Mitsubishi Galant (2004+). Manual — part 907
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-445
DTC P0182: Fuel Tank Temperature Sensor Circuit Low Input
1
2 3
4
5
22
21
23 24 25
26 27 28 29
30 31 32 33 34
35 36 37 38
39 40 41 42 43
AK303837
POWERTRAIN CONTROL
MODULE (PCM)
Fuel Tank Temperature Sensor Circuit
7
3
1
BLA
CK
D-18
(MU802058)
41
FUEL TANK TEMPERATURE SENSOR
(INTEGRATED IN FUEL PUMP MODULE)
C-25
5 V
GRA
Y
-
GREEN
GRA
Y
-
GREEN
B-20
1 2
3 4
6
5
7 8
15 16
14
13
11 12
10
9
AK303085
CONNECTOR: B-20
PCM
AB
AIR CLEANER
B-20
AK303838AB
C-25
CONNECTOR: C-25
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-446
.
CIRCUIT OPERATION
• 5-volt voltage is applied to the fuel tank tempera-
ture sensor output terminal (terminal No. 3) from
the PCM (terminal No. 41) via the resistor in the
PCM.
• The fuel tank temperature sensor output voltage
increases when the resistance increases and
decreases when the resistance decreases. The
ground terminal (terminal No. 1) is grounded to
the vehicle body.
.
TECHNICAL DESCRIPTION
• The fuel tank temperature sensor converts the
fuel tank temperature to a voltage.
• The PCM detects the fuel tank temperature with
this output voltage.
.
DESCRIPTIONS OF MONITOR METHODS
Fuel tank temperature sensor output voltage is out of
specified range.
.
MONITOR EXECUTION
Continuous
.
MONITOR EXECUTION CONDITIONS (Other
monitor and Sensor)
Other Monitor (There is no temporary DTC stored
in memory for the item monitored below)
• Not applicable
Sensor (The sensor below is determined to be
normal)
• Engine coolant temperature sensor
• Intake air temperature sensor
.
AK303839AB
CONNECTOR: D-18
SERVICE
HOLE
FUEL TANK TEMPERATURE SENSOR
(INTEGRATED IN FUEL PUMP MODULE)
D-18 (GR)
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-447
DTC SET CONDITIONS
Logic Flow Chart
.
Check Conditions
• 2 seconds or more have passed since the engine
starting sequence was completed.
Judgement Criteria
• Sensor output voltage has continued to be 0.1
volt or lower for 2 seconds.
.
OBD-II DRIVE CYCLE PATTERN
Refer to Diagnostic Function
− OBD-II Drive Cycle −
Procedure 6
.
.
TROUBLESHOOTING HINTS (The most likely
causes for this code to be set are:)
• Fuel tank temperature sensor failed.
• Shorted fuel tank temperature sensor circuit or
connector damage.
• PCM failed.
DIAGNOSIS
Required Special Tools:
• MB991958: Scan Tool (MUT-III Sub Assembly)
• MB991824: V.C.I.
• MB991827: USB Cable
• MB991910: Main Harness A
START
MONITORING
CONDITIONS
END
NO
NO
NO
YES
YES
YES
MALFUNCTION
GOOD
OUTPUT VOLTAGE
< 0.1V
CONTINUOUS
FAILURE FOR
2secs
OUTPUT VOLTAGE
> 4.6V
NO
YES
AK302030
MULTIPORT FUEL INJECTION (MFI) DIAGNOSIS
TSB Revision
MULTIPORT FUEL INJECTION (MFI) <2.4L ENGINE>
13A-448
STEP 1. Using scan tool MB991958, check data list item
4A: Fuel Tank Temperature Sensor.
CAUTION
To prevent damage to scan tool MB991958, always turn the
ignition switch to the "LOCK" (OFF) position before con-
necting or disconnecting scan tool MB991958.
(1) Connect scan tool MB991958 to the data link connector.
(2) Turn the ignition switch to the "ON" position.
(3) Set scan tool MB991958 to the data reading mode for item
4A, Fuel Tank Temperature Sensor.
• Approximately the same as the ambient air temperature
when the engine is cooled.
(4) Turn the ignition switch to the "LOCK" (OFF) position.
Q: Is the sensor operating properly?
YES : It can be assumed that this malfunction is intermittent.
Refer to GROUP 00, How to Use
Troubleshooting/Inspection Service Points
NO : Go to Step 2.
STEP 2. Check the fuel tank temperature sensor.
(1) Disconnect the fuel tank temperature sensor connector
D-18.
(2) Measure the resistance between terminal No. 1 and No. 3
of the fuel tank temperature sensor.
Standard value:
0.5
− 12.0 kΩ
Q: Is the measured resistance between 0.5 and 12.0 k
Ω?
YES : Go to Step 3.
NO : Replace the fuel tank temperature sensor. Then go to
Step 5.
AK303804AB
MB991910
DATA LINK
CONNECTOR
MB991824
MB991827
AK303840
1
2
3
4
5
SERVICE
HOLE
AB
CONNECTOR: D-18
D-18 (GR)
HARNESS
CONNECTOR:
COMPONENT SIDE
1
2 3
4
5
AK203165
FUEL TANK TEMPERATURE
SENSOR CONNECTOR
AB
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст