Mitsubishi Grandis. Manual — part 816
CROSSMEMBER
POWER PLANT MOUNT
32-11
REMOVAL SERVICE POINTS
<<A>> STEERING SHAFT ASSEMBLY
AND GEAR BOX CONNECTING BOLT
REMOVAL
1. Remove the steering column bolt connecting
steering gear to steering column assembly.
2. Disconnect the steering gear from the steering
column assembly while sliding shaft A to shaft B
with the clip claw as shown is pinched.
<<B>> TIE ROD END AND KNUCKLE
DISCONNECTION
CAUTION
• Do not remove the nut from ball joint. Loosen
it and use special tool to avoid possible
damage to ball joint threads.
• Hang special tool with a cord to prevent it
from falling.
1. Install the special tool ball joint remover
(MB991897) as shown in the figure.
2. Turn the bolt and knob as necessary to make the
jaws of the special tool parallel, tighten the bolt by
hand and confirm that the jaws are still parallel.
NOTE: When adjusting the jaws in parallel, make
sure the knob is in the position shown in the
figure.
3. Tighten the bolt with a wrench to disconnect the
tie rod end.
<<C>> CROSSMEMBER ASSEMBLY
REMOVAL
1. Use a transmission jack to hold the crossmember,
and then remove the crossmember mounting nuts
and bolts.
2. Lower the crossmember with the engine rear roll
stopper bracket, the stabilizer bar, the return tube,
and the steering gear.
AC311143 AB
Shaft A
Shaft B
Clip
AC208247AD
Cord
Bolt
MB991897
Nut
Ball joint
AC106821
Knob
Parallel
Bolt
Good
Bad
AB
AC302103
Transmission
jack
AC
CROSSMEMBER
POWER PLANT MOUNT
32-12
INSTALLATION SERVICE POINT
>>A<< STEERING COLUMN GROMMET
INSTALLATION
Install the steering column grommet with its mark
facing the front of the vehicle.
AC302650
Front of vehicle
Mark
Steering
column
grommet
AC
51-1
GROUP 51
EXTERIOR
CONTENTS
FRONT BUMPER ASSEMBLY . . . . .
ADHESIVE . . . . . . . . . . . . . . . . . . . . . . . . .
FRONT BUMPER ASSEMBLY . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
DISASSEMBLY AND REASSEMBLY. . . . .
REAR BUMPER ASSEMBLY . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
MOULDINGS . . . . . . . . . . . . . . . . . . .
SPECIAL TOOL . . . . . . . . . . . . . . . . . . . . .
MOULDINGS . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
GARNISHES . . . . . . . . . . . . . . . . . . .
ADHESIVE . . . . . . . . . . . . . . . . . . . . . . . . .
GARNISHES . . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
DOOR SASH TAPE . . . . . . . . . . . . . .
SPECIAL TOOL . . . . . . . . . . . . . . . . . . . . .
DOOR SASH TAPE . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
TAILGATE SPOILER . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
ROOF RAIL . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
WINDSHIELD WIPER AND WASHER
SERVICE SPECIFICATION . . . . . . . . . . . .
TROUBLESHOOTING . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE . . . . . . . . . . . . . . .
WINDSHIELD INTERMITTENT WIPER INSPECTION
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WASHER MOTOR INSPECTION (WINDSHIELD
WASHER) . . . . . . . . . . . . . . . . . . . . . . . . . .
WINDSHIELD WIPER . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
WINDSHIELD WASHER . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
REAR WIPER AND WASHER . . . . . .
TROUBLESHOOTING . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE . . . . . . . . . . . . . . .
Operation check of reverse gear-linked operation of the
rear wiper. . . . . . . . . . . . . . . . . . . . . . . . . . .
WASHER MOTOR INSPECTION (REAR WASHER)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REAR WIPER AND WASHER . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
HEADLAMP WASHER . . . . . . . . . . . .
TROUBLESHOOTING . . . . . . . . . . . . . . . .
HEADLAMP WASHER . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
INSPECTION. . . . . . . . . . . . . . . . . . . . . . . .
MARK . . . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
DOOR MIRROR . . . . . . . . . . . . . . . . .
SERVICE SPECIFICATION . . . . . . . . . . . .
TROUBLESHOOTING . . . . . . . . . . . . . . . .
DIAGNOSIS TROUBLESHOOTING FLOW
TROUBLE SYMPTOM CHART . . . . . . . . . .
INSPECTION PROCEDURE 1: All Heated Door Mirrors
do not Operate. . . . . . . . . . . . . . . . . . . . . . .
INSPECTION PROCEDURE 2: Right or Left Heated
Door Mirror does not Operate . . . . . . . . . . .
51-2
ON-VEHICLE SERVICE . . . . . . . . . . . . . . .
Check of door mirror timer function. . . . . . .
DOOR MIRROR . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . . . . .
DISASSEMBLY AND REASSEMBLY . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст