Range Rover Classic. Manual — part 13
09
LUBRICANTS, FLUIDS AND CAPACITIES
2
INFORMATION
RECOMMENDED LUBRICANTS AND FLUIDS
All climates and conditions
AMBIENT TEMPERATURE ˚C
COMPONENT
SPECIFICATION
VISCOSITY
-30
-20
-10
0
10
20
30
40
50
Engine V8i
Oils must meet:
5W/30
RES.22.OL.G-4
5W/40
or
5W/50
CCMC G-4 or
10W/30
API SG or SH
10W/40
10W/50
15W/40
15W/50
20W/40
20W/50
25W/40
25W/50
Engine TDi
RES.22.OL.PD-2
15W/40
or CCMC PD-2
or API CD
Main Gearbox
Automatic
ATF Dexron IID
Main Gearbox
manual
ATF Dexron IID
Final drive units
API or GL5
90 EP
Swivel pin housings
MIL - L - 2105 or
MIL - L - 2105B
80 EP
C or D
Power steering
ATF Dexron IID
Borg Warner
ATF Dexron IID
Transfer box
LUBRICANTS, FLUIDS AND CAPACITIES
3
INFORMATION
Propeller shaft Front
and Rear
NLGI - 2 Multi-purpose Lithium based GREASE
Lubrication nipples
(hubs, ball joints
etc.)
Seat slides
Door lock striker
Brake and clutch
reservoirs
Brake fluids having a minimum boiling point of 260
°
C (500
°
F) and complying with
FMVSS 116 DOT4
Engine cooling
Use an ethylene glycol based anti-freeze (containing no methanol)
system
with non-phosphate corrosion inhibitors suitable for use in aluminium engines to ensure
the protection of the cooling system against frost and corrosion in all seasons.
Battery lugs,
Petroleum jelly.
Earthing surfaces
NOTE: Do not use Silicone Grease
where paint has
been removed
Air Conditioning
Refrigerant R134a
System Refrigerant
CAUTION: DO NOT use any other type of refrigerant.
Compressor Oil
Nippon denso ND-OIL8
UNIPART R134a ND-OIL8
ABS Sensor
Silicone grease: Staborags NBU - Wabco 830 502,0634
bush-rear
Wacker chemie 704 - Wabco 830 502,0164
Kluber GL301
LUBRICATION PRACTICE
Use a high quality oil of the correct viscosity range and service classification in the engine during maintenance and
when topping up. The use of oil not to the correct specification can lead to high oil and fuel consumption and
ultimately to damaged components.
Oil to the correct specification contains additives which disperse the corrosive acids formed by combustion and
prevent the formation of sludge which can block the oilways. Additional oil additives should not be used. Always
adhere to the recommended servicing intervals.
WARNING: Many liquids and other substances used in motor vehicles are poisonous. They must
not be consumed and must be kept away from open wounds. These substances, among others,
include anti-freeze windscreen washer additives, lubricants and various adhesives.
09
LUBRICANTS, FLUIDS AND CAPACITIES
4
INFORMATION
CAPACITIES
The following capacity figures are approximate and provided as a guide only. Refer to Section 10 for correct
checking procedure for oil levels.
Capacities (approx.)*
Litres
Imp Unit
US unit
Engine sump and filter from dry
- petrol
6.6
. . . . . . . . . . . . . . . . . .
11.60 pints
14.0 pints
- diesel - Tdi
7.0
. . . . . . . . . . . . . . .
12.30 pints
14.8 pints
Manual gearbox - R380
2.7
. . . . . . . . . . . . .
4.70 pints
5.7 pints
Automatic gearbox
9.1
. . . . . . . . . . . . . . ...
16.00 pints
20 pints
Transfer gearbox from dry
1.7
. . . . . . . . . . . .
3.00 pints
3.6 pints
Front axle from dry
1.7
. . . . . . . . . . . . . . ...
3.00 pints
3.6 pints
Front axle swivel pin housing (each)
0.35
. . . . . . . .
0.60 pints
0.7 pints
Rear axle from dry
1.7
. . . . . . . . . . . . . . .
3.00 pints
3.6 pints
Power steering box and reservoir
2.9
. . . . . . . . .
5.00 pints
6.0 pints
Cooling system
11.4
. . . . . . . . . . . . . . . .
20.00 pints
24 pints
Fuel tank
89
. . . . . . . . . . . . . . . . . . ..
19.5 gallons
23 gallons
NOTE: * All levels must be checked by dipstick or level plugs as applicable.
When draining oil from the ZF automatic gearbox, oil will remain in the torque converter, refill to
high level on dipstick only.
ANTI-FREEZE
ENGINE TYPE
MIXTURE STRENGTH
PERCENTAGE
PROTECTION
CONCENTRATION
LOWER
TEMPERATURE
LIMIT
V8 Engine
One part anti-freeze
Diesel Engine
One part water
50%
Complete protection
- 33
°
F
Vehicle may be driven away immediately from cold
- 36
°
C
Safe limit protection
- 41
°
C
Coolant in mushy state. Engine may be started and driven away after warm-up
period
- 42
°
F
Lower protection
- 47
°
C
Prevents frost damage to cylinder head, block and radiator. Thaw out before
starting engine
- 53
°
F
CAUTION: Anti-freeze content must never be allowed to fall below 25% otherwise damage to the
engine is liable to occur. Also, anti-freeze content should not exceed 60% as this will greatly
reduce the cooling effect of the coolant.
LUBRICANTS, FLUIDS AND CAPACITIES
5
INFORMATION
FUEL REQUIREMENTS
Catalyst vehicles
Vehicles equipped with catalytic converter are designed to use ONLY unleaded fuel. Unleaded fuel must be used
for the emission control system to operate properly. Its use will also reduce spark plug fouling, exhaust system
corrosion and engine oil deterioration.
Using fuel that contains lead will result in damage to the emission control system and could result in loss of
warranty coverage. The effectiveness of the catalysts in the catalytic converters will be seriously impaired if leaded
fuel is used. The vehicle is equipped with an electronic fuel injection system, which includes two oxygen sensors.
Leaded fuel will damage the sensors, and will deteriorate the emission control system.
Regulations require that pumps delivering unleaded fuel be labelled UNLEADED. Only these pumps have nozzles
which fit the filler neck of the vehicle fuel tank.
RECOMMENDED FUEL
Petrol engines
- with catalytic converter
unleaded only, 95 RON (USA 90 CLC or AKI)
. . . . . . . . . . ..
- non catalytic, 9.35:1 compression ratio
leaded 97 RON/unleaded 95 RON
. . . . .
- non catalytic, 8.13:1 compression ratio
leaded 90 RON/unleaded 95 RON
. . . . .
- Australia
minimum 91 RON unleaded
. . . . . . . . . . . . . . . .
Diesel engines
- 300Tdi
Diesel fuel oil, distillate, diesel fuel, automotive gas or
. . . . . . . . . . . . . . . . ...
Derv to British standard 2869, (1983) class A1 or A2.
Using fuel with an octane rating lower than stated above could seriously impair vehicle performance.
CAUTION: Do not use oxygenated fuels such as blends of methanol/gasoline or ethanol/gasoline
(e.g. ’Gasohol’). Take care not to spill fuel during refuelling.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст