Mitsubishi Lancer. Manual — part 245
AC304163
<Sedan>
2. Three-diamond mark
<Wagon>
Centre line
of vehicle
Centre line
of vehicle
Trunk lid
press line
Press line
112 mm
53 ± 1 mm
AC
AC304164
<Sedan>
3. Lancer mark
Rear combination
lamp terminal
Trunk lid terminal
Tailgate terminal
33 mm
24 mm
45 ± 1 mm
13 ± 1 mm
19 ± 1 mm
<Wagon>
AB
MARK
EXTERIOR
51-42
2. Installation procedure
(1) Use 3M ATD Part number 8906 or equivalent
to clean the mark installation surfaces on the
body.
CAUTION
When attaching the marks, the ambient tempera-
ture should be 20
− 38° C and the air should be
completely free of dust. If the ambient tempera-
ture is lower than 20
° C, the marks and the places
on the vehicle body where the marks are to be
attached should be heated to 20
− 38° C.
(2) Peel off the protection sheet on the back of the
marks to paste it on the installation position.
DOOR MIRROR
EXTERIOR
51-43
DOOR MIRROR
GENERAL INFORMATION
M1511000100536
DOOR MIRROR OPERATION
Remote Controlled Mirror Operation
• The mirror on the door mirror moves up/down
and left/right by operating the remote controlled
door mirror switch when the ignition switch is in
the "ON" or "ACC" position.
Heated Door Mirror operation
• The defogger relay switch is activated (ON) by
turning on the A/C-ECU built-in defogger switch
when the ignition switch is in the "ON" position.
When the defogger relay is turned ON, power is
supplied to the defogger and door mirror, and the
heater of the door mirror (heated door mirror)
starts operations. The defogger comes with a
timer function and will automatically turn OFF the
switch approximately 11 minutes after the defog-
ger switch is turned ON. The heated door mirror
operations are also terminated along with the
defogger, at this time.
SERVICE SPECIFICATION
M1511000300347
Item
Standard value
Heated door mirror operation current
Ω
5.9
− 7.8
SPECIAL TOOL
M1511000601103
Tool
Number
Name
Use
MB990784
MB990784
Ornament remover
Removal of remote controlled
mirror switch
TROUBLESHOOTING
DIAGNOSIS TROUBLESHOOTING FLOW
M1511014600169
Refer to GROUP 00
− How to Use Troubleshoot-
ing/Inspection Service Points
.
TROUBLE SYMPTOM CHART
M1511015000160
Symptom
Inspection
procedure
Reference
page
All heated door mirrors do not operate
1
The right or left heated door mirror does not operate
2
DOOR MIRROR
EXTERIOR
51-44
SYMPTOM PROCEDURES
Inspection Procedure 1: All Heated Door Mirrors do not Operate
Wire colour code
B : Black LG : Light green G : Green L : Blue W : White Y : Yellow SB : Sky blue
BR : Brown O : Orange GR : Gray R : Red P : Pink V : Violet
REAR WINDOW
DEFOGGER RELAY
REAR WINDOW
DEFOGGER
REMOTE
CONTROLLED
MIRROR (LH)
REMOTE
CONTROLLED
MIRROR (RH)
MIRROR
HEATER
MIRROR
HEATER
NOTE
LH drive vehicles
RH drive vehicles
COMMENTS ON TROUBLE SYMPTOM
The heated door mirrors should works for approxi-
mately 11 minutes when the rear defogger switch is
turned on. If the mirror heater does not work for the
specified period, the defogger relay circuit (heated
door mirror power supply circuit) may be defective.
PROBABLE CAUSE
• Damaged harness wire and connector
DIAGNOSIS PROCEDURE
STEP 1. Check the rear window defogger.
Check that the rear window defogger system should
work normally.
Q: Is the check result normal?
YES :
Go to Step 2.
NO :
Troubleshoot the rear window defogger
(Refer to GROUP 55,
Troubleshooting
DOOR MIRROR
EXTERIOR
51-45
STEP 2. Connector check: C-212 junction block
connector
AC304913
21
7
16 15
17
18
20 19
1
2
3
4
5
6
23 22
24
25
28
26
27
9
8
10
11
14
12
13
Connector: C-212
Harness side
AB
Junction block (Front view)
Q: Is the check result normal?
YES :
Intermittent malfunction (Refer to GROUP
00
− How to Cope with Intermittent
).
NO :
Repair the defective connector.
Inspection Procedure 2: Right or Left Heated Door Mirror does not Operate
Wire colour code
B : Black LG : Light green G : Green L : Blue W : White Y : Yellow SB : Sky blue
BR : Brown O : Orange GR : Gray R : Red P : Pink V : Violet
REAR WINDOW
DEFOGGER RELAY
REAR WINDOW
DEFOGGER
REMOTE
CONTROLLED
MIRROR (LH)
REMOTE
CONTROLLED
MIRROR (RH)
MIRROR
HEATER
MIRROR
HEATER
NOTE
LH drive vehicles
RH drive vehicles
COMMENTS ON TROUBLE SYMPTOM
If either of the heated door mirrors does not work, the
door mirror assembly may be defective.
PROBABLE CAUSES
• Malfunction of the door mirror assembly
• Damaged harness wires and connectors
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст