Mitsubishi Evolution X. Manual — part 326

MAINTENANCE SERVICE

TSB Revision

GENERAL

00-79

22. REAR AXLE OIL (FOR DIFFERENTIAL PART)
(CHANGE)

M1001007200118

1. Remove the filler plug.
2. Remove the drain plug and drain oil.
3. Install the drain plug, and tighten it to the specified torque.

Tightening torque: 32

± 2 N⋅ m (23 ± 2 ft-lb)

4. Fill the specified gear oil up to the bottom of the filler plug

hole.

Specified gear oil: MITSUBISHI Genuine DIA QUEEN
Multi gear oil LS

Amount to use: 0.55

± 0.02 dm

3

(0.58

± 0.02 qt)

5. Install the filler plug, and tighten it to the specified torque.

Tightening torque: 49

± 10 N⋅ m (37 ± 7 ft-lb)

23. REAR AXLE OIL (FOR TORQUE TRANSFER
MECHANISM PART) (CHANGE)

M1001007500164

1. Remove the filler plug.
2. Remove the drain plug and drain oil.
3. Install the drain plug, and tighten it to the specified torque.

Tightening torque: 32

± 2 N⋅ m (23 ± 2 ft-lb)

4. Fill the specified gear oil up to the bottom of the filler plug

hole.

Specified gear oil: DIAMOND ATF-SP III

Amount to use: 0.55

− 0.60 dm

3

(0.58

− 0.63 qt)

5. Install the filler plug, and tighten it to the specified torque.

Tightening torque: 49

± 10 N⋅ m (37 ± 7 ft-lb)

24. TIRES (ROTATE)

M1001008900529

Rotate tires regularly to equalize tire wear and help extend tire
life. Recommended tire rotation is every 12,000 km (7,500
miles).
Timing for the rotation may vary according to vehicle condition,
road surface conditions, and individual driver's habits.
When rotating tires, check for uneven wear, damage, and
wheel alignment. Abnormal wear is usually caused by incorrect
tire pressure, improper wheel alignment, out-of balance
wheels, or severe braking.
The first rotation is the most important, to achieve more uniform
wear for all tires on the vehicle.

AC705198AC

Filler plug

Drain plug

AC705199AC

Filler plug

Drain plug

AC000120

MAIN SEALANT AND ADHESIVE TABLE

TSB Revision

GENERAL

00-80

25. AIR PURIFIER FILTER (REPLACE)

M1001009000143

1. Remove the glove box (Refer to GROUP 52A

− glove box,

P.52A-6

).

2. Loosen the two lugs as shown to replace the clean air filter.
3. Install the glove box.

MAIN SEALANT AND ADHESIVE TABLE

M1001003800516

AC611715AB

Application

3M

™/three bond No.

Loctite

®/

permatex

®No.

ENGINE AND
DRIVETRAIN

Between rocker cover,
cylinder head and timing
chain case.

Three bond 1217G
(Mitsubishi Genuine Part
No.1000A923), Three bond
1227D (Mitsubishi Genuine
Part No.MZ100792)

-

Between cylinder head
gasket. Between timing chain
case.

Three bond 1217G
(Mitsubishi Genuine Part
No.1000A923)

-

Between oil pan

Three bond 1217G
(Mitsubishi Genuine Part
No.1000A923), Three bond
1227D (Mitsubishi Genuine
Part No.MZ100792), Three
bond 1207F (Mitsubishi
Genuine Part No.MD970389)

Loctite

®5971,

Loctite

®5900,

Loctite

®5970

Between engine oil pressure
switch

Three bond 1215, Three
bond 1212D

-

Between engine coolant
temperature switch

Three bond 1324

Loctite

®262

WEATHERSTRI
PPING FOR
GLASS

Between tempered glass,
body flanges, and
weatherstrip

3M

™ AAD Part No. 8509 Auto

Bedding and Glazing
Compound or 3M

™ AAD Part

No. 8633 Windo-weld
Resealant

-

WEATHERSTRI
PPING FOR
GLASS

Between laminated glass and
weatherstrip

3M

™ AAD Part No. 8633

-

MAIN SEALANT AND ADHESIVE TABLE

TSB Revision

GENERAL

00-81

INTERIORS

Adhesive of vinyl chloride
cloth

3M

™ AAD Part No. 8088

General Trim Adhesive or
3M

™ AAD Part No. 8064

Vinyl Trim Adhesive

Permatex

® Vinyl Repair

Kit No.81786

Adhesion of door
weatherstrip

3M

™ AAD Part No. 8001

(yellow) or 3M

™ AAD Part

No. 8008 (black) Super
Weatherstrip Adhesive or
3M

™ AAD Part No. 8011

Black Weatherstrip Adhesive

Permatex

® Super Black

Weatherstrip Adhesive
No.82, 81850

Sealing of various grommets
and packing

3M

™ AAD Part No. 8509 or

3M

™ AAD Part No. 8678

-

Adhesion of headliners and
various interior decorative
materials

3M

™ AAD Part No. 8088

General Trim Adhesive or
3M

™ AAD Part No. 8090

Super Trim Adhesive

Permatex

® Spray

Adhesive No.82019

BODY
SEALANTS

Sealing of sheet metal joints,
drip rail, floor, side panels,
trunk, front panel, tail gate
hinge

3M

™ AAD Part No. 8531

Heavy Drip-Check Sealer
(gray) or 3M

™ AAD Part No.

8302 Ultrapro Autobody
Sealant (clear) or 3M

™ AAD

Part No. 8361 Urethane A/B
Sealant (gray or white)

-

Miscellaneous body sealants
(original mounted
w/adhesive tape)

• Waterproof door film

• Fender panel

• Splash shield

• Mud guard

• Rear combination lamp

3M

™ AAD Part No. 8633

Windo-weld Resealant

-

Fuel Tank and Pad

3M

™ AAD Part No. 8088

General Trim Adhesive or
3M

™ AAD Part No. 8090

Super Trim Adhesive

Permatex

® Spray

Adhesive No.82019

Application

3M

™/three bond No.

Loctite

®/

permatex

®No.

MAIN SEALANT AND ADHESIVE TABLE

TSB Revision

GENERAL

00-82

CHASSIS
SEALANT

Sealant of various flange
faces and threaded parts.
Packing of fuel gauge unit

3M

™ AAD Part No. 8730 High

Strength Red Threadlock or
3M

™ AAD Part No. 8731

Medium Strength Blue
Threadlocker

Loctite

®272 High Strength

and High Temperature
27200

Sealing of various threaded
parts, dust covers.
Differential carrier packing,
dust covers and ball joint and
linkage. Packing and shims
of steering box, sealing of
rack support cover and top
cover of steering box
housing, seal of junction face
of knuckle arm flange

3M

™ AAD Part No. 8672

Ultrapro High Temp. Silicone
Gasket or 3M

™ AAD Part No.

8679 (black) or 3M

™ AAD

Part No. 8678 (black)
Press-In-Place Silicone
gasket strips 3M

™ AAD Part

No. 8661 or 3M

™ AAD Part

No. 8663 Super Silicone
sealant

Permatex

® The Right Stuff

No.25223

QUICK FIX
ADHESIVE

-

3M

™ AAD Part No. 8155

Quick Fix Adhesive

Loctite

®Quicktite Super

Glue 21309

ANAEROBIC
STRONG
SEALING
AGENT

Fixing of various threads,
bolts, screws. Fixing of
differential drive gear bolt,
Connecting of tilt steering
bolt. Fan, pulley, gear Sealing
of small gaps and flange
faces

3M

™ AAD Part No. 8730 High

Strength Threadlocker or
3M

™ AAD Part No. 8731

Medium Strength
Threadlocker

Loctite

®271,

High-Strength
Threadlocker 27100 or
27200

UNDER
COATING
AGENT

-

3M

™ AAD Part No. 8883

Rubberized Undercoating
Aerosol or 3M

™ AAD Part No.

8864 Body Schutz
Undercoating (qt)

Permatex

® Heavy-Duty

Undercoating 81833

Application

3M

™/three bond No.

Loctite

®/

permatex

®No.