Toyota Yaris Hatchback (2020 year). Manual in english — part 7
396
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
After replacing the engine oil, have a repair shop such as your Toyota
dealer perform the initialization (engine oil data resetting) of the
recorded value. If the value recorded by the computer is not initialized,
the wrench indicator light may not turn off or it may turn on earlier than
normal.
●
This procedure is intended for vehicles with the engine oil flexible mainte-
nance setting selected.
●
The initialization (engine oil data resetting) of the recorded value can be per-
formed using the following procedure:
Switch the ignition OFF.
Vehicle Engine Control Unit Reset Procedure
Switch the ignition ON with the selec-
tor pressed and continue pressing the
selector for about 5 seconds until the
master warning light
flashes.
After the master warning light
flashes for several seconds, the ini-
tialization is completed.
1
2
3
Selector
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
397
5
Mainten
Be sure the vehicle is on a level surface.
Warm up the engine to normal operating temperature.
Turn it off and wait at least 5 minutes for the oil to return to the oil
pan.
Pull out the dipstick, wipe it
clean, and reinsert it fully.
Full
OK
Low
Pull it out again and examine the level. The level is normal if it is
between Low and Full.
If it is near or below Low, add enough oil to bring the level to Full.
Make sure the O-ring on the dipstick is positioned properly before
reinserting the dipstick.
Reinsert the dipstick fully.
Inspecting Engine Oil Level
1
2
3
4
1
2
3
NOTICE
Do not overfill the engine oil. This may cause engine damage.
5
6
7
-------------------------------------------------------------------------------------------------------------------------------------------------------------
398
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Engine Coolant
Inspect the antifreeze protection and coolant level in the coolant res-
ervoir at least once a year—at the beginning of the winter season—
and before traveling where temperatures may drop below freezing.
Inspect the condition and connections of all cooling system and
heater hoses.
Replace any that are swollen or deteriorated.
The coolant should be at full in the
radiator and between the F and L
marks on the coolant reservoir
when the engine is cool.
Cooling fan
Cooling system cap
Coolant reservoir
If it is at or near L, add enough coolant to the coolant reservoir to pro-
vide freezing and corrosion protection and to bring the level to F.
Securely tighten the coolant reservoir tank cap after adding coolant.
If the coolant reservoir is empty or new coolant is required frequently,
consult your Toyota dealer.
Changing the coolant should be done by your Toyota dealer.
Inspecting Coolant Level
1
2
3
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
399
5
Mainten
WARNING
■
Do not use a match or live flame in the engine compartment. DO NOT
ADD COOLANT WHEN THE ENGINE IS HOT
A hot engine is dangerous. If the engine has been running, parts of the
engine compartment can become very hot. You could be burned. Carefully
inspect the engine coolant in the coolant reservoir, but do not open it.
■
Pull over to a safe location, then switch the ignition to off and
make sure the fan is not running before attempting to work near the
cooling fan
Working near the cooling fan when it is running is dangerous. The fan could
continue running indefinitely even if the engine has stopped and the engine
compartment temperature is high. You could be hit by the fan and seriously
injured.
■
Do not remove either cooling system cap when the engine and
radiator are hot
When the engine and radiator are hot, scalding coolant and steam may
shoot out under pressure and cause serious injury.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
400
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
NOTICE
●
Radiator coolant will damage paint. Rinse it off quickly if spilled.
●
Use only soft (deionized) water in the coolant mixture. Water that contains
minerals will cut down on the coolant’s effectiveness.
●
Do not add only water. Always add a proper coolant mixture.
●
The engine has aluminum parts and must be protected by an ethylene-gly-
col-based coolant to prevent corrosion and freezing.
●
DO NOT USE coolants Containing Alcohol, methanol, Borate or Silicate.
These coolants could damage the cooling system.
●
DO NOT MIX alcohol or methanol with the coolant. This could damage the
cooling system.
●
Do not use a solution that contains more than 60% antifreeze.
This would reduce effectiveness.
●
Use of engine coolant specifically designed for the YARIS/YARIS HATCHBACK
is required when replacing engine coolant. Using engine coolant that is not spe-
cifically designed for this vehicle may cause serious damage to the engine and
cooling system. For questions on how to obtain this specially designed coolant,
contact your Toyota dealer.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
401
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5
Mainten
Brake/Clutch Fluid
The brakes and clutch draw fluid from the same reservoir.
Inspect the fluid level in the reser-
voir regularly. It should be kept
between the MAX and MIN lines.
The level normally drops with
accumulated distance, a condition
associated with wear of brake and
clutch linings. If it is excessively
low, have the brake/clutch system
inspected by your Toyota dealer.
Inspecting Brake/Clutch Fluid Level
WARNING
■
If the brake/clutch fluid level is low, have the brakes inspected
A low brake/clutch fluid level is dangerous.
A low level could indicate brake lining wear or a brake system leak which
could cause the brakes to fail and lead to an accident.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
402
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Window Washer Fluid
Inspect fluid level in the washer
fluid reservoir; add fluid if neces-
sary.
Use plain water if washer fluid is unavailable.
But use only washer fluid in cold weather to prevent it from freezing.
●
State or local regulations may restrict the use of volatile organic compounds
(VOCs), which are commonly used as anti-freeze agents in washer fluid. A
washer fluid with limited VOC content should be used only if it provides ade-
quate freeze resistance for all regions and climates in which the vehicle will
be operated.
●
Front and rear washer fluid is supplied from the same reservoir.
Inspecting Washer Fluid Level
E
WARNING
■
Use only windshield washer fluid or plain water in the reservoir
Using radiator antifreeze as washer fluid is dangerous. If sprayed on the
windshield, it will dirty the windshield, affect your visibility, and could result
in an accident.
■
Using Washer Fluid Without Anti-freeze Protection in Cold Weather
Operating your vehicle in temperatures below 40 °F (4 °C) using washer
fluid without anti-freeze protection is dangerous as it could cause impaired
windshield vision and result in an accident. In cold weather, always use
washer fluid with anti-freeze protection.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
403
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5
Mainten
Body Lubrication
All moving points of the body, such as door and hood hinges
and locks, should be lubricated each time the engine oil is
changed. Use a nonfreezing lubricant on locks during cold
weather.
Make sure the hood’s secondary latch keeps the hood from
opening when the primary latch is released.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
404
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Wiper Blades
Contamination of either the windshield or the blades with for-
eign matter can reduce wiper effectiveness. Common sources
are insects, tree sap, and hot wax treatments used by some
commercial car washes.
If the blades are not wiping properly, clean the window and
blades with a good cleaner or mild detergent; then rinse thor-
oughly with clean water. Repeat if necessary.
WARNING
When the wiper lever is in the AUTO position and the ignition is switched
ON, the wipers may move automatically in the following cases
●
If the windshield above the rain sensor is touched.
●
If the windshield above the rain sensor is wiped with a cloth.
●
If the windshield is struck with a hand or other object.
●
If the rain sensor is struck with a hand or other object from inside the vehi-
cle.
Be careful not to pinch hands or fingers as it may cause injury, or damage
the wipers. When washing or servicing the vehicle, make sure the wiper
lever is in the OFF position.
NOTICE
●
Hot waxes applied by automatic car washers have been known to affect
the wiper’s ability to clean windows.
●
To prevent damage to the wiper blades, do not use gasoline, kerosene,
paint thinner, or other solvents on or near them.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
405
5
Mainten
When the wipers no longer clean well, the blades are probably worn
or cracked.
Replace the wiper blades using the following procedure.
Raise the wiper arm and turn
the blade assembly to expose
the plastic locking clip.
Compress the clip and slide the
assembly downward; then lift it
off the arm.
Hold the end of the rubber and
pull until the tabs are free of the
metal support.
Metal support
Tab
Remove the metal stiffeners
from each blade rubber and
install them in the new blade.
Carefully insert the new blade
rubber. Then install the blade
assembly in the reverse order
of removal.
Install the blade so that the tabs
are toward the bottom of the wiper
arm.
Replacing Windshield Wiper Blades
Plastic locking clip
1
2
1
2
3
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
406
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
When the wiper no longer cleans well, the blade is probably worn or
cracked.
Replace it.
Remove the cover.
Remove the stopper and raise
the wiper arm.
Firmly rotate the wiper blade to
the right until it unlocks, then
remove the blade.
Pull down the blade rubber and
slide it out of the blade holder.
Replacing Rear Window Wiper Blade (5-Door)
1
Stopper
2
3
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
407
5
Mainten
Remove the metal stiffeners
from the blade rubber and
install them in the new blade.
Carefully insert the new blade
rubber. Then install the blade
assembly in the reverse order
of removal.
5
6
NOTICE
●
To prevent damage to the wiper arms and other components, do not try to
sweep the wiper arm by hand.
●
To prevent damage to the windshield let the wiper arm down easily, do not
let it slap down on the windshield.
●
To prevent damage to the rear window, do not let the wiper arm fall on it.
●
Do not bend or discard the stiffeners. You need to use them again.
●
If the metal stiffeners are switched, the blade’s wiping efficiency could be
reduced.
So don’t use the driver’s side metal stiffeners on the passenger’s side, or
vice versa.
●
Be sure to reinstall the metal stiffeners in the new blade rubber so that the
curve is the same as it was in the old blade rubber.
●
When raising both windshield wiper arms, raise the driver’s side wiper arm
first. When lowering the wiper arms, slowly lower the wiper arm from the
passenger’s side first while supporting it with your hand. Forcefully lower-
ing the wiper arms could damage the wiper arm and blade, and may
scratch or crack the windshield.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
408
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Battery
Before performing battery mainte-
nance, remove the battery cover
by pressing the tab.
Tab
WARNING
■
Wash hands after handling the battery and related accessories
Battery posts, terminals and related accessories contain lead and lead com-
pounds, chemicals known to the State of California to cause cancer and
reproductive harm.
■
Read the following precautions carefully before using the bat-
tery or inspecting to ensure safe and correct handling
■
Always wear eye protection when working near the battery
Working without eye protection is dangerous. Battery fluid contains SULFU-
RIC ACID which could cause blindness if splashed into your eyes. Also,
hydrogen gas produced during normal battery operation, could ignite and
cause the battery to explode.
■
Wear eye protection and protective gloves to prevent contact
with battery fluid
Spilled battery fluid is dangerous.
Battery fluid contains SULFURIC ACID which could cause serious injuries if
it gets in eyes, or on the skin or clothing. If this happens, immediately flush
your eyes with water for 15 minutes or wash your skin thoroughly and get
medical attention.
■
Always keep batteries out of the reach of children
Allowing children to play near batteries is dangerous. Battery fluid could
cause serious injuries if it gets in the eyes or on the skin.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
409
5
Mainten
To get the best service from a battery:
• Keep it securely mounted.
• Keep the top clean and dry.
• Keep terminals and connec-
tions clean, tight, and coated
with petroleum jelly or terminal
grease.
• Rinse off spilled electrolyte
immediately with a solution of
water and baking soda.
• If the vehicle will not be used for an extended time, disconnect the
battery cables and charge the battery every 6 weeks.
Contact your Toyota dealer for a battery replacement purchase.
WARNING
■
Keep flames and sparks away from open battery cells and do
not allow metal tools to contact the positive (+) or negative (-) terminal
of the battery when working near a battery. Do not allow the positive (+)
terminal to contact the vehicle body
Flames and sparks near open battery cells are dangerous. Hydrogen gas,
produced during normal battery operation, could ignite and cause the bat-
tery to explode. An exploding battery can cause serious burns and injuries.
Keep all flames including cigarettes and sparks away from open battery
cells.
■
Keep all flames and sparks away from open battery cells
because hydrogen gas is produced from open battery cells while
charging the battery or adding battery fluid:
Flames and sparks near open battery cells are dangerous. Hydrogen gas,
produced during normal battery operation, could ignite and cause the bat-
tery to explode. An exploding battery can cause serious burns and injuries.
Keep all flames including cigarettes and sparks away from open battery
cells.
Battery Maintenance
Battery Replacement
-------------------------------------------------------------------------------------------------------------------------------------------------------------
410
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Key Battery Replacement
If the buttons on the smart key are inoperable and the operation indi-
cator light does not flash, the battery may be dead.
Replace with a new battery before the smart key becomes unusable.
The following conditions indicate that the battery power is low:
• The KEY indicator light (green) flashes in the combination meter for
about 30 seconds after the engine is switched OFF.
• The system does not operate and the operation indicator light on
the smart key does not flash when the buttons are pressed.
• The system’s operational range is reduced.
Replacing the battery at your Toyota dealer is recommended to pre-
vent damage to the key. If replacing the battery by yourself, follow the
instruction below.
■
Replacing the key battery
Press the knob and pull out
the auxiliary key.
Twist a tape-wrapped flat-
head screwdriver in the
direction of the arrow and
open the cover slightly.
Knob
1
Cover
2
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
411
5
Mainten
Insert the tape-wrapped flat-
head screwdriver into the
gap and slide it in the direc-
tion of the arrow.
Twist the flathead screw-
driver in the direction of the
arrow and remove the cover.
Remove the battery cap,
then remove the battery.
Insert a new battery with the
positive pole facing up, and
then cover the battery with
the battery cap.
Cover
Gap
3
Cover
4
5
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
412
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Close the cover.
Reinsert the auxiliary key.
7
NOTICE
●
Make sure the battery is installed correctly. Battery leakage could occur if it
is not installed correctly.
●
When replacing the battery, be careful not to touch any of the internal cir-
cuitry and electrical terminals, bend the electrical terminals, or get dirt in
the smart key as the smart key could be damaged.
●
There is the danger of explosion if the battery is not correctly replaced.
●
Dispose of used batteries according to the following instructions.
• Insulate the plus and minus terminals of the battery using cellophane or
equivalent tape.
• Never disassemble.
• Never throw the battery into fire or water.
• Never deform or crush.
●
Replace only with the same type battery (CR2025 or equivalent).
8
●
Be careful not to allow the rubber ring
shown in the figure to be scratched or
damaged.
●
If the rubber ring detaches, reattach it
before inserting a new battery.
Rubber ring
-------------------------------------------------------------------------------------------------------------------------------------------------------------
413
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5
Mainten
Tires
Inspect all tire pressures monthly (including the spare) when the tires
are cold. Maintain recommended pressures for the best ride, han-
dling, and minimum tire wear.
Refer to the specification charts
(
)
.
With tire pressure monitoring system:
After adjusting the tire pressure, initialization of the tire pressure mon-
itoring system is necessary to make the system operate normally.
Refer to Tire Pressure Monitoring System Initialization on P. 244.
For reasons of proper performance, safety, and better fuel econ-
omy, always maintain recommended tire inflation pressures and
stay within the recommended load limits and weight distribu-
tion.
WARNING
■
Using Different Tire Types
Driving your vehicle with different types of tires is dangerous. It could
cause poor handling and poor braking; leading to loss of control.
Except for the limited use of the temporary spare tire, use only the same
type tires (radial, bias-belted, bias-type) on all four wheels.
■
Using Wrong-Sized Tires
Using any other tire size than what is specified for the vehicle (
is dangerous. It could seriously affect ride, handling, ground clearance,
tire clearance, and speedometer calibration. This could cause you to
have an accident. Use only tires that are the correct size specified for
the vehicle.
Tire Inflation Pressure
-------------------------------------------------------------------------------------------------------------------------------------------------------------
414
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
●
Always check tire pressure when tires are cold.
●
Warm tires normally exceed recommended pressures. Do not release
air from warm tires to adjust the pressure.
●
Underinflation can cause reduced fuel economy, uneven and acceler-
ated tire wear, and poor sealing of the tire bead, which will deform the
wheel and cause separation of tire from rim.
●
Overinflation can produce a harsh ride, uneven and accelerated tire
wear, and a greater possibility of damage from road hazards.
Keep your tire pressure at the correct levels. If one frequently needs
inflating, have it inspected.
During rotation, inspect them for
correct balance.
WARNING
■
Always inflate the tires to the correct pressure
Overinflation or underinflation of tires is dangerous. Adverse handling or
unexpected tire failure could result in a serious accident.
Refer to Tires on (
■
Use only a Toyota-genuine tire valve cap
Use of a non-genuine part is dangerous as the correct tire air pressure
cannot be maintained if the tire valve becomes damaged. If the vehicle
is driven under this condition, the tire air pressure will decrease which
could result in a serious accident. Do not use any part for the tire valve
cap that is not a Toyota-genuine part.
Tire Rotation
Forward
Do not include
(TEMPORARY USE ONLY)
spare tire in rotation.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
415
5
Mainten
Also, inspect them for uneven wear and damage. Abnormal wear is
usually caused by one or a combination of the following:
• Incorrect tire pressure
• Improper wheel alignment
• Out-of-balance wheel
• Severe braking
After rotation, inflate all tire pressures to specification (
P. 553) and
inspect the lug nuts for tightness.
With tire pressure monitoring system:
After adjusting the tire pressure, initialization of the tire pressure mon-
itoring system is necessary to make the system operate normally.
Refer to Tire Pressure Monitoring System Initialization on P. 244.
WARNING
■
Rotate tires periodically
Irregular tire wear is dangerous. To equalize tire wear and extend tire
life, Toyota recommends that tire rotation is carried out at the same
interval as tire inspection.
For scheduled maintenance information, please refer to the “Owner’s
Manual Supplement/Scheduled Maintenance Guide”.
NOTICE
Rotate unidirectional tires and radial tires that have an asymmetrical
tread pattern or studs only from front to rear, not from side to side. Tire
performance will be reduced if rotated from side to side.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
416
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
If a tire wears evenly, a wear indicator will appear as a solid band
across the tread.
Replace the tire when this happens.
New tread
Worn tread
Tread wear indicator
You should replace the tire before the band crosses the entire tread.
With tire pressure monitoring system:
After adjusting the tire pressure, initialization of the tire pressure mon-
itoring system is necessary to make the system operate normally.
Refer to Tire Pressure Monitoring System Initialization on P. 244.
Tires degrade over time, even when they are not being used on the road.
It is recommended that tires generally be replaced when they are 6 years
or older. Heat caused by hot climates or frequent high loading conditions
can accelerate the aging process. You should replace the spare tire when
you replace the other road tires due to the aging of the spare tire. The
period in which the tire was manufactured (both week and year) is indi-
cated by a 4-digit number.
Refer to Tire Labeling on P. 522.
Replacing a Tire
1
2
3
WARNING
■
Always use tires that are in good condition
Driving with worn tires is dangerous. Reduced braking, steering, and
traction could result in an accident.
■
Replace all four tires at the same time
Replacing just one tire is dangerous. It could cause poor handling and
poor braking resulting in loss of vehicle control. Toyota strongly recom-
mends that you replace all four tires at the same time. If you replace
only two tires, the new tires should be installed on the rear of the vehi-
cle.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
417
5
Mainten
Inspect the temporary spare tire at least monthly to make sure it is
properly inflated and stored.
The temporary spare tire is easier to handle because of its construc-
tion which is lighter and smaller than a conventional tire. This tire
should be used only for an emergency and only for a short distance.
Use the temporary spare tire only until the conventional tire is
repaired, which should be as soon as possible.
Refer to Tires on P. 553.
●
The temporary spare tire condition gradually deteriorates even if it has
not been used.
●
Tires degrade over time, even when they are not being used on the
road. It is recommended that tires generally be replaced when they are
6 years or older. Heat caused by hot climates or frequent high loading
conditions can accelerate the aging process. You should replace the
spare tire when you replace the other road tires due to the aging of the
spare tire. The period in which the tire was manufactured (both week
and year) is indicated by a 4-digit number.
Refer to Tire Labeling on P. 522.
Proper tire balancing provides the best riding comfort and helps
reduce tread wear. Out-of-balance tires can cause vibration and
uneven wear, such as cupping and flat spots.
When replacing a wheel, make sure the new one is the same as the orig-
inal factory wheel in diameter, rim width, and offset (inset/outset).
For details, contact your Toyota dealer.
Temporary Spare Tire
NOTICE
●
Do not use your temporary spare tire rim with a snow tire or a conven-
tional tire. Neither will properly fit and could damage both tire and rim.
●
The temporary spare tire has a tread life of less than 3,000 miles
(5,000 km). The tread life may be shorter depending on driving condi-
tions.
●
The temporary spare tire is for limited use, however, if the tread wear
solid-band indicator appears, replace the tire with the same type of
temporary spare (
Replacing a Wheel
-------------------------------------------------------------------------------------------------------------------------------------------------------------
418
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
WARNING
■
Always use wheels of the correct size on your vehicle
Using a wrong-sized wheel is dangerous. Braking and handling could
be affected, leading to loss of control and an accident.
NOTICE
A wrong-sized wheel may adversely affect:
●
Tire fit
●
Wheel and bearing life
●
Ground clearance
●
Snow-chain clearance
●
Speedometer calibration
●
Headlight aim
●
Bumper height
●
Tire Pressure Monitoring System (if equipped)
-------------------------------------------------------------------------------------------------------------------------------------------------------------
419
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5
Mainten
Light Bulbs
■
Front
With Halogen Headlights
Headlights (Low/High beam)/
Daytime running lights
Front side-marker lights
Overhead lights/Map lights
Side turn signal lights (if
equipped)
Front turn signal lights/Park-
ing lights
Fog lights (if equipped)
With LED Headlights
Headlights (High beam)
Headlights (Low beam)
Front side-marker lights
Overhead lights/Map lights
Side turn signal lights (if
equipped)
Front turn signal lights/Park-
ing lights
Daytime running light/Park-
ing light
Fog lights
1
2
3
4
5
6
1
2
3
4
5
6
7
8
-------------------------------------------------------------------------------------------------------------------------------------------------------------
420
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Rear
4-Door
Trunk light
High-mount brake lights
License plate lights
Reverse lights
Rear turn signal lights
Brake
lights/Taillights/Rear
side-marker lights
5-Door
High-mount brake light
License plate lights
Reverse lights
Rear turn signal lights
Brake lights/Tail lights
Rear side-marker lights
Luggage compartment light
●
To replace the bulb, contact your Toyota dealer.
●
If the halogen bulb is accidentally touched, it should be cleaned with rubbing
alcohol before being used.
●
Use the protective cover and carton of the replacement bulb to dispose of
the old bulb promptly out of the reach of children.
1
2
3
4
5
6
1
2
3
4
5
6
7
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
421
5
Mainten
WARNING
■
Never touch the glass portion of a halogen bulb with your bare hands
and always wear eye protection when handling or working around the
bulbs
When a halogen bulb breaks, it is dangerous. These bulbs contain pressur-
ized gas. If one is broken, it will explode and serious injuries could be
caused by the flying glass.
If the glass portion is touched with bare hands, body oil could cause the
bulb to overheat and explode when lit.
■
Always keep halogen bulbs out of the reach of children
Playing with a halogen bulb is dangerous. Serious injuries could be caused
by dropping a halogen bulb or breaking it some other way.
NOTICE
When removing the lens or lamp unit using a flathead screwdriver, make
sure that the flathead screwdriver does not contact the interior terminal. If
the flathead screwdriver contacts the terminal, a short circuit may occur.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
422
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Headlights/Daytime running lights (With halogen headlights)
Make sure the ignition is switched off, and the headlight switch is
off.
Lift the hood.
Disconnect the connector
from the bulb.
Detach the sealing cover
from the bulb.
Retaining spring
Sealing cover
Unhook the bulb retaining spring.
Swing the retaining spring out and away to free the headlight
bulb.
Carefully remove the headlight bulb from the socket by pulling it
straight back.
Replace the bulb.
Install the new bulb in the reverse order of the removal proce-
dure.
Replacing Exterior Light Bulbs
1
2
3
4
1
2
5
6
7
8
9
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
423
5
Mainten
■
Front turn signal lights/Parking lights, Front side-marker lights
Make sure the ignition is switched off, and the headlight switch is
off.
Lift the hood.
Front turn signal lights/Park-
ing lights: Remove the fuse
block cover.
Turn the socket and bulb assembly counterclockwise and
remove it.
Disconnect the bulb from the socket.
Install the new bulb in the reverse order of the removal proce-
dure.
1
2
3
4
5
Front turn signal lights/Parking
lights
Front side-marker lights
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
424
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Fog lights (if equipped)
Make sure the ignition is switched off, and the fog light switch is
off.
Turn the screws counter-
clockwise and remove them.
Pull the center of each retain-
ers and remove them, and
then partially peel back the
front under cover.
Removal
Installation
Disconnect the connector
from the unit by pressing the
tab on the connector with
your finger and pulling the
connector downward.
1
2
3
1
2
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
425
5
Mainten
Turn the socket and bulb
assembly to remove it. Care-
fully remove the bulb from its
socket in the reflector by
gently pulling it straight back-
ward out of the socket.
Install the new bulb in the reverse order of the removal proce-
dure.
5
6
-------------------------------------------------------------------------------------------------------------------------------------------------------------
426
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Rear turn signal lights, Brake lights/Taillights/Rear side-marker
lights
4-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Remove the cover.
Turn the socket and bulb assembly counterclockwise and
remove it.
Disconnect the bulb from the socket.
1
2
3
4
Rear turn signal lights:
Brake lights/Taillights/Rear side-
marker lights:
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
427
5
Mainten
Install the new bulb in the reverse order of the removal proce-
dure.
Insert the cover tabs and install the cover.
Verify that the cover is securely installed.
5-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Turn the bolts counterclock-
wise and remove them.
Pull the unit rearward to
remove it.
Turn the socket and bulb assembly counterclockwise and
remove it.
Disconnect the bulb from the socket.
5
6
1
2
3
4
5
Rear turn signal lights:
Brake lights/Taillights:
-------------------------------------------------------------------------------------------------------------------------------------------------------------
428
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Install the new bulb in the reverse order of the removal proce-
dure.
■
Reverse lights
4-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Pull the center of each plastic
retainers and remove them.
Removal
Installation
Remove the trunk lid trim.
Disconnect the electrical
connector from the bulb by
pressing the tab on the con-
nector with your finger and
pulling the connector.
Rear side-marker lights:
6
1
2
1
2
3
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
429
5
Mainten
Turn the socket and bulb
assembly counterclockwise
and remove it.
Disconnect the bulb from the
socket.
Install the new bulb in the reverse order of the removal proce-
dure.
5-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Pull the center of each plastic
retainer and remove the
retainers.
Removal
Installation
Remove the trunk lid trim.
Disconnect the connector
from the socket.
5
6
7
1
2
1
2
3
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
430
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Turn the socket and bulb
assembly counterclockwise
and remove it.
Disconnect the bulb from the
socket.
Install the new bulb in the reverse order of the removal proce-
dure.
5
6
7
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
431
5
Mainten
■
License plate lights
4-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Pull the center of each plastic
retainers and remove them.
Removal
Installation
Peel back the trunk lid trim.
Turn the socket and bulb
assembly counterclockwise
and remove it.
Disconnect the bulb from the
socket.
Install the new bulb in the reverse order of the removal proce-
dure.
5-Door
Make sure the ignition is switched off, and the headlight switch is
off.
Wrap a flathead screwdriver with a soft cloth to prevent damage
to the light unit.
Insert a flathead screwdriver
into the position shown in the
figure and pull the light unit
outward.
1
2
1
2
3
4
5
6
1
2
3
-------------------------------------------------------------------------------------------------------------------------------------------------------------
432
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Disconnect the connector
from the bulb by pressing the
tab on the connector with
your finger and pulling the
connector.
Turn the socket and bulb
assembly counterclockwise
and remove it.
Disconnect the bulb from the
socket.
Install the new bulb in the reverse order of the removal proce-
dure.
■
Headlights/Daytime running lights (With LED headlights), Side
turn signal lights (if equipped), High-mount brake light
The LED bulb cannot be replaced as a single unit because it is an
integrated unit. The LED bulb has to be replaced with the unit. We
recommend your Toyota dealer when the replacement is necessary.
■
Headlights/Daytime running lights
●
To replace the bulb, contact your Toyota dealer.
●
If the halogen bulb is accidentally touched, it should be cleaned with rubbing
alcohol before being used.
●
Use the protective cover and carton of the replacement bulb to dispose of
the old bulb promptly out of the reach of children.
●
When reinstalling the sealing cover, make sure it is fitted correctly.
4
5
6
7
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
433
5
Mainten
■
Overhead lights/Map lights
Wrap a small flathead screw-
driver with a soft cloth to pre-
vent damage to the lens, and
then remove the lens by
carefully prying on the edge
of the lens with the flathead
screwdriver.
Disconnect the bulb by pull-
ing it out.
Install the new bulb in the reverse order of the removal proce-
dure.
Replacing Interior Light Bulbs
1
2
3
-------------------------------------------------------------------------------------------------------------------------------------------------------------
434
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Trunk light (4-Door)
Press both sides of the lens
cap to remove it.
Disconnect the bulb by pull-
ing it out.
Install the new bulb in the reverse order of the removal proce-
dure.
■
Luggage compartment light (5-Door)
Wrap a small flathead screw-
driver with a soft cloth to pre-
vent damage to the lens and
remove the lens by carefully
prying on the edge of the
lens with the flathead screw-
driver.
Disconnect the bulb by pull-
ing it out.
Install the new bulb in the reverse order of the removal proce-
dure.
1
2
3
1
2
3
-------------------------------------------------------------------------------------------------------------------------------------------------------------
435
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5
Mainten
Fuses
■
Replacing the fuses on the vehicle’s left side
If the electrical system does not work, first inspect the fuses on the
vehicle’s left side.
Make sure the ignition is switched off, and other switches are off.
Open the fuse panel cover.
Pull the fuse straight out with
the fuse puller provided on
the fuse block located in the
engine compartment.
Your vehicle’s electrical system is protected by fuses.
If any lights, accessories, or controls do not work, inspect the
appropriate circuit protector. If a fuse has blown, the inside ele-
ment will be melted.
If the same fuse blows again, avoid using that system and con-
sult your Toyota dealer as soon as possible.
Fuse Replacement
1
2
3
-------------------------------------------------------------------------------------------------------------------------------------------------------------
436
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Inspect the fuse and replace
it if it is blown.
Normal
Blown
Insert a new fuse of the same amperage rating, and make sure it
fits tightly. If it does not fit tightly, have an expert install it. We rec-
ommend your Toyota dealer.
If you have no spare fuses, borrow one of the same rating from a
circuit not essential to vehicle operation, such as the AUDIO or
OUTLET circuit.
Reinstall the cover and make sure that it is securely installed.
■
Replacing the fuses under the hood
If the headlights or other electrical components do not work and the
fuses in the cabin are normal, inspect the fuse block under the
hood.
If a fuse is blown, it must be replaced.
Follow these steps:
Make sure the ignition is switched off, and other switches are off.
Remove the fuse block
cover.
4
1
2
5
6
1
2
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
437
5
Mainten
If any fuse but the MAIN fuse
is blown, replace it with a
new one of the same amper-
age rating.
Normal
Blown
Reinstall the cover and make sure that it is securely installed.
3
1
2
WARNING
■
Do not replace the main fuse and multiplex slow blow fuse by yourself.
Have your Toyota dealer perform the replacement
Replacing these fuses by yourself is dangerous because they are high cur-
rent fuses. Incorrect replacement could cause an electrical shock or a short
circuit resulting in a fire.
NOTICE
Always replace a fuse with a genuine Toyota fuse or equivalent of the same
rating. Otherwise you may damage the electric system.
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
438
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Fuse block (Engine compartment)
Fuse Panel Description
DESCRIPTION
FUSE
RATING
PROTECTED COMPONENT
1
C/U IG1
15 A
For protection of various circuits
2
ENGINE IG1
7.5 A
Engine control system
3
SUNROOF
10 A
—
4
INTERIOR
15 A
For protection of various circuits
5
ENG+B
7.5 A
Engine control system
6
AUDIO2
ENGINE4
15 A
Engine control system
7
METER1
10 A
Combination meter
8
SRS1
7.5 A
Air bag
9
METER2
7.5 A
—
10
RADIO
7.5 A
Audio system
11
ENGINE3
15 A
Engine control system
12
ENGINE1
15 A
—
13
ENGINE2
15 A
Engine control system
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
439
5
Mainten
14
AUDIO1
25 A
Audio system
15
A/C MAG
7.5 A
Air conditioner
16
AT PUMP
15 A
—
17
AT
15 A
Transaxle control system (if equipped),
Ignition switch
18
D.LOCK
25 A
Power door locks
19
H/L RH
20 A
Headlight (RH)
20
ENG+B2
7.5 A
Engine control system
21
TAIL
20 A
Taillights, License plate lights, Parking
lights
22
ST.HEATER
20 A
Heated steering wheel (if equipped)
23
ROOM
25 A
For protection of various circuits
24
FOG
15 A
Fog lights (if equipped)
25
H/CLEAN
20 A
—
26
STOP
10 A
Brake lights
27
HORN
15 A
Horn
28
H/L LH
20 A
Headlight (LH)
29
ABS/DSC S
30 A
ABS, Dynamic stability control system
30
HAZARD
15 A
Hazard warning flashers, Turn signal lights
31
FUEL PUMP
SCR
15 A
Fuel system
32 FUEL WARM
25 A
—
33
WIPER
20 A
Windshield wipers
34
CABIN+B
50 A
For protection of various circuits
35
FAN2
EPB L
30 A
Cooling fan
36
FUEL PUMP
30 A
—
37
ABS/DSC M
50 A
ABS, Dynamic stability control system
38
EVVT
20 A
—
39
—
—
—
DESCRIPTION
FUSE
RATING
PROTECTED COMPONENT
-------------------------------------------------------------------------------------------------------------------------------------------------------------
440
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
40
FAN1
EPB R
30 A
Cooling fan
41
FAN3
40 A
—
42
ENG.MAIN
40 A
Engine control system
43
EPS
60 A
—
44
DEFOG
40 A
Rear window defogger
45
IG2
30 A
For protection of various circuits
46
INJECTOR
ENG.SUB
30 A
Engine control system
47
HEATER
40 A
Air conditioner
48
P.WINDOW1
30 A
Power windows
49
DCDC DE
40 A
—
DESCRIPTION
FUSE
RATING
PROTECTED COMPONENT
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
441
5
Mainten
■
Fuse block (Left side)
DESCRIPTION
FUSE
RATING
PROTECTED COMPONENT
1
—
—
—
2
—
—
—
3
AUDIO2
15 A
Audio system
4
ST.HEATER
10 A
Heated steering wheel (if equipped)
5
F.OUTLET
15 A
Accessory sockets
6
—
—
—
7
AT IND
7.5 A
AT shift indicator (if equipped)
8
MIRROR
7.5 A
Power control mirror
9
—
—
—
10
P.WINDOW2
25 A
Power windows
11
R.WIPER
15 A
Rear window wiper
12
—
—
—
13
—
—
—
14
SRS2/ESCL
15 A
—
15 SEAT WARM
20 A
Seat warmer (if equipped)
16
M.DEF
7.5 A
Mirror defogger (if equipped)
-------------------------------------------------------------------------------------------------------------------------------------------------------------
442
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Exterior Care
■
Etching Caused by Acid Rain or Industrial Fallout
●
Occurrence
Industrial pollutants and vehicle emissions drift into the air and
mix with rain or dew to form acids. These acids can settle on a
vehicle’s finish. As the water evaporates, the acid becomes con-
centrated and can damage the finish.
And the longer the acid remains on the surface, the greater the
chance is for damage.
●
Prevention
It is necessary to wash and wax your vehicle to preserve its finish
according to the instructions in this section. These steps should
be taken immediately after you suspect that acid rain has settled
on your vehicle’s finish.
■
Damage Caused by Bird Dropping, Insects, or Tree Sap
●
Occurrence
Bird droppings contain acids. If these are not removed they can
eat away the clear and color base coat of the vehicle’s paintwork.
When insects stick to the paint surface and decompose, corro-
sive compounds form.
These can erode the clear and color base coat of the vehicle’s
paintwork if they are not removed.
Tree sap will harden and adhere permanently to the paint finish.
If you scratch the sap off while it is hard, some vehicle paint could
come off with it.
The paintwork on your Toyota represents the latest technical
developments in composition and methods of application.
Environmental hazards, however, can harm the paint’s protec-
tive properties, if proper care is not taken.
Here are some examples of possible damage, with tips on how
to prevent them.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
443
5
Mainten
●
Prevention
It is necessary to have your Toyota washed and waxed to pre-
serve its finish according to the instructions in this section. This
should be done as soon as possible.
Bird droppings can be removed with a soft sponge and water. If
you are traveling and these are not available, a moistened tissue
may also take care of the problem. The cleaned area should be
waxed according to the instructions in this section.
Insects and tree sap are best removed with a soft sponge and
water or a commercially available chemical cleaner.
Another method is to cover the affected area with dampened
newspaper for 1 to 2 hours. After removing the newspaper, rinse
off the loosened debris with water.
■
Water Marks
●
Occurrence
Rain, fog, dew, and even tap water can contain harmful minerals
such as salt and lime. If moisture containing these minerals set-
tles on the vehicle and evaporates, the minerals will concentrate
and harden to form white rings. The rings can damage your vehi-
cle’s finish.
●
Prevention
It is necessary to wash and wax your vehicle to preserve its finish
according to the instructions in this section. These steps should
be taken immediately after you find water marks on your vehi-
cle’s finish.
■
Paint Chipping
●
Occurrence
Paint chipping occurs when gravel thrown in the air by another
vehicle’s tires hits your vehicle.
●
How to avoid paint chipping
Keeping a safe distance between you and the vehicle ahead
reduces the chances of having your paint chipped by flying
gravel.
Follow all label and container directions when using a chemical
cleaner or polish. Read all warnings and cautions.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
444
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Paint Chipping
●
The paint chipping zone varies with the speed of the vehicle. For example,
when traveling at 56 mph (90 km/h), the paint chipping zone is 164 ft.
(50 m).
●
In low temperatures a vehicle’s finish hardens. This increases the chance of
paint chipping.
●
Chipped paint can lead to rust forming on your Toyota. Before this happens,
repair the damage by using Toyota touch-up paint according to the instruc-
tions in this section. Failure to repair the affected area could lead to serious
rusting and expensive repairs.
■
Washing
To help protect the finish from rust and deterioration, wash your
Toyota thoroughly and frequently, at least once a month, with luke-
warm or cold water.
If the vehicle is washed improperly, the paint surface could be
scratched. Here are some examples of how scratching could occur.
Scratches occur on the paint surface when:
• The vehicle is washed without first rinsing off dirt and other for-
eign matter.
• The vehicle is washed with a rough, dry, or dirty cloth.
• The vehicle is washed at a car wash that uses brushes that are
dirty or too stiff.
• Cleansers or wax containing abrasives are used.
To minimize scratches on the vehicle’s paint finish:
• Rinse off any dirt or other foreign matter using lukewarm or cold
water before washing.
• Use plenty of lukewarm or cold water and a soft cloth when
washing the vehicle. Do not use a nylon cloth.
• Rub gently when washing or drying the vehicle.
• Take your vehicle only to a car wash that keeps its brushes well
maintained.
• Do not use abrasive cleansers or wax that contain abrasives.
Pay special attention to removing salt, dirt, mud, and other foreign
material from the underside of the fenders, and make sure the drain
holes in the lower edges of the doors and rocker panels are clean.
Maintaining the Finish
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
445
5
Mainten
Insects, tar, tree sap, bird droppings, industrial fallout, and similar
deposits can damage the finish if not removed immediately. When
prompt washing with plain water is ineffective, use a mild soap
made for use on vehicles.
Thoroughly rinse off all soap with lukewarm or cold water. Do not
allow soap to dry on the finish.
After washing the vehicle, dry it with a clean chamois to prevent
water spots from forming.
●
When using an automatic car wash
• Retract the door mirrors.
• The automatic car wash brushes could reduce the paint luster
or hasten paint deterioration.
●
When using a high water pressure car wash
High water temperature and high water pressure car washers are
available depending on the type of car wash machine. If the car
washer nozzle is put too close to the vehicle, the force of the
spray could damage or deform the molding, affect the sealability
of parts, and allow water to penetrate the interior. Keep a suffi-
cient space (12 in. (300 mm) or more) between the nozzle and
the vehicle. In addition, do not spend too much time spraying the
same area of the vehicle, and be very careful when spraying
between gaps in doors and around windows.
■
Waxing
Your vehicle needs to be waxed when water no longer beads on the
finish. Always wash and dry the vehicle before waxing it. In addition
to the vehicle body, wax the metal trim to maintain its luster.
Use wax which contains no abrasives. Waxes containing abra-
sive will remove paint and could damage bright metal parts.
Use a good grade of natural wax for metallic, mica, and solid col-
ors.
When waxing, coat evenly with the sponge supplied or a soft
cloth.
Wipe off the wax with a soft cloth.
1
2
3
4
-------------------------------------------------------------------------------------------------------------------------------------------------------------
446
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Washing
●
Toyota is not responsible for scratches caused by automatic car washes or
improper washing.
●
Scratches are more noticeable on vehicles with darker paint finishes.
■
Waxing
A spot remover to remove oil, tar, and similar materials will usually also take
off the wax. Rewax these areas even if the rest of the vehicle does not need
it.
WARNING
■
Dry off brakes that have become wet by driving slowly, releasing the
accelerator pedal and lightly applying the brakes several times until
the brake performance returns to normal
Driving with wet brakes is dangerous. Increased stopping distance or the
vehicle pulling to one side when braking could result in a serious accident.
Light braking will indicate whether the brakes have been affected.
NOTICE
●
When the wiper lever is in the AUTO position and the ignition is switched
ON, the wipers may move automatically in the following cases:
• If the windshield above the rain sensor is touched or wiped with a cloth.
• If the windshield is struck with a hand or other object from either outside
or inside the vehicle.
Keep hands and scrapers clear of the windshield when the wiper lever is
in the AUTO position and the ignition is switched ON as fingers could be
pinched or the wipers and wiper blades damaged when the wipers acti-
vate automatically.
If you are going to clean the windshield, be sure the wipers are turned off
completely (when it is most likely that the engine is left running) this is par-
ticularly important when clearing ice and snow.
●
Do not spray water in the engine compartment. Otherwise, it could result in
engine-starting problems or damage to electrical parts.
●
When washing and waxing the vehicle, be careful not to apply excessive
force to any single area of the vehicle roof or the antenna. Otherwise, you
could dent the vehicle or damage the antenna.
●
Do not use steel wool, abrasive cleaners, or strong detergents containing
highly alkaline or caustic agents on chrome-plated or anodized aluminum
parts. This may damage the protective coating; also, cleaners and deter-
gents may discolor or deteriorate the paint.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
447
5
Mainten
Deep scratches or chips on the finish should be repaired promptly.
Exposed metal quickly rusts and can lead to major repairs.
• Use tar remover to remove road tar and insects. Never do this with
a knife or similar tool.
• To prevent corrosion on bright-metal surfaces, apply wax or chrome
preservative and rub it to a high luster.
• During cold weather or in coastal areas, cover bright-metal parts
with a coating of wax or preservative heavier than usual. It would
also help to coat them with noncorrosive petroleum jelly or some
other protective compound.
Repairing Damage to the Finish
NOTICE
If your Toyota is damaged and needs metal parts repaired or replaced,
make sure the body shop applies anti-corrosion materials to all parts, both
repaired and new. This will prevent them from rusting.
Bright-Metal Maintenance
NOTICE
Do not use steel wool, abrasive cleaners, or strong detergents containing
highly alkaline or caustic agents on chrome-plated or anodized aluminum
parts. This may result in damage to the protective coating and cause discol-
oration or paint deterioration.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
448
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Road chemicals and salt used for ice and snow removal and solvents
used for dust control may collect on the underbody. If not removed,
they will speed up rusting and deterioration of such underbody parts
as fuel lines, frame, floor pan, and exhaust system, even though these
parts may be coated with anti-corrosive material.
Thoroughly flush the underbody and wheel housings with lukewarm or
cold water at the end of each winter. Try also to do this every month.
Pay special attention to these areas because they easily hide mud
and dirt. It will do more harm than good to wet down the road grime
without removing it.
The lower edges of doors, rocker panels, and frame members have
drain holes that should not be clogged. Water trapped there will cause
rusting.
A protective coating is provided over the aluminum wheels. Special
care is needed to protect this coating.
Underbody Maintenance
WARNING
■
Dry off brakes that have become wet by driving slowly, releasing the
accelerator pedal and lightly applying the brakes several times until
the brake performance returns to normal
Driving with wet brakes is dangerous. Increased stopping distance or the
vehicle pulling to one side when braking could result in a serious accident.
Light braking will indicate whether the brakes have been affected.
Aluminum Wheel Maintenance (if equipped)
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
449
5
Mainten
• When cleaning the plastic lenses of the lights, do not use gasoline,
kerosene, rectified spirit, paint, thinner, highly acidic detergents, or
strongly alkaline detergents. Otherwise, these chemical agents can
discolor or damage the surfaces resulting in a significant loss in
functionality. If plastic parts become inadvertently exposed to any of
these chemical agents, flush with water immediately.
• If plastic parts such as the bumpers become inadvertently exposed
to chemical agents or fluids such as gasoline, oil, engine coolant, or
battery fluid, it could cause discoloration, staining, or paint peeling.
Wipe off any such chemical agents or fluids using a soft cloth imme-
diately.
• High water temperature and high water pressure car washers are
available depending on the type of high pressure car washer
device. If the car washer nozzle is put too close to the vehicle or
aimed at one area for an extended period of time, it could deform
plastic parts or damage the paint.
• Do not use wax containing compounds (polish). Otherwise, it could
result in paint damage.
• In addition, do not use an electrical or air tool to apply wax. Other-
wise, the frictional heat generated could result in deformation of
plastic parts or paint damage.
NOTICE
●
Do not use any detergent other than mild detergent. Before using any
detergent, verify the ingredients.
Otherwise, the product could discolor or stain the aluminum wheels.
●
Do not use a wire brush or any abrasive cleaner, polishing compound, or
solvent on aluminum wheels. They may damage the coating.
●
Always use a sponge or soft cloth to clean the wheels.
Rinse the wheels thoroughly with lukewarm or cold water. Also, be sure to
clean the wheels after driving on dusty or salted roads to help prevent cor-
rosion.
●
Avoid washing your vehicle in an automatic car wash that uses high-speed
or hard brushes.
Plastic Part Maintenance
-------------------------------------------------------------------------------------------------------------------------------------------------------------
450
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Interior Care
Prevent caustic solutions such as perfume and cosmetic oils from
contacting the dashboard. They will damage and discolor the dash-
board. If these solutions get on the dashboard, wipe them off immedi-
ately.
■
Instrument panel top
• When cleaning, it is recommended that you use a clean towel
dampened in a mild detergent to remove soiling.
• If the surface is rubbed harshly, it could result in the surface
being damaged leaving white scratch marks.
WARNING
■
Do not spray water in the cabin
Splashing water on electrical parts such as the audio unit and switches is
dangerous as it could cause a malfunction or a fire.
Dashboard Precautions
NOTICE
Do not use glazing agents.
Glazing agents contain ingredients which may cause discoloration, wrin-
kling, cracks and peeling.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
451
5
Mainten
■
Vinyl
Remove dust and loose dirt from vinyl with a whisk broom or vac-
uum cleaner. Clean vinyl with a leather-and-vinyl cleaner.
■
Leather (if equipped)
Remove dust and sand first using a vacuum cleaner or other
means, then wipe dirt off using a soft cloth with a leather cleaner or
a soft cloth soaked in mild soap. Wipe off the remaining cleaner or
soap using a cloth soaked in clean water and wrung out well.
Remove moisture with a dry, soft cloth and allow the leather to fur-
ther dry in a well-ventilated, shaded area. If the leather gets wet
such as from rain, also remove moisture and dry it as soon as pos-
sible.
■
Fabric
Remove dust and loose dirt from fabric with a whisk broom or vac-
uum cleaner. Clean it with a mild soap solution good for upholstery
and carpets. Remove fresh spots immediately with a fabric spot
cleaner.
To keep the fabric looking clean and fresh, take care of it. Other-
wise its color will be affected, it can be stained easily, and its fire-
resistance may be reduced.
■
Panel
When the interior panels need to be cleaned, use soft material such
as a soft cloth soaked in clean water and wrung out well and lightly
wipe off dirt from the surface. If a panel requires further cleaning,
use the following procedure.
Wipe dirt off using a soft cloth soaked in mild detergent (about
5% solution).
Wipe off any remaining detergent using a cloth soaked in clean
water and wrung out well.
Cleaning the Upholstery and Interior Trim
1
2
-------------------------------------------------------------------------------------------------------------------------------------------------------------
452
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
■
Leather
●
Because genuine leather is a natural material, its surface is not uniform and
it may have natural scars, scratches, and wrinkles.
●
To maintain the quality for as long as possible, periodical maintenance,
about twice a year, is recommended.
NOTICE
■
Leather
●
Sand and dust on the seat surface may damage the overcoat of the genu-
ine leather surfaces and accelerate wear.
●
Greasy soiling on genuine leather may cause molding and stains.
●
Rubbing hard with a stiff brush or cloth may cause damage.
●
Do not wipe the leather using alcohol, chlorine bleach, or organic solvents
such as thinner, benzene, or gasoline. Otherwise, it may cause discolor-
ation or stains.
●
If the seats get wet, promptly remove moisture with a dry cloth. Remaining
moisture on the surface may cause deterioration such as hardening and
shrinkage.
●
Exposure to direct sunlight for long periods may cause deterioration and
shrinkage. When parking the car under direct sunlight for long periods,
shade the interior using sunshades.
●
Do not leave vinyl products on the seats for long periods as they may
affect the leather quality and coloring. If the cabin temperature becomes
hot, the vinyl may deteriorate and adhere to the genuine leather.
■
Fabric
Use only recommended cleaners and procedures. Others may affect
appearance and fire-resistance.
■
Panel
●
Do not wipe leather parts using alcohol, chlorine bleach, or organic sol-
vents such as thinner, benzene, or gasoline. Otherwise, it may cause dis-
coloration or stains.
●
Scratches or nicks on the panels and metallic trim resulting from the use of
a hard brush or cloth may not be repairable.
●
Be particularly careful when cleaning high lustre panels and metallic trim
as they can be easily scratched.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
453
5
Mainten
Clean the webbing with a mild soap solution recommended for uphol-
stery or carpets. Follow instructions. Do not bleach or dye the web-
bing; this may weaken it.
After cleaning the belts, thoroughly dry the belt webbing and make
sure there is no remaining moisture before retracting them.
If the windows become covered with an oily, greasy, or waxy film,
clean them with glass cleaner. Follow the directions on the container.
Rubber floor mats should be cleaned with mild soap and water only.
After removing the floor mats for cleaning, always reinstall them
securely. (
Cleaning the Lap/Shoulder Belt Webbing
WARNING
■
Have your Toyota dealer replace damaged seat belts immediately
Using damaged seat belts is dangerous. In a collision, damaged belts can-
not provide adequate protection.
Cleaning the Window Interiors
NOTICE
●
Do not scrape or scratch the inside of the window glass. It could damage
the thermal filaments and the antenna lines.
●
When washing the inside of the window glass, use a soft cloth dampened
in lukewarm water, gently wiping the thermal filaments and the antenna
lines.
Use of glass cleaning products could damage the thermal filaments and
the antenna lines.
Cleaning the Floor Mats
WARNING
■
Do not use rubber cleaners, such as tire cleaner or tire shine, when
cleaning rubber floor mats
Cleaning the rubber floor mats with rubber cleaning products makes the
floor mats slippery.
This may cause an accident when depressing the accelerator, brake, or
clutch (Manual transaxle) pedal or when getting in or out of the vehicle.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
-------------------------------------------------------------------------------------------------------------------------------------------------------------
455
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
6
If Trouble Arises
6-1. Parking in an Emergency
Parking in an
Emergency. . . . . .. 456
6-2. Flat Tire
Spare Tire and Tool
Storage . . . . . . ... 457
Changing a Flat Tire . . . 463
6-3. Battery Runs Out
Jump-Starting. . . . . 478
6-4. Emergency Starting
Starting a Flooded
Engine. . . . . . . . 482
Push-Starting . . . . . 483
6-5. Overheating
Overheating . . . . . .. 484
6-6. Emergency Towing
Towing Description . . ... 486
Tiedown Hooks . . . . . 487
6-7. Warning/Indicator Lights
and Warning Sounds
If a Warning Light Turns
On or Flashes . . . . . 489
Message Indicated on
Display . . . . . . . 500
Warning Sound is
Activated . . . . . . . 502
6-8. When Trunk Lid Cannot
be Opened
When Liftgate/Trunk Lid
Cannot be Opened . . . 506
-------------------------------------------------------------------------------------------------------------------------------------------------------------
456
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
Parking in an Emergency
The hazard warning lights should
always be used when you stop on
or near a roadway in an emer-
gency.
The hazard warning lights warn
other drivers that your vehicle is a
traffic hazard and that they must
take extreme caution when near
it.
Depress the hazard warning flasher and all the turn signals will flash.
The hazard warning indicator lights in the combination meter flash
simultaneously.
●
The turn signals do not work when the hazard warning lights are on.
●
Check local regulations about the use of hazard warning lights while the
vehicle is being towed to verify that it is not in violation of the law.
-------------------------------------------------------------------------------------------------------------------------------------------------------------
457
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
6
If Trouble Arises
Spare Tire and Tool Storage
Spare tire and tools are stored in the locations illustrated in the dia-
gram.
4-Door
*
1
: The jack point attachment can be used by vehicle repair shops and
road assistance services. Consult your Toyota dealer for details.
Spare tire
Spare tire hold-down bolt
Tool bag
Jack
Jack point attachment
*
1
Jack lever
Tiedown eyelet (if equipped)
Lug wrench
Flat tire belt
1
2
3
4
5
6
7
8
9
-------------------------------------------------------------------------------------------------------------------------------------------------------------
458
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
5-Door
Spare tire hold-down bolt
Jack
Spare tire
Tool bag
Jack lever
Tiedown eyelet (if equipped)
Lug wrench
Flat tire belt
1
2
3
4
5
6
7
8
-------------------------------------------------------------------------------------------------------------------------------------------------------------
YARIS_YARIS HATCHBACK_OM_OM99V59z_(U)
459
6
If Trouble Arises
■
To remove the jack
4-Door
Lift the trunk mat.
Remove trunk board.
Turn the wing bolt and jack
screw counterclockwise.
5-Door
Remove the cover.
Turn the wing bolt and jack
screw counterclockwise.
Jack
1
2
Wing bolt
Jack screw
3
1
2
-------------------------------------------------------------------------------------------------------------------------------------------------------------
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст