Toyota Tundra. Manual — part 1918
DRIVE BELT
COMPONENTS
2
Lean mixture causing misfire
High High
Rough idle (Black smoke
from exhaust)
1
Restricted air filter
2
Faulty SFI system:
Faulty pressure regulator
Defective ECT sensor
Faulty ECM - Faulty injectors
Faulty throttle position sensor
Faulty MAF meter
2009 Toyota Tundra
2009 ENGINE Engine Mechanical (3UR-FBE) - Tundra
Fig. 8: Identifying Drive Belt Components With Torque Specifications
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
ON-VEHICLE INSPECTION
1
INSPECT FAN AND GENERATOR V BELT
a
Check the belt for wear, cracks or other signs of damage
If any of the following defects is found, replace the fan and generator V belt
The belt is cracked
2009 Toyota Tundra
2009 ENGINE Engine Mechanical (3UR-FBE) - Tundra
The belt is worn out to the extent that the cords are exposed
The belt has chunks missing from the ribs
Fig. 9: Identifying Damage Belt
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
b
Check that the belt fits properly in the ribbed grooves
HINT:
Check with your hand to confirm that the belt has not slipped out of the grooves on the bottom of
the pulley If it has slipped out, replace the fan and generator V belt Install a new fan and generator
V belt correctly
2
INSPECT V-RIBBED BELT TENSIONER ASSEMBLY
a
Check that nothing gets caught in the tensioner by turning it clockwise and counterclockwise If the
result is not as specified condition, replace the tensioner
REMOVAL
1
REMOVE V-BANK COVER SUB-ASSEMBLY (See REMOVAL )
2
REMOVE NO. 1 ENGINE UNDER COVER (See REPLACEMENT )
3
REMOVE FAN AND GENERATOR V BELT
a
While turning the belt tensioner counterclockwise, align the service hole for the belt tensioner and
the belt tensioner fixing position, and then insert a bar of Ø 5 mm (0 197 in ) into the service hole
to fix the belt tensioner in place
HINT:
2009 Toyota Tundra
2009 ENGINE Engine Mechanical (3UR-FBE) - Tundra
The pulley bolt for the belt tensioner has a left-hand thread
Fig. 10: Turning Belt Tensioner
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
b
Remove the V belt
INSTALLATION
1
INSTALL FAN AND GENERATOR V BELT
a
Set the V belt onto every part
2009 Toyota Tundra
2009 ENGINE Engine Mechanical (3UR-FBE) - Tundra
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст