Ford Galaxy / Ford S-MAX. Manual — part 735
1. 1. PRESS the NAV button
2. 2. PRESS the S5 button to enter the GPS INFO menu.
NOTE: The minimum number of satellites received by the navigation system display
module for correct operation is four. If the satellites received is below the minimum
requirement, the navigation system will not operate correctly. Move the vehicle to a
position where the required amount of satellites are received.
3. 3. Check the amount of satellites received by the navigation system display module.
4. 4. PRESS ESC to return to the previous menu.
5. 5. With the navigation system display module in the navigation main menu, PRESS
the S6 (EXTRA) button.
NOTE: ROTATE the right-hand rotary knob to highlight the mode required and PRESS the
right-hand rotary knob (ENTER) to select the mode.
6. 6. SELECT SENSOR TEST and PRESS the right-hand rotary knob. CHECK that all of
the sensors shown on the screen are operating correctly.
NOTE: When checking the wheel speed sensor it is necessary to drive the vehicle ten
meters forwards above 4 km/h (2.5 mph) to make the value change.
NOTE: When checking the direction sensor select the reverse gear and drive the vehicle
ten meters rearwards above 4 km/h (2.5 mph) to make the value change.
NOTE: When checking the navigation system display module internal gyroscope manually
move the vehicle from side to side to make the value change. If the value does not
change when the vehicle is being moved, INSTALL a new navigation system display
module.
REFER to:
Audio Unit - Vehicles With: Travel Pilot EX
(415-01 Information and
Entertainment System, Removal and Installation).
NOTE: When checking the GPS antenna self-diagnostic function, disconnect the GPS
antenna from the rear of the navigation system display module and TEST the system for
normal operation.
REFER to:
Audio Unit - Vehicles With: Travel Pilot EX
(415-01 Information and
Entertainment System, Removal and Installation).
If the navigation system display module is operating correctly, the display will show a
GPS error. If no message is displayed with the GPS antenna disconnected, INSTALL a new
navigation system display module.
REFER to:
Audio Unit - Vehicles With: Travel Pilot EX
(415-01 Information and
Entertainment System, Removal and Installation).
NOTE: Connect the GPS antenna to the navigation system display module and REFER to
the following list to diagnose the GPS antenna.
NOTE: The following list will not apply if the fault is induced by disconnecting the GPS
antenna.
If the GPS antenna sensor test displays OPEN, the GPS antenna is open circuit. REFER to
the DTC Index Chart and DTC TBD13 ACTION. Follow the instructions to diagnose the
GPS antenna.
If the GPS antenna sensor test displays SHORT, the GPS antenna is out of specification.
REFER to the WDS, check the DTCs. If DTC TBD12 is retrieved, REFER to the DTC Index
Chart to diagnose the GPS antenna.
If the GPS antenna sensor test displays OK, the GPS antenna is OK.
7. 7. PRESS ESC to return to the previous menu.
8. 8. If the cause is not visually evident after the Self-Diagnostic Mode, connect the
WDS to the data link connector (DLC).
9.
NOTE: Do not select the NAV from the WDS menu as this is for vehicles with digital
versatile disc (DVD) navigation system with touchscreen.
9. Select the ACU from the WDS menu.
10. 10. Retrieve the DTCs and refer to the DTC Index Chart.
Diagnostic Trouble Code (DTC) Index Chart
DTC
Description/Condition Possible Source
Action
B1342
Navigation system
display module failure
Navigation
system display
module
INSTALL a new navigation system display
module.
REFER to:
Audio Unit - Vehicles With: Travel
Pilot EX
(415-01 Information and
Entertainment System, Removal and
Installation).
TEST the system for normal operation.
B2408 Speaker line short circuit
Speaker(s),
Circuit(s)
REFER to:
Information and Entertainment
System
(415-00 Information and
Entertainment System - General Information,
Diagnosis and Testing).
B1097 Tweeter line short circuit
Speaker(s),
Circuit(s)
REFER to:
Information and Entertainment
System
(415-00 Information and
Entertainment System - General Information,
Diagnosis and Testing).
B1893 GPS antenna connection
open circuit
Antenna fault
open circuit
CHECK the navigation system antenna
connections and antenna base ground
connection. TEST the system for normal
operation. IF the concern persists, INSTALL a
new navigation system antenna cable.
B2204 GPS antenna connection
short circuit
Antenna fault
short
Disconnect the navigation system antenna.
TEST the system for normal operation. If the
DTC is still present with the navigation
system antenna disconnected, INSTALL a
new navigation system display module.
REFER to:
Audio Unit - Vehicles With: Travel
Pilot EX
(415-01 Information and
Entertainment System, Removal and
Installation).
IF the DTC B1893 is shown, REFER to DTC
B1893 in this section.
B2206
Gyroscope error
Invalid values
from gyroscope
for 30 seconds
INSTALL a new navigation system display
module.
REFER to:
Audio Unit - Vehicles With: Travel
1. 1. If the cause is not evident, verify the symptom and refer to the Symptom Chart.
Symptom Chart
Pilot EX
(415-01 Information and
Entertainment System, Removal and
Installation).
TEST the system for normal operation.
B2477
Module configuration
failure
Navigation
system display
module not
configured
REFER to the WDS.
U1900 Controller area network
(CAN) BUS failure
CAN
REFER to: Communications Network (418-00,
Diagnosis and Testing).
B2406 Internal audio CD player
failure
Navigation
system display
module
INSTALL a new navigation system display
module.
REFER to:
Audio Unit - Vehicles With: Travel
Pilot EX
(415-01 Information and
Entertainment System, Removal and
Installation).
TEST the system for normal operation.
B1035
CD ROM read test
CD ROM
INSPECT the CD ROM for damage. INSTALL a
new CD ROM. TEST the system for normal
operation.
B2410 FM receiving signal error
Antenna cable
REFER to:
Information and Entertainment
System
(415-00 Information and
Entertainment System - General Information,
Diagnosis and Testing).
B1317
Battery voltage low
Battery voltage
below 9 volts
REFER to:
Charging System
(414-00
Charging System - General Information,
Diagnosis and Testing).
B1318
Battery voltage high
Battery voltage
above 16 volts
REFER to:
Charging System
(414-00
Charging System - General Information,
Diagnosis and Testing).
Symptom
Possible Sources
Action
Navigation
system does not
operate but
radio does
Incorrectly
installed
navigation CD
ROM.
*
Install the navigation CD ROM correctly.
*
Navigation
system will not
switch on
Circuit(s).
Navigation
system display
module.
*
*
GO to Pinpoint Test
A.
*
Navigation
system not
operating
correctly
Wheel speed
sensor.
*
REFER to: Road Test Form - Anti-Lock Brake System
(ABS) (206-09A Anti-Lock Control, Diagnosis and
Testing).
*
Antenna
signal.
*
REFER to the Self-Diagnostic Mode.
*
Reversing
lamp(s).
*
REFER to:
Reversing Lamps
(417-01 Exterior Lighting,
Diagnosis and Testing).
*
Gyroscope.
*
With the navigation system display module in Self-
Diagnostic Mode, check the Gyro value changes when the
vehicle is moved side to side. If the value changes with
the movement of the vehicle, the internal gyroscope is
operating correctly. If the value does not change,
INSTALL a new navigation system display module.
REFER to:
Audio Unit - Vehicles With: Travel Pilot EX
*
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст