Mitsubishi Montero (2002-2004). Manual — part 652
TSB Revision
DIAGNOSTIC TROUBLE CODE PROCEDURES
13Ac-305
DTC P0182: Fuel Tank Temperature Sensor Circuit Low Input
POWERTRAIN CONTROL
MODULE (PCM)
Fuel Tank Temperature Sensor Circuit
2
16
3
2
7
1
BLA
CK
BLA
CK
LIGHT
GREEN-
RED
G-03
MU802337
1 2 3
AK201139
81
FUEL TANK TEMPERATURE SENSOR
(INTEGRATED IN FUEL LEVEL SENSOR)
4
17
1
12 13 14
18
30
41
34
3
16
10
6 7
19
31
42
20
32
43
21
33
25
24
26
36
35
37
29
28
15
27
38
8 9
39 40
11
2
22
5
23
D-111
8
7
6
5
1 2 3 4
F-07
MU802609
11
1
9 10
13
2
12
3 4
7
5
14
6
8
E-113
5 V
LIGHT
GREEN-
RED
LIGHT
GREEN-
RED
LIGHT GREEN-
RED
61
656667686970 717273
74757677787980 8182
8384
858687
8889
62
6364
D-134
(MU803804)
TSB Revision
DIAGNOSTIC TROUBLE CODE PROCEDURES
13Ac-306
.
CIRCUIT OPERATION
• 5-volt voltage is applied to the fuel tank tempera-
ture sensor output terminal (terminal No. 3) from
the PCM (terminal No. 81) via the resistor in the
PCM.
• The fuel tank temperature sensor output voltage
increases when the resistance increases and
decreases when the resistance decreases. The
ground terminal (terminal No. 2) is grounded to
the vehicle body.
.
TECHNICAL DESCRIPTION
• The fuel tank temperature sensor converts the
fuel tank temperature to a voltage.
• The PCM detects the fuel tank temperature in the
fuel tank with this output voltage.
.
DTC SET CONDITIONS
Check Conditions
• 2 seconds or more have passed since the start-
ing sequence was completed.
Judgement Criteria
• Sensor output voltage has continued to be 0.1
volt or lower for 2 seconds.
.
TROUBLESHOOTING HINTS (The most likely
causes for this code to be set are: )
• Fuel tank temperature sensor failed.
• Open or shorted fuel tank temperature sensor cir-
cuit, or loose connector.
• PCM failed.
AK201038
CONNECTOR: D-134
AD
PCM
D-134(GR)
AK201053
E-113
AB
CONNECTOR: E-113
AK201055
CONNECTOR: D-111
D-111
AB
AK201040 AB
CONNECTOR: G-03
G-03(B)
FUEL TANK TEMPERATURE SENSOR
(INTEGRATED IN FUEL
LEVEL SENSOR)
AK201054
F-07(B)
AB
CONNECTOR: F-07
TSB Revision
DIAGNOSTIC TROUBLE CODE PROCEDURES
13Ac-307
DIAGNOSIS
Required Special Tool:
• MB991502: Scan Tool (MUT-II)
STEP 1. Using scan tool MB991502, check data list item
4A: Fuel Tank Temperature Sensor.
CAUTION
To prevent damage to scan tool MB991502, always turn the
ignition switch to the "LOCK" (OFF) position before con-
necting or disconnecting scan tool MB991502.
(1) Connect scan tool MB991502 to the data link connector.
(2) Turn the ignition switch to the "ON" position.
(3) Set scan tool MB991502 to the data reading mode for item
4A, Fuel Tank Temperature Sensor.
• Approximately the same as the ambient air temperature
when the engine is cooled.
(4) Turn the ignition switch to the "LOCK" (OFF) position.
Q: Is the sensor operating properly?
YES : It can be assumed that this malfunction is intermittent.
Refer to GROUP 00, How to Use Troubleshooting/
Inspection Service Points
NO : Go to Step 2.
STEP 2. Check the fuel tank temperature sensor.
(1) Disconnect the fuel tank temperature sensor connector G-
03.
(2) Measure the resistance between terminal No. 2 and No. 3
of the fuel tank temperature sensor.
Standard value:
0.5
− 12.0 kiloohms
Q: Is the resistance between 0.5 and 12.0 kiloohms?
YES : Go to Step 3.
NO : Replace the fuel tank temperature sensor. Then go to
Step 5.
ACX01539
16-PIN
MB991502
AC
AK200959
1
2
3
AB
CONNECTOR: G-03
G-03(B)
HARNESS
CONNECTOR:
COMPONENT SIDE
1 2 3
AK101072
FUEL TANK TEMPERATURE
SENSOR SIDE
CONNECTOR
AC
TSB Revision
DIAGNOSTIC TROUBLE CODE PROCEDURES
13Ac-308
STEP 3. Check connector G-03 at the fuel tank temperature
sensor and connector D-134 at PCM for damage.
Q: Is the connector in good condition?
YES : Go to Step 4.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
. Then go to Step 5.
AK200959
1
2
3
AB
CONNECTOR: G-03
G-03(B)
HARNESS
CONNECTOR:
COMPONENT SIDE
AK201166
61
62
63
64
65
66
67
68
69
70
71
76
77
78
79
85
86
87
80
72
73
74
75
81
82
83
84
88
89
CONNECTOR: D-134
AB
PCM
D-134(GR)
HARNESS CONNECTOR:
COMPONENT SIDE
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст