Jeep Wrangler TJ. Manual — part 198
MAINTENANCE SCHEDULES – EXPORT
There are two maintenance schedules that show
the required service for your vehicle.
First is Schedule “A”. It is for vehicles that are not
operated under any of the conditions listed under
Schedule “B.”
Second is Schedule
(B(. It is for vehicles that are
operated under the conditions that are listed below
and at the beginning of the schedule.
• Day or night temperatures are below 0°C (32°F)
• Stop and go driving
• Excessive engine idling
• Driving in dusty conditions
• Short trips of less than 16.2 km (10 miles)
• More than 50% of your driving is at sustained
high speeds during hot weather, above 32°C (90°F)
• Trailer towing
• Taxi, police, or delivery service (commercial ser-
vice)
• Off-road or desert driving
• If equipped for and operated with E-85
(ethanol) fuel.
NOTE: Most vehicles are operated under the condi-
tions listed for Schedule “B.”
Use the schedule that best describes your driving
conditions. Where time and mileage are listed, follow
the interval that occurs first.
CAUTION: Failure to perform the required mainte-
nance items may result in damage to the vehicle.
At Each Stop for Fuel
• Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the oil
level while the vehicle is on level ground will
improve the accuracy of the oil level reading. Add oil
only when the level is at or below the ADD or MIN
mark.
• Check the windshield washer solvent, add as
required.
Once a Month
• Check the tire pressure and look for unusual
wear or damage.
• Inspect the battery and clean and tighten the
terminals as required.
• Check the fluid levels of the coolant reservoir,
brake master cylinder, power steering, and transmis-
sion, and add as needed.
• Check all lights and all other electrical items for
correct operation.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
• Inspect brake hoses.
• Check the coolant level, hoses, and clamps.
• Rotate the tires.
• Inspect manual transmission fluid level - if
equipped.
• After completion of off-road operation, the
underside
of
the
vehicle
should
be
thoroughly
inspected. Examine threaded fasteners for looseness.
Schedule “A”
Kilometers
10 000
19 000
29 000
38 000
48 000
(Miles)
(6,000)
(12,000)
(18,000)
(24,000)
(30,000)
[Months]
[6]
[12]
[18]
[24]
[30]
Change the engine oil and engine oil filter.
X
X
X
X
X
Rotate the tires.
X
X
X
X
X
Inspect the engine air filter element, and replace if
necessary.
X
Replace the spark plugs.
X
Lubricate the steering linkage joints and outer tie rod
ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Inspect the transfer case fluid.
X
TJ
LUBRICATION & MAINTENANCE
0 - 15
MAINTENANCE SCHEDULES (Continued)
Kilometers
58 000
67 000
77 000
86 000
(Miles)
(36,000)
(42,000)
(48,000)
(54, 000)
[Months]
[36]
[42]
[48]
[54]
Change the engine oil and engine oil filter.
X
X
X
X
Rotate the tires.
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Lubricate the steering linkage joints and outer tie rod ends.
X
X
X
X
Inspect the brake linings.
X
X
Kilometers
96 000
106 000
115 000
125 000
(Miles)
(60,000)
(66,000)
(72,000)
(78,000)
[Months]
[60]
[66]
[72]
[78]
Change the engine oil and engine oil filter.
X
X
X
X
Rotate the tires.
X
X
X
X
Inspect the engine air filter element, and replace if
necessary.
X
Inspect the PCV Valve, and replace if necessary.
L
X
Replace the ignition cables (2.4L Only).
X
Replace the spark plugs.
X
Lubricate the steering linkage joints and outer tie rod ends.
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Inspect the drive belt, and replace as needed.
X
Inspect the drive belt, and replace as needed. Not required
if belt was previously replaced.
X
Flush and replace the engine coolant/anti-freeze at 60
months, if not done at 163 000 km (102,000 miles).
X
Inspect transfer case fluid.
X
0 - 16
LUBRICATION & MAINTENANCE
TJ
MAINTENANCE SCHEDULES (Continued)
Kilometers
134 000
144 000
154 000
163 000
(Miles)
(84,000)
(90,000)
(96,000)
(102, 000)
[Months]
[84]
[90]
[96]
[102]
Change the engine oil and engine oil filter.
X
X
X
X
Rotate the tires.
X
X
X
X
Inspect the engine air filter element, and replace if
necessary.
X
Inspect the PCV Valve, and replace if necessary.
L
X
Replace the spark plugs.
X
Lubricate the steering linkage joints and outer tie rod ends.
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Inspect the drive belt, and replace as needed. Not required
if previously replaced.
X
X
Flush and replace the engine coolant/anti-freeze if not done
at 60 months.
X
Inspect the transfer case fluid.
X
Kilometers
173 000
182 000
192 000
(Miles)
(108,000)
(114,000)
(120,000)
[Months]
[108]
[114]
[120]
Change the engine oil and engine oil filter.
X
X
X
Rotate the tires.
X
X
X
Inspect the engine air filter element, and replace if necessary.
X
Replace the ignition cables (2.4L Only).
X
Inspect the PCV Valve, and replace if necessary.
L
X
Replace the spark plugs.
X
Lubricate the steering linkage joints and outer tie rod ends.
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Replace the timing belt (2.4L Only).
L
X
Inspect the drive belt, and replace as needed. Not required if
previously replaced.
X
Drain and refill the transfer case fluid.
X
Flush and replace the engine coolant/anti-freeze, if not done at 163
000 km (102,000 miles).
X
Inspection and service should also be performed
anytime a malfunction is observed or suspected.
Retain all receipts.
L This maintenance is recommended by the man-
ufacturer to the owner, but is not required to main-
tain emissions warranty.
TJ
LUBRICATION & MAINTENANCE
0 - 17
MAINTENANCE SCHEDULES (Continued)
Schedule “B”
Follow schedule “B” if you usually operate your
vehicle under one or more of the following conditions.
• Day or night temperatures are below 0°C (32°F).
• Stop and go driving.
• Extensive engine idling.
• Driving in dusty conditions.
• Short trips of less than 16.2 km (10 miles).
• More than 50% of your driving is at sustained
high speeds during hot weather, above 32°C (90°F).
• Trailer towing.
• Taxi, police, or delivery service (commercial ser-
vice).
• Off-road or desert driving.
• If equipped for and operated with E-85
(ethanol) fuel.
Kilometers
5 000
10 000
14 000
19 000
24 000
(Miles)
(3,000)
(6,000)
(9,000)
(12,000)
(15,000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
Inspect the engine air filter element, replace if
necessary.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
Kilometers
29 000
34 000
38 000
43 000
48 000
(Miles)
(18,000)
(21,000)
(24,000)
(27,000)
(30,000)
Change the engine oil and engine oil filter, if not
replaced at 3 months.
X
X
X
X
X
Rotate the tires.
X
X
X
Inspect the engine air filter element, replace if
necessary.
X
Inspect the PCV Valve, and replace if necessary.
L
X
Replace the spark plugs.
X
Lubricate the steering linkage tie rod ends.
X
X
X
X
X
Lubricate the steering and suspension ball joints.
X
X
X
Inspect the brake linings.
X
Drain and refill the front and rear axle fluid‡
X
Inspect the transfer case fluid, add if necessary.
X
0 - 18
LUBRICATION & MAINTENANCE
TJ
MAINTENANCE SCHEDULES (Continued)
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст