Mitsubishi Outlander GS45X. Manual — part 1211
MAINTENANCE SERVICE
TSB Revision
GENERAL
00-87
19. DRIVE SHAFT BOOTS (INSPECT FOR
GREASE LEAKS AND DAMAGE)
M1001003600501
1. These components, which are permanently lubricated at the
factory, do not require periodic lubrication. Damaged seals
and boots should be replaced to prevent leakage or grease
contamination.
2. Inspect the boots for proper sealing, leakage and damage.
Replace them if defective.
20. SUSPENSION SYSTEM (INSPECT FOR
LOOSENESS AND DAMAGE)
M1001009600220
Visually inspect the front/rear suspension components for dete-
rioration and damage. Re-tighten the front/rear suspension
components retaining bolts to specified torque.
21. REAR AXLE OIL (CHECK OIL LEVEL)
M1001007500175
1. Remove the filler plug.
2. Check that gear oil level is not 8 mm (0.3 inch) below the
bottom of filler plug hole.
3. Tighten the filler plug to the specified torque.
Tightening torque: 32
± 2 N⋅m (23 ± 2 ft-lb)
22. TIRES (ROTATE)
M1001008900530
Rotate tires regularly to equalize tire wear and help extend tire
life. Recommended tire rotation is every 12,000 km (7,500
miles).
Timing for the rotation may vary according to vehicle condition,
road surface conditions, and individual driver's habits.
When rotating tires, check for uneven wear, damage, and
wheel alignment. Abnormal wear is usually caused by incorrect
tire pressure, improper wheel alignment, out-of balance
wheels, or severe braking.
The first rotation is the most important, to achieve more uniform
wear for all tires on the vehicle.
AC000109 AC
Boots
AC102739
Gear oil
Upper
limit
Lower
limit
AE
8 mm
(0.3 in)
AC000120
MAIN SEALANT AND ADHESIVE TABLE
TSB Revision
GENERAL
00-88
23. AIR FILTER (REPLACE)
M1001009000154
1. Remove the glove box (Refer to GROUP 52A
− Instrumental
Panel,
2. Loosen the two lugs as shown to replace the clean air filter.
3. Install the glove box.
MAIN SEALANT AND ADHESIVE TABLE
M1001003800635
AC702753AB
Application
3M
™/three bond No.
Loctite
®/
permatex
®No.
ENGINE AND
DRIVETRAIN
Between rocker cover,
cylinder head and timing
chain case. Between cylinder
head gasket. Between timing
chain case.
ThreeBond 1227D,
ThreeBond 1217G
(Mitsubishi Genuine Part
No.1000A923), LOCTITE
5900
-
Between oil pan
ThreeBond 1227D,
ThreeBond 1217G
(Mitsubishi Genuine Part
No.1000A923), ThreeBond
1207F (Mitsubishi Genuine
Part No.1000A992),
LOCTITE 5970, LOCTITE
5900t
Loctite
®5971,
Loctite
®5900,
Loctite
®5970
Between engine oil pressure
switch
Three bond 1215, Three
bond 1212D
-
Between engine coolant
temperature switch
Three bond 1324
Loctite
®262
WEATHERSTRI
PPING FOR
GLASS
Between tempered glass,
body flanges, and
weatherstrip
3M
™ AAD Part No. 08509
Auto Bedding and Glazing
Compound or 3M
™ AAD Part
No. 08633 Windo-weld
Resealant
-
WEATHERSTRI
PPING FOR
GLASS
Between laminated glass and
weatherstrip
3M
™ AAD Part No. 08633
-
MAIN SEALANT AND ADHESIVE TABLE
TSB Revision
GENERAL
00-89
INTERIORS
Adhesive of vinyl chloride
cloth
3M
™ AAD Part No. 08088
General Trim Adhesive or
3M
™ AAD Part No. 08064
Vinyl Trim Adhesive
Permatex
® Vinyl Repair
Kit No.81786
Adhesion of door
weatherstrip
3M
™ AAD Part No. 08001
(yellow) or 3M
™ AAD Part
No. 08008 (black) Super
Weatherstrip Adhesive or
3M
™ AAD Part No. 08011
Black Weatherstrip Adhesive
Permatex
® Super Black
Weatherstrip Adhesive
No.82, 81850
Sealing of various grommets
and packing
3M
™ AAD Part No. 08509 or
3M
™ AAD Part No. 8678
-
Adhesion of headliners and
various interior decorative
materials
3M
™ AAD Part No. 08088
General Trim Adhesive or
3M
™ AAD Part No. 08090
Super Trim Adhesive
Permatex
® Spray
Adhesive No.82019
BODY
SEALANTS
Sealing of sheet metal joints,
drip rail, floor, side panels,
trunk, front panel, tail gate
hinge
3M
™ AAD Part No. 08531
Heavy Drip-Check Sealer
(gray) or 3M
™ AAD Part No.
08302 Ultrapro Autobody
Sealant (clear) or 3M
™ AAD
Part No. 08361 Urethane A/B
Sealant (gray or white)
-
Miscellaneous body sealants
(original mounted
w/adhesive tape)
• Waterproof door film
• Fender panel
• Splash shield
• Mud guard
• Rear combination light
3M
™ AAD Part No. 08633
Windo-weld Resealant
-
Fuel Tank and Pad
3M
™ AAD Part No. 08088
General Trim Adhesive or
3M
™ AAD Part No. 08090
Super Trim Adhesive
Permatex
® Spray
Adhesive No.82019
Application
3M
™/three bond No.
Loctite
®/
permatex
®No.
MAIN SEALANT AND ADHESIVE TABLE
TSB Revision
GENERAL
00-90
CHASSIS
SEALANT
Sealant of various flange
faces and threaded parts.
Packing of fuel gauge unit
3M
™ AAD Part No. 08730
High Strength Red
Threadlock or 3M
™ AAD Part
No. 08731 Medium Strength
Blue Threadlocker
Loctite
®272 High Strength
and High Temperature
27200
Sealing of various threaded
parts, dust covers.
Differential carrier packing,
dust covers and ball joint and
linkage. Packing and shims
of steering box, sealing of
rack support cover and top
cover of steering box
housing, seal of junction face
of knuckle arm flange
3M
™ AAD Part No. 08672
Ultrapro High Temp. Silicone
Gasket or 3M
™ AAD Part No.
8679 (black) or 3M
™ AAD
Part No. 8678 (black)
Press-In-Place Silicone
gasket strips 3M
™ AAD Part
No. 08661 or 3M
™ AAD Part
No. 08663 Super Silicone
sealant
Permatex
® The Right Stuff
No.25223
Seal of brake shoe hold down
pin and wheel cylinder of
drum brakes
3M
™ AAD Part No. 08633
Windo-weld Resealant
-
QUICK FIX
ADHESIVE
-
3M
™ AAD Part No. 08155
Quick Fix Adhesive
Loctite
®Quicktite Super
Glue 21309
ANAEROBIC
STRONG
SEALING
AGENT
Fixing of various threads,
bolts, screws. Fixing of
differential drive gear bolt,
Connecting of tilt steering
bolt. Fan, pulley, gear Sealing
of small gaps and flange
faces
3M
™ AAD Part No. 08730
High Strength Threadlocker
or 3M
™ AAD Part No. 08731
Medium Strength
Threadlocker
Loctite
®271,
High-Strength
Threadlocker 27100 or
27200
UNDER
COATING
AGENT
-
3M
™ AAD Part No. 08883
Rubberized Undercoating
Aerosol or 3M
™ AAD Part
No. 08864 Body Schutz
Undercoating (qt)
Permatex
® Heavy-Duty
Undercoating 81833
Application
3M
™/three bond No.
Loctite
®/
permatex
®No.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст