Ford F150 Pickup. Instruction — part 1317

See Fig. 133 . Remove spark plugs. To install, reverse removal procedure. Tighten all fasteners to specification.
See TORQUE SPECIFICATIONS .

Fig. 132: Locating Ignition Coil Cover Bolts
Courtesy of FORD MOTOR CO.

2003 Ford Pickup F150

2003 ENGINE PERFORMANCE Removal & Installation - Blackwood, Expedition, F150 Pickup & Navigator - Gasoline

Fig. 133: Removing Ignition Coils
Courtesy of FORD MOTOR CO.

Removal & Installation (4.2L Coil Pack)

Coil pack is located on right side valve cover. Disconnect harness connector. Disconnect spark plug wires.
Remove coil bolts and coil. See Fig. 134 .

2003 Ford Pickup F150

2003 ENGINE PERFORMANCE Removal & Installation - Blackwood, Expedition, F150 Pickup & Navigator - Gasoline

Fig. 134: Locating Ignition Coil Bolts
Courtesy of FORD MOTOR CO.

KNOCK SENSOR

See KNOCK SENSOR under SENSORS & SWITCHES.

SPARK PLUGS

Removal & Installation (4.6L & 5.4L)

Remove ignition coils. See IGNITION COILS . Remove spark plugs. To install, reverse removal procedure.
Tighten spark plugs to specification. See TORQUE SPECIFICATIONS .

NOTE:

Allow engine to cool before removing spark plugs. There is no authorized repair
for spark plug hole threads. Replace cylinder head if threads are damaged. If
spark plug removal and installation is primarily an unbolt and bolt-on
procedure, only a torque specification is furnished. See TORQUE
SPECIFICATIONS .

2003 Ford Pickup F150

2003 ENGINE PERFORMANCE Removal & Installation - Blackwood, Expedition, F150 Pickup & Navigator - Gasoline

EMISSIONS SYSTEMS & SUBSYSTEMS

EVAPORATIVE EMISSIONS SYSTEM SAFETY PRECAUTIONS

AFTER REPAIR PROCEDURE

After servicing evaporative system components, perform leak test. See EVAPORATIVE EMISSIONS
SYSTEM LEAK TEST under SYSTEM TESTS (EVAPORATIVE EMISSION) in SELF-DIAGNOSTICS -
CNG, FLEX-FUEL & GASOLINE article. Perform Evaporative Emission Running Loss Monitor Repair
Verification Drive Cycle. See EVAPORATIVE EMISSION LEAK CHECK MONITOR under
DIAGNOSTIC MONITORS in SELF-DIAGNOSTICS - CNG, FLEX-FUEL & GASOLINE article.

CHARCOAL CANISTER

Removal & Installation (Blackwood & F150)

1. Disconnect the battery ground cable. Raise and support the vehicle. Disconnect the canister vent solenoid

electrical connector. Remove the canister bracket bolts. See Fig. 135 and Fig. 136 . Disconnect the
canister vent solenoid hose assembly. Lower the canister and bracket.

2. Disconnect the hose. Disconnect the Evaporative (EVAP) emissions canister purge outlet tube. Remove

the canister vent solenoid. See Fig. 84 . Remove the evaporative emissions canister.

3. To install, reverse removal procedure. Lubricate all "O" rings with MERPOL(R) "O" ring Seal Lubricant

before installation. Perform after repair procedure. See AFTER REPAIR PROCEDURE .

WARNING:

The evaporative emissions system contains fuel vapor and condensed
fuel vapor. Although not present in large quantities, it still presents the
danger of explosion or fire. Disconnect battery ground cable from battery
to minimize the possibility of an electrical spark occurring, possibly
causing a fire or explosion if fuel vapor or liquid fuel are present in the
area. Failure to follow these instructions may result in personal injury. Do
not smoke or carry lighted tobacco or open flame of any type when
working on or near any fuel related component. Highly flammable
mixtures are always present and may be ignited, resulting in possible
personal injury. Failure to follow these instructions may result in personal
injury.

WARNING:

On Blackwood and Navigator models, The electrical power to the air
suspension system must be shut off prior to hoisting, jacking or towing
an air suspension vehicle. This can be accomplished by turning off the air
suspension switch, located below the glove box in the lower right side of
the passenger foot well. Failure to do so may result in shifting of the
vehicle during these operations. Failure to follow these instructions may
result in personal injury.

2003 Ford Pickup F150

2003 ENGINE PERFORMANCE Removal & Installation - Blackwood, Expedition, F150 Pickup & Navigator - Gasoline