Toyota Tundra. Manual — part 1482
Fig. 15: Vehicle Speed Driving Pattern
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
a. Preconditions
The monitor will not run unless:
The MIL is OFF.
b. Drive Pattern
1. Connect the Techstream to the DLC3.
2. Turn the ignition switch to ON.
3. Turn the Techstream ON.
4. Clear DTCs (if set) (see DTC CHECK/CLEAR ).
5. Start the engine.
6. Allow the engine to idle for 10 minutes or more.
7. Drive the vehicle at 40 km/h (25 mph) or more for at least 2 minutes.
c. Monitor Status
1. Check the Readiness Monitor status displayed on the Techstream.
If the status does not switch to complete, make sure that the preconditions have been met,
and repeat steps from (5) to (7) described in the Drive Pattern above.
PROBLEM SYMPTOMS TABLE
HINT:
Use the table below to help determine the cause of problem symptoms. If multiple suspected areas are
listed, the potential causes of the symptoms are listed in order of probability in the "Suspected Area"
column of the table. Check each symptom by checking the suspected areas in the order they are listed.
Replace parts as necessary.
Inspect the fuses and relays related to this system before inspecting the suspected areas below.
SFI SYSTEM
PROBLEM SYMPTOM CHART
Symptom
Suspected Area
Refer To
Engine does not crank (Does not
start)
Battery
ON-VEHICLE INSPECTION
Starter
INSPECTION
Starter relay
STARTER RELAY
Cranking Holding Function
Circuit
CRANKING HOLDING
FUNCTION CIRCUIT
Park/neutral position switch
INSPECTION
Immobilizer system
HOW TO PROCEED WITH
2009 Toyota Tundra
2009 ENGINE PERFORMANCE Engine Control System (3UR-FBE) - Tundra
TROUBLESHOOTING
No initial combustion (Does not
start)
ECM power source circuit
ECM POWER SOURCE
CIRCUIT
Crankshaft position sensor
DTC P0335 CRANKSHAFT
POSITION SENSOR "A"
CIRCUIT; DTC P0337
CRANKSHAFT POSITION
SENSOR "A" CIRCUIT LOW
INPUT; DTC P0338
CRANKSHAFT POSITION
SENSOR "A" CIRCUIT HIGH
INPUT; DTC P0339
CRANKSHAFT POSITION
SENSOR "A" CIRCUIT
INTERMITTENT
Camshaft position sensor
DTC P1340 CAMSHAFT
POSITION SENSOR
"A" (BANK 1 SENSOR 2); DTC
P1342 CAMSHAFT POSITION
SENSOR "A" LOW INPUT
(MRE); DTC P1343 CAMSHAFT
POSITION SENSOR "A" HIGH
INPUT (MRE)
Ignition system
ON-VEHICLE INSPECTION
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Fuel Injector Circuit
FUEL INJECTOR CIRCUIT
ECM
TERMINALS OF ECM
VC output circuit
VC OUTPUT CIRCUIT
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Engine cranks normally but
difficult to start
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Compression
ON-VEHICLE INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Difficult to start with cold engine
Ignition system
ON-VEHICLE INSPECTION
Spark plug
ON-VEHICLE INSPECTION
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Injector
INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Injector
INSPECTION
Ignition system
ON-VEHICLE INSPECTION
2009 Toyota Tundra
2009 ENGINE PERFORMANCE Engine Control System (3UR-FBE) - Tundra
Difficult to start with warm
engine
Spark plug
ON-VEHICLE INSPECTION
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
High engine idle speed
Electronic throttle control system THROTTLE BODY
A/C signal circuit (for Automatic
Air Conditioning System)
TERMINALS OF ECU
A/C signal circuit (for Manual
Air Conditioning System)
TERMINALS OF ECU
ECM power source circuit
ECM POWER SOURCE
CIRCUIT
Acoustic Control Induction
System (ACIS)
ACIS CONTROL CIRCUIT
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Low engine idle speed (Poor
idling)
Electronic throttle control system THROTTLE BODY
A/C signal circuit (for Automatic
Air Conditioning System)
TERMINALS OF ECU
A/C signal circuit (for Manual
Air Conditioning System)
TERMINALS OF ECU
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Air induction system
ON-VEHICLE INSPECTION
Acoustic Control Induction
System (ACIS)
ACIS CONTROL CIRCUIT
PCV hose
ON-VEHICLE INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Rough idling
Compression
ON-VEHICLE INSPECTION
Spark plug
ON-VEHICLE INSPECTION
Injector
INSPECTION
Ignition system
ON-VEHICLE INSPECTION
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Electronic throttle control system THROTTLE BODY
Air induction system
ON-VEHICLE INSPECTION
Acoustic Control Induction
System (ACIS)
ACIS CONTROL CIRCUIT
PCV hose
ON-VEHICLE INSPECTION
Mass air flow meter
MASS AIR FLOW METER
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Electronic throttle control system THROTTLE BODY
Air induction system
ON-VEHICLE INSPECTION
2009 Toyota Tundra
2009 ENGINE PERFORMANCE Engine Control System (3UR-FBE) - Tundra
Idle hunting
ECM power source circuit
ECM POWER SOURCE
CIRCUIT
Acoustic Control Induction
System (ACIS)
ACIS CONTROL CIRCUIT
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Hesitation/Poor acceleration
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Spark plug
ON-VEHICLE INSPECTION
Ignition system
ON-VEHICLE INSPECTION
Injector
INSPECTION
Mass air flow meter
MASS AIR FLOW METER
Electronic throttle control system THROTTLE BODY
Air induction system
ON-VEHICLE INSPECTION
Compression
ON-VEHICLE INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Surging (Poor driveability)
Spark plug
ON-VEHICLE INSPECTION
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Ignition system
ON-VEHICLE INSPECTION
Injector
INSPECTION
Mass air flow meter
MASS AIR FLOW METER
Variable valve timing system
CAMSHAFT TIMING OIL
CONTROL VALVE ASSEMBLY
Compression
ON-VEHICLE INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
Engine stalls soon after starting
Fuel pump control circuit
FUEL PUMP CONTROL
CIRCUIT
Spark plug
ON-VEHICLE INSPECTION
Ignition system
ON-VEHICLE INSPECTION
Injector
INSPECTION
Variable valve timing system
CAMSHAFT TIMING OIL
CONTROL VALVE ASSEMBLY
Electronic throttle control system THROTTLE BODY
Air induction system
ON-VEHICLE INSPECTION
PCV hose
ON-VEHICLE INSPECTION
Compression
ON-VEHICLE INSPECTION
Fuel Pressure Switching System FUEL PRESSURE SWITCHING
SYSTEM
A/C signal circuit (for Automatic
Air Conditioning System)
TERMINALS OF ECU
2009 Toyota Tundra
2009 ENGINE PERFORMANCE Engine Control System (3UR-FBE) - Tundra
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст