Mitsubishi Galant (2004+). Manual — part 1050
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-1017
STEP 3. Check for open circuit and short circuit to ground
and harness damage between generator connector B-116
(terminal No. 1) and PCM connector B-23 (terminal No.
132).
Q: Is the harness wire in good condition?
YES : Replace the PCM. Then confirm that the malfunction
symptom is eliminated.
NO : Repair it. Then confirm that the malfunction symptom
is eliminated.
AK303884
2
1
3
4
AB
CONNECTOR: B-116
B-116 (GR)
HARNESS
CONNECTOR:
COMPONENT SIDE
127 126 125 124 123 122 121
133 132 131 130 129 128
140 139 138 137 136 135 134
146 145 144 143 142 141
153 152 151 150 149 148 147
AK303058
HARNESS CONNECTOR:
COMPONENT SIDE
CONNECTOR: B-23
B-23
PCM
AB
AIR CLEANER
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-1018
INSPECTION PROCEDURE 27: Fans (radiator fan, A/C condenser fan) are inoperative
.
COMMENT
• The fan control relay is controlled by the power
transistor inside the PCM turning "ON" and
"OFF".
.
TROUBLESHOOTING HINTS (The most likely
causes for this code to be set are:)
• Malfunction of the fan control relay.
• Malfunction of the fan condenser fan relay.
• Malfunction of the radiator fan relay.
• Malfunction of the condenser fan motor.
• Malfunction of the radiator fan motor.
• Improper connector contact, open or shorted har-
ness wire.
• PCM failed.
RED-WHITE
AK303260
5
POWERTRAIN
CONTROL
MODULE (PCM)
RADIATOR
FAN RELAY
WHITE-RED
WHITE-RED
CONDENSER
FAN RELAY
BLUE-ORANGE
10
FAN CONTROL
RELAY
B-19
1 2 3 4
5 6 7
8 9 10 11
12 13 14
15 16 17 18
AK303147
CONNECTOR: B-19
PCM
AB
AIR CLEANER
B-19 (B)
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-1019
DIAGNOSIS
Required Special Tools:
• MB991958: Scan tool (MUT-III Sub Assembly)
• MB991824: V.C.I.
• MB991827: USB Cable
• MB991910: Main Harness A
STEP 1. Check harness connector B-19 at PCM for
damage.
Q: Is the harness connector in good condition?
YES : Go to Step 2.
NO : Repair or replace it. Refer to GROUP 00E, Harness
Connector Inspection
. Then confirm that the
malfunction symptom is eliminated.
AK303153
4 3 2 1
7 6 5
9 8
11 10
14 13 12
18 17 16 15
CONNECTOR: B-19
PCM
AB
AIR CLEANER
HARNESS CONNECTOR:
COMPONENT SIDE
B-19 (B)
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-1020
STEP 2. Check the fan condition.
(1) Disconnect the B-19 at PCM connector.
(2) Turn the ignition switch to the "ON" position.
(3) Check the fan condition.
• When the terminal No.10 is grounded by the jumper
cable, the radiator and condenser fans should run.
• When the terminal No.10 is grounded first and then both
of the terminal No.10 and No.5 are grounded next,
check that the rotation speed of fan is higher than the
rotation speed when the terminal No.10 is grounded.
(4) Turn the ignition switch to the "LOCK" (OFF) position.
Q: Is the fan condition normal?
YES : Go to Step 3.
NO : Refer to GROUP 14, Symptom Chart
STEP 3. Using scan tool MB991958, check data list item 21:
Engine Coolant Temperature Sensor.
CAUTION
To prevent damage to scan tool MB991958, always turn the
ignition switch to the "LOCK" (OFF) position before con-
necting or disconnecting scan tool MB991958.
(1) Connect scan tool MB991958 to the data link connector.
(2) Start the engine and run at idle.
(3) Check the following items in the data list. Refer to Data List
Reference Table
a. Item 21 Engine Coolant Temperature Sensor.
(4) Turn the ignition switch to the "LOCK" (OFF) position.
Q: Is the sensor operating properly?
YES : Go to Step 4.
NO : Repair and replace. Then confirm that the malfunction
symptom is eliminated.
AK303257
1 2 3 4
5 6 7
8 9 10 11
12 13 14
15 16 17 18
B-19 HARNESS CONNECTOR:
COMPONENT SIDE
AB
AK303259
1 2 3 4
5 6 7
8 9 10 11
12 13 14
15 16 17 18
B-19 HARNESS CONNECTOR:
COMPONENT SIDE
AB
AK303804AB
MB991910
DATA LINK
CONNECTOR
MB991824
MB991827
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст