Acura TSX / Honda Accord CL. Manual — part 450

8. If the plastigage measures too wide or too narrow, remove the upper half of the bearing, install a new,

complete bearing with the same color code(s), and recheck the clearance. Do not file, shim, or scrape the
bearings or the caps to adjust clearance.

9. If the plastigage shows the clearance is still incorrect, try the next larger or smaller bearing (the color

listed above or below that one), and check clearance again. If the proper clearance cannot be obtained by
using the appropriate larger or smaller bearing, replace the crankshaft and start over.

Rod Bearing Selection

1. Inspect each connecting rod for cracks and heat damage.

Connecting Rod Big End Bore Code Locations

2. Each rod has a tolerance range from 0 to 0.024 mm (0.0009 in.), in 0.006 mm (0.0002 in.) increments,

depending on the size of its big end bore. It's then stamped with a number or bar (1, 2, 3 or 4/I, II, III, or
IIII) indicating the range. You may find any combination of numbers and bars in any engine. (Half the
number or bar is stamped on the bearing cap, the other half is on the rod.)

Normal Bore Size: 51.0 mm (2.01 in.)

NOTE:

If you can't read the code because of an accumulation of oil and varnish,
do not scrub it with a wire brush or scraper. Clean it only with solvent or
detergent.

2004 Acura TSX

2004 ENGINES 2.4L DOHC VTEC - TSX

Fig. 190: Locating Connecting Rod Big End Bore Code

Connecting Rod Journal Code Location

3. The connecting rod journal codes are stamped on the crankshaft.

2004 Acura TSX

2004 ENGINES 2.4L DOHC VTEC - TSX

2004 Acura TSX

2004 ENGINES 2.4L DOHC VTEC - TSX

Fig. 191: Locating Connecting Rod Journal Code Locations

4. Use the big end bore codes and rod journal codes to select appropriate replacement bearings from the

following table. See Fig. 192 .

Fig. 192: Replacement Bearings Color Code Table

OIL PAN REMOVAL

Special Tools Required: Engine hanger plate EQS00BRSX0

NOTE:

z

The color code is on the edge of the bearing.

z

When using bearing halves of different colors, it does not matter
which color is used in the top or bottom.

2004 Acura TSX

2004 ENGINES 2.4L DOHC VTEC - TSX