Toyota Tundra. Manual — part 1188
When multiple DTCs for misfiring cylinders are set, but DTC P0300 is not set, it indicates that misfires have
been detected in different cylinders at different times. DTC P0300 is only set when several misfiring cylinders
are detected at the same time.
MONITOR DESCRIPTION
The ECM illuminates the MIL and sets a DTC when either one of the following conditions, which could cause
emission deterioration, is detected (2 trip detection logic).
Within the first 1000 crankshaft revolutions of the engine starting, an excessive misfiring rate
(approximately 20 to 50 misfires per 1000 crankshaft revolutions) occurs once.
An excessive misfiring rate (approximately 20 to 50 misfires per 1,000 crankshaft revolutions) occurs a
total of 4 times.
The ECM flashes the MIL and sets a DTC when either one of the following conditions, which could cause the
Three-Way Catalytic Converter (TWC) damage, is detected (2 trip detection logic).
At a high engine RPM, a catalyst damage misfire, which monitored every 200 crankshaft revolutions,
occurs once.
At a normal engine RPM, a catalyst damage misfire, which monitored every 200 crankshaft revolutions,
occurs 3 times.
HINT:
If a catalyst damage misfire occurs, the ECM informs the driver by flashing the MIL.
MONITOR STRATEGY
MONITOR STRATEGY
P0301
P0302
P0303
P0304
P0305
P0306
Misfiring of specific cylinder occurs and one of following
conditions below is detected (2 trip detection logic):
High temperature misfire occurs in Three-Way Catalytic
Converter (TWC) (MIL blinks)
Emission deterioration misfire occurs (MIL illuminates)
Temperature (ECT)
sensor
Compression pressure
Valve clearance
Valve timing
PCV valve and hose
PCV hose connections
Air induction system
ECM
Related DTCs
P0300: Multiple cylinder misfire
P0301: Cylinder 1 misfire
P0302: Cylinder 2 misfire
P0303: Cylinder 3 misfire
P0304: Cylinder 4 misfire
P0305: Cylinder 5 misfire
2008 Toyota Tundra
2008 ENGINE PERFORMANCE Engine Control System (1GR-FE) - Tundra
TYPICAL ENABLING CONDITIONS
Misfire:
TYPICAL ENABLING CONDITIONS
Monitor period of emission-related-misfire:
TYPICAL ENABLING CONDITIONS
Monitor period of catalyst-damaged-misfire (MIL blinks)
TYPICAL ENABLING CONDITIONS
P0306: Cylinder 6 misfire
Required Sensors/Components
(Main)
Crankshaft position sensor and Camshaft position sensor
Required Sensors/Components
(Related)
Engine coolant temperature and intake air temperature sensors and Mass
air flow meter
Frequency of Operation
Continuous
Duration
1000 to 4000 crankshaft revolutions: Emission related misfire 200 to 600
crankshaft revolutions: Catalyst damaged misfire
MIL Operation
2 driving cycles: (MIL illuminates when misfire detected) MIL flashes
immediately: When catalyst damaged misfire occur
Sequence of Operation
None
Monitor runs whenever following DTCs not present
P0102 - P0103 (MAF meter)
P0110 - P0113 (IAT sensor)
P0115 - P0118 (ECT sensor)
P0120 - P0223, P2135 (TP sensor)
P0125 (Insufficient ECT for Closed Loop)
P0327, P0328 (Knock sensor)
P0335 (CKP sensor)
P0340 (VVT sensor)
P0500 (VSS)
Battery voltage
8 V or more
VVT system
Not operated by scan tool
Engine RPM
400 to 5400 RPM
Either of following conditions (a) or (b) met
-
(a) ECT at engine start
More than-7°C (19°F)
(b) ECT
More than 20°C (68°F)
Fuel cut
OFF
First 1000 revolutions after engine start, or Check Mode
Crankshaft 1000 revolutions
Except above
Crankshaft 1000 revolutions x 4
All of following conditions 1, 2 and 3 met
Crankshaft 200 revolutions x 3
2008 Toyota Tundra
2008 ENGINE PERFORMANCE Engine Control System (1GR-FE) - Tundra
TYPICAL MALFUNCTION THRESHOLDS
Monitor period of emission-related-misfire:
TYPICAL MALFUNCTION THRESHOLDS
Monitor period of catalyst-damaged-misfire (MIL blinks)
TYPICAL MALFUNCTION THRESHOLDS
MONITOR RESULT
Refer to CHECKING MONITOR STATUS .
WIRING DIAGRAM
Wiring diagram of the ignition system.
1. Driving cycles
1st
2. Check mode
OFF
3. Engine RPM
Less than 2800 RPM
Except above
Crankshaft 200 revolutions
Misfire rate
2% or more
Number of misfire per 200 revolutions
98 or more (varies with intake air amount and RPM)
Paired cylinder misfire (MIL blinks immediately) Detected
2008 Toyota Tundra
2008 ENGINE PERFORMANCE Engine Control System (1GR-FE) - Tundra
Fig. 104: Ignition System Wiring Diagram (1 Of 2)
2008 Toyota Tundra
2008 ENGINE PERFORMANCE Engine Control System (1GR-FE) - Tundra
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст