Chery A15. Manual — part 160
Chery A15 Maintenance Manual
“Disconnecting Airbag” Part in this manual.
Disassembling Procedure
Disconnect SRS. Please refer to “Disconnecting Airbag” part of this manual;
Demount the left and right decorating plates of dashboard central control panel;
Loosen fuse lock of BCM wire harness connector;
Disconnect BCM wire harness connector;
Remove BCM fastening bolts;
Take off BCM.
Assembling Procedure
Install BCM with arrow on BCM pointing forward direction of vehicle;
Fix BCM fastening bolts;
Tighten fastening bolts with torque of 8-12Nm.
Connect BCM wire harness connector;
Push connector fuse lock in position;
Fix the left and right decorating plates of dashboard central control panel;
Power on SRS. Please refer to “Connecting Airbag” part of this manual.
Warning: All BCM mounting bolts must be tightened with care. Always make the
arrow on BCM point toward forward direction of the vehicle to ensure normal
working of SRS. BCM may still work if powered before installation onto vehicle body,
but potential mistrigger of airbag and injuries may be caused.
IV. Wiring and Connector
Note: combined with scuttle wiring assembly, wirings of SRS auxiliary system are all
held in a yellow corrugated tube, and all connectors are standard-yellow colored.
Chery A15 Maintenance Manual
(I). Inspection Items
1. Vehicles never collided or been collided:
Self-diagnosis of the system.
2. Vehicles ever collided or been collided:
(a). Self-diagnosis of the system;
(b). Check SRS auxiliary system wiring for breakage or bare lead;
(c). Check SRS auxiliary system connector for crack or breakage.
(II). Requirement on Part Replacement
In following cases the wiring or connector shall be replaced:
(a). SRS auxiliary system wiring or connector is found damaged during
troubleshooting.
(b). SRS auxiliary system wiring or connector is found damaged during inspection.
Note: In case of SRS auxiliary system wiring damage, the whole wiring assembly
shall be replaced.
Chery A15 Maintenance Manual
Section Four: Circuit Diagram
5
6
7
9
11
10
诊断座9#
5
黄
0.
驾驶侧气囊
棕/黄
1.0
绿/黄
1.0
囊电脑
故障灯
17#
30
15
X
31
D5
FS
21
10A
安全气
仪表安
全气囊
红
1.0
绿
0.5
棕/紫
1.0
Airbag fault indicator
light on dashboard
Red
Green
Brown/Purple
Yellow
0.5
Diagnose socket 9#
Airbag at driver’s side
Brown/yellowe Green/yellow
Airbag computer
Chery A15 Maintenance Manual
Chapter Five: Instruments
Section One: Introduction to Instruments
System Instruction
Chery A15 car adopts analog and digital combination instrument which includes
meters and gauges indicating vehicle conditions, warning lights monitoring abnormal
vehicle conditions and sending notices to driver, indicator lights informing driver of
conditions of different parts. The combination instrument also provides lighting for
meters and gauges.
The combination instrument consists of meters and gauges including speedometer,
water temperature gauge, fuel gauge and engine tachometer, warning lights such as
fuel warning light, door-unclosed warning light, engine warning light, engine oil
warning light, brake system warning light, ABS warning light, safety belt warning
light, airbag warning light, generator warning light, indicator lights including turn
signal indicator light, danger warning indicator light, flashing indicator light, high
beam indicator light, fog light, and other components such as multifunction display,
control unit, power supply module, circuit board, etc. (Meter-1)
Combination Instrument (Meter-1)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст