Mitsubishi Pajero Pinin. Manual — part 287
BODY –
Sunroof
42-24
DISASSEMBLY AND REASSEMBLY
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
11
15
Disassembly steps
1. Roof lid glass assembly
2. Weatherstrip
3. Sunroof motor
4. Roof wind deflector panel
5. Roof drip channel
6. Panel stopper
7. Sunshade assembly
8. Guide rail stopper
9. Cable guide casing
10. Side deflector
11. Drive cable assembly
12. Seal
13. Seal
14. Clamp
15. Guide rail sub assembly
42-1
BODY
CONTENTS
GENERAL
2
. . . . . . . . . . . . . . . . . . . . . . . . . .
OUTLINE OF CHANGES
2
. . . . . . . . . . . . . . . . . .
DOOR
2
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING
2
. . . . . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE
8
. . . . . . . . . . . . . . . . . .
Power Window Safety Mechanism
Check
8
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DOOR TRIM AND WATERPROOF
FILM
8
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DOOR GLASS AND REGULATOR
9
. . . . . . . .
BODY –
General/Door
42-2
GENERAL
OUTLINE OF CHANGES
The following service procedures have been added. The other items are the same as before.
D
Troubleshooting
D
On-vehicle service
D
Door trim and waterproof film inspection
D
Door glass and regulator inspection
DOOR
TROUBLESHOOTING
The central door locking is controlled by the Smart Wiring System (SWS). For troubleshooting, refer to
GROUP 54B – Troubleshooting.
DIAGNOSIS FUNCTION
INPUT SIGNAL CHECK POINTS <VEHICLES WITH ETACS-ECU>
1.
Connect the MUT-
II
or a voltmeter to the diagnosis connector to check input signal. (Refer to GROUP
00 – How to Use Troubleshooting/Inspection Service Points.)
2.
The following input signals can be checked:
Door lock actuator
D
LOCK
D
UNLOCK
NOTE
If all the input signals cannot be check by using the MUT-
II
, the diagnosis circuit may be defective.
INSPECTION CHART FOR TROUBLE SYMPTOMS
POWER WINDOWS
Symptom
Inspection
procedure
Reference
page
None of power window switches can operate any of windows.
1
42-3
Power window main switch can not operate any of windows. (However, each power
window sub-switch can operate window.)
2
42-4
Power window main switch can not operate driver’s window. (However, power window
main switch can operate window except driver’s window.)
3
42-4
Power window main switch can not operate passenger’s window. (However,
passenger’s power window sub-switch can operate passenger’s window.)
4
42-5
Power window main switch can not operate rear door windows. (However, rear power
window sub-switches can operate rear door windows.)
5
42-5
Passenger’s power window sub-switch can not operate passenger’s window.
(However, power window main switch can operate passenger’s window.)
6
42-6
Rear power window sub-switches can not operate rear door windows. (However,
power window main switch can operate rear door windows.)
7
42-7
BODY –
Door
42-3
INSPECTION PROCEDURE FOR TROUBLE SYMPTOMS
Inspection Procedure 1
None of power window switches can operate any of
windows.
Probable cause
Power window relay, power window relay drive circuit or ETACS-ECU may be defective.
D
Malfunction of power window relay
D
Malfunction of ETACS-ECU
D
Malfunction of junction block
D
Malfunction of wiring harness or connector
OK
Check trouble symptoms.
NG
Check the harness wire between fusible
link No.4 and junction block.
OK
Check trouble symptoms.
NG
Replace the junction block.
OK
Replace the ETACS-ECU.
OK
Check continuity at power window relay
connector C-71 and junction block con-
nector C-74.
D
Disconnect the connector and
measure at harness side.
D
Continuity between terminal 4 of
C-71 and terminal 1 of C-74
OK: Continuity
NG
Check the following connectors:
C-71, C-74
NG
Repair
OK
Measure at ETACS-ECHO connector
C-82.
D
Disconnect the connector and
measure at harness side.
D
Voltage between 8 and body earth
OK: System voltage
NG
Check the following connectors:
C-71, C-72, C-82
NG
Repair
Check power window relay continuity.
NG
Replace
Check trouble symptoms.
Repair
NG
OK
Replace the junction block.
NG
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст