Ford Focus RS (2011 year). Instruction — part 104
Item 1
Side air bag module wiring harness
1.
WARNING: Note the position of the wiring
harness, to aid installation. An incorrectly
routed wiring harness could become
damaged when the seat is moved. Failure to
follow this instruction may result in personal
injury.
Detach the side air bag electrical connector
from the connector block.
TIE39630
2. Detach the side air bag module wiring
harness from the seat frame.
• Use a trim tool to carefully release the
retaining clips.
TIE39631
G296350en
501-20B-
136
Supplemental Restraint System
501-20B-
136
REMOVAL AND INSTALLATION
Side Air Curtain Module — Vehicles Built From: 22-06-2007
General Equipment
Long Nose Pliers
Removal
WARNINGS:
After the power supply has been
disconnected, wait for a minimum of 3
minutes before disconnecting or removing
any pyrotechnic components.
Make sure that the vehicle electrical
system is fully depowered and no other
power source is connected.
NOTE: Removal steps in this procedure may
contain installation details.
General Information, Description and
Operation).
(414-01 Battery, Mounting and Cables,
General Procedures).
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
4.
E94863
5.
G1249050en
501-20B-
137
Supplemental Restraint System
501-20B-
137
REMOVAL AND INSTALLATION
1. Refer to:
Supplemental Restrai
nt System (SRS)
2. Refer to:
Battery Disconnect and Connect
Health and Safety Precautions
(100-00
Sliding Roof Opening Panel
(501-05 Interior
Refer to:
Headliner - 3-Door, Vehicles Without:
3. Refer to:
Headliner - 3-Door, Vehicles With:
Sliding Roof Opening Panel
(501-05 Interior
Refer to:
Headliner - 5-Door, Vehicles With:
Refer to:
Headliner - 5-Door, Vehicles Without:
Sliding Roof Opening Panel
(501-05 Interior
Sliding Roof Opening Panel
(501-05 Interior
E121928
1
2
3-door
6.
General Equipment: Long Nose Pliers
E121918
1
2
x5
4-door, 5-door and wagon
7.
General Equipment: Long Nose Pliers
E121931
1
2
x4
G1249050en
501-20B-
138
Supplemental Restraint System
501-20B-
138
REMOVAL AND INSTALLATION
Installation
1.
E122336
2.
G1249050en
501-20B-
139
Supplemental Restraint System
501-20B-
139
REMOVAL AND INSTALLATION
E122350
3.
G1249050en
501-20B-
140
Supplemental Restraint System
501-20B-
140
REMOVAL AND INSTALLATION
E122337
4.
Torque: 10 Nm
E122354
5.
E122355
G1249050en
501-20B-
141
Supplemental Restraint System
501-20B-
141
REMOVAL AND INSTALLATION
6.
E94863
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
Trim and Ornamentation, Removal and
Installation).
(414-01 Battery, Mounting and Cables,
General Procedures).
G1249050en
501-20B-
142
Supplemental Restraint System
501-20B-
142
REMOVAL AND INSTALLATION
7. Refer to:
Headliner - 3-Door, Vehicles With:
Refer to:
Headliner - 3-Door, Vehicles Without:
Sliding Roof Opening Panel
(501-05 Interior
Sliding Roof Opening Panel
(501-05 Interior
Refer to:
Headliner - 5-Door, Vehicles With:
Sliding Roof Opening Panel
(501-05 Interior
Refer to:
Headliner - 5-Door, Vehicles Without:
Sliding Roof Opening Panel
(501-05 Interior
8. Refer to:
Battery Disconnect and Connect
Clockspring
General Equipment
Worldwide diagnostic system (WDS)
1. Remove the steering wheel.
and Installation).
2. Remove the components in the order
indicated in the following illustration(s) and
table(s).
E48261
1
4
3
2
5
Description
Item
Audio control switch (if equipped)
1
Steering column lower shroud
See Removal Detail
2
Steering wheel rotation sensor electrical
connector (if equipped)
3
Clockspring electrical connector
4
Clockspring
See Removal Detail
See Installation Detail
5
All vehicles
3. To install, reverse the removal procedure.
Vehicles with stability assist
4.
WARNING: The electronic stability
program must be re-configured. Failure to
follow this instruction may result in personal
injury.
Configure the stability assist program using
WDS.
Removal Details
G391268en
501-20B-
143
Supplemental Restraint System
501-20B-
143
REMOVAL AND INSTALLATION
For additional information, refer to:
Steering
Wheel
(211-04 Steering Column, Removal
See Removal Detail
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст