description for
BCM . . . . . . . . . . . . . . . . 10B-1
Theft Deterrent Light Description . . . . . ..10B-2
Schematic and Routing Diagram. . . . . ..10B-3
Body Electrical Control System Wiring Circuit
Diagram . . . . . . . . . . . . . . ..10B-3
Connector Layout Diagram of BCM . . . . ..10B-4
Component Location . . . . . . . . . . .10B-5
BCM and Related System Component
Location. . . . . . . . . . . . . . ...10B-5
Diagnostic Information and Procedures. . ..10B-6
BCM Self-Diagnosis Function . . . . . . ...10B-6
Body Electrical Control System Check. . . ..10B-8
Scan Tool Data . . . . . . . . . . . ...10B-10
DTC Table. . . . . . . . . . . . . ...10B-11
DTC Check. . . . . . . . . . . . . ..10B-12
DTC Clearance . . . . . . . . . . . ...10B-13
BCM Power Circuit and Ground Circuit Check 10B-14
DTC B1133 (No. 1133): Battery Voltage Too
High. . . . . . . . . . . . . . . ...10B-15
DTC B1141 / B1142 / B1143 (No. 1141 / No.
1142/ No. 1143): Outside Air Temperature
(Ambient Temp.) Sensor Circuit Malfunction 10B-16
Communication Circuit Malfunction. . . ...10B-17
DTC B1157 (No. 1157): Air Bag Deployment
Signal Input . . . . . . . . . . . . ...10B-19
DTC B1170 (No. 1170): EEPROM access
error. . . . . . . . . . . . . . . ...10B-19
DTC U1073 (No. 1073): Control Module
Communication Bus Off . . . . . . . . 10B-20
DTC U1100 (No. 1100): Lost Communication
with ECM. . . . . . . . . . . . . ...10B-23
DTC U1101 (No. 1101): Lost communication
with TCM . . . . . . . . . . . . . ...10B-25
DTC U1144 (No. 1144): Lost Communication
with Keyless Start Control Module . . . . 10B-27
Inspection of BCM and its Circuits . . . . ..10B-29
Repair Instructions . . . . . . . . . . ..10B-35
BCM Removal and Installation. . . . . . 10B-35
Outside Air Temperature Sensor Removal
and Installation . . . . . . . . . . . ..10B-35
Outside Air Temperature Sensor Inspection ...10B-36
DRL Function Setting Procedure . . . . . 10B-36
Special Tools and Equipment . . . . . . .10B-36
Special Tool . . . . . . . . . . . . . 10B-36
Immobilizer Control System . . . . . 10C-1
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст