Mitsubishi Montero Sport (2004+). Manual — part 504
54-3
DOME LIGHT . . . . . . . . . . . . . . .
LIGHTING SYSTEM DIAGNOSIS .
INTRODUCTION TO DOME LIGHT AND
CARGO SPACE LIGHT DIAGNOSIS
<VEHICLES WITH KEYLESS ENTRY
SYSTEM> . . . . . . . . . . . . . . . . . . . . . . .
DOME LIGHT AND CARGO SPACE LIGHT
DIAGNOSTIC TROUBLESHOOTING
STRATEGY <VEHICLES WITH KEYLESS
ENTRY SYSTEM> . . . . . . . . . . . . . . . . .
SYMPTOM CHART . . . . . . . . . . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . .
HIGH-MOUNTED STOPLIGHT .
REMOVAL AND INSTALLATION .
RHEOSTAT . . . . . . . . . . . . . . . .
INSPECTION . . . . . . . . . . . . . . . . .
HAZARD WARNING LIGHT
SWITCH . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION .
INSPECTION . . . . . . . . . . . . . . . . .
HORN . . . . . . . . . . . . . . . . . . . . .
HORN DIAGNOSIS <VEHICLE WITH
KEYLESS ENTRY SYSTEM OR
THEFT ALARM SYSTEM> . . . . . .
HORN . . . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . .
INSPECTION . . . . . . . . . . . . . . . . . . . . .
CIGARETTE LIGHTER . . . . . . .
REMOVAL AND INSTALLATION .
INSPECTION . . . . . . . . . . . . . . . . .
ACCESSORY SOCKET . . . . . .
REMOVAL AND INSTALLATION .
INSPECTION . . . . . . . . . . . . . . . . .
RADIO AND TAPE PLAYER . .
RADIO WITH TAPE PLAYER AND CD
PLAYER, SPEAKER AND ANTENNA
DIAGNOSIS . . . . . . . . . . . . . . . . . .
INTRODUCTION TO AUDIO SYSTEM
DIAGNOSIS . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING STRATEGY . . . .
SYMPTOM CHART . . . . . . . . . . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . . .
SPECIAL TOOL . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE . . . . . . . . .
PROCEDURE FOR INPUT OF SECURITY
CODE FOR ANTI-THEFT SYSTEM. . . .
SPEAKER TEST . . . . . . . . . . . . . . . . . .
RADIO WITH CD PLAYER. . . . . . .
REMOVAL AND INSTALLATION. . . . . .
SPEAKER. . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION .
AMPLIFIER. . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION .
ANTENNA . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION .
INSPECTION . . . . . . . . . . . . . . . . .
ANTENNA POLE REPLACEMENT
Continued on next page
54-4
REAR WINDOW DEFOGGER . .
ON-VEHICLE SERVICE. . . . . . . . .
PRINTED-HEATER LINES CHECK . . .
REAR WINDOW DEFOGGER
SWITCH . . . . . . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . . .
INSPECTION . . . . . . . . . . . . . . . . . . . . .
THEFT ALARM . . . . . . . . . . . . .
THEFT-ALARM SYSTEM
DIAGNOSIS . . . . . . . . . . . . . . . . . .
INTRODUCTION TO THEFT-ALARM
SYSTEM DIAGNOSIS . . . . . . . . . . . . . .
TROUBLE SYMPTOM CHART . . . . . . .
SYMPTOM PROCEDURES . . . . . . . . . .
THEFT ALARM. . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION. . . . . .
INSPECTION . . . . . . . . . . . . . . . . . . . . .
SPECIFICATIONS . . . . . . . . . .
FASTENER TIGHTENING
SPECIFICATIONS . . . . . . . . . . . . .
SERVICE SPECIFICATIONS . . . . .
BATTERY
TSB Revision
CHASSIS ELECTRICAL
54-5
BATTERY
ON-VEHICLE SERVICE
BATTERY CHECK
M1541001000319
WARNING
Battery posts, terminals and related accessories con-
tain lead and lead compounds. WASH HANDS AFTER
HANDLING.
BATTERY VISUAL INSPECTION (1)
The battery contains a visual test indicator which gives a blue
signal when an adequate charge level exists, and a white sig-
nal when charging is required.
AC002728 AB
INDICATOR
BLUE
CHARGING
NECESSARY
GOOD
CONDITION
WHITE
BATTERY
TSB Revision
CHASSIS ELECTRICAL
54-6
BATTERY VISUAL INSPECTION (2)
Make sure ignition switch is in "LOCK" (OFF) position and all
battery fed accessories are OFF.
1. Disconnect the negative cable from battery before
disconnecting the positive cable.
WARNING
Care should be taken in the event battery case is
cracked or leaking to protect hands from the electro-
lyte. A suitable pair of rubber gloves (not the house-
hold type) should be worn when removing battery by
hand.
2. Remove the battery from the vehicle.
3. Inspect battery carrier for damage caused by loss of acid
from battery. If acid damage is present, it is necessary to
clean area with a solution of clean warm water and baking
soda. Scrub area with a stiff bristle brush. Wipe clean with a
cloth moistened with ammonia or baking soda in water.
4. Clean the battery, especially the top with same solutions as
described in step 3.
5. Inspect the battery case and cover for cracks. If cracks are
present, battery must be replaced.
6. Clean the battery post with a suitable battery post cleaning
tool.
7. Clean the inside surfaces of the terminal clamps with a
suitable battery terminal cleaning tool. Replace damaged or
frayed cables and broken terminal clamps.
8. Install the battery in the vehicle.
9. Connect the positive and negative cables to the battery in
the order of mention.
10.Tighten the clamp nut securely.
BATTERY CHARGING
M1541001100576
WARNING
When batteries are being charged, an explosive gas forms beneath the cover of each cell. Do
not smoke near batteries on charge or which have recently been charged. Do not break live
circuits at the terminals of the batteries on charge. A spark will occur where the live circuit is
broken. Keep all open flames away from the battery.
Battery electrolyte temperature may temporarily be allowed to rise to 55
°C (131°F). Increase of electrolyte
temperature above 55
°C (131°F) is harmful to the battery, causing deformation of battery cell, decrease in
life of battery, etc.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст