Dodge Caliber. Manual — part 567
WIRE
STANDARD PROCEDURE - WIRE SPLICING
When splicing a wire, it is important that the correct gage be used as shown in the wiring diagrams.
1. Remove one-half (1/2) inch of insulation from each
wire that needs to be spliced.
2. Place a piece of adhesive lined heat shrink tubing
on one side of the wire. Make sure the tubing will
be long enough to cover and seal the entire repair
area.
3. Place the strands of wire overlapping each other
inside of the splice clip (1).
4. Using crimping tool (1), Mopar p/n 05019912AA,
crimp the splice clip and wires together.
5. Solder (3) the connection (2) together using rosin
core type solder (1) only.
CAUTION: DO NOT USE ACID CORE SOLDER.
6. Center the heat shrink tubing (2) over the joint and
heat using a heat gun. Heat the joint until the tub-
ing is tightly sealed and sealant (1) comes out of
both ends of the tubing.
PM
8W-01 WIRING DIAGRAM INFORMATION
8W - 01 - 21
8W-02 COMPONENT INDEX
Component
Page
Actuator-Recirculation Door . . . . . . . . . . . . . 8W-42
Airbag Squibs . . . . . . . . . . . . . . . . . . . . . . . . 8W-43
Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43
Amplifier-Radio . . . . . . . . . . . . . . . . . . . . . . . 8W-47
Antenna-Global Positioning System . . . . . . . 8W-55
Antenna-Radio . . . . . . . . . . . . . . . . . . . . . . . 8W-47
Antenna-Satellite . . . . . . . . . . . . . . . . . . . . . 8W-47
Assembly-Shift Lever . . . . . . . . . . . . . . . . . . 8W-31
Assembly-Transmission Solenoid/Pressure
Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-31
Assembly-Valve Block . . . . . . . . . . . . . . . . . . 8W-30
Backlite-Electric Heated . . . . . . . . . . . . . . . . 8W-48
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-13
Capacitor-Ignition . . . . . . . . . . . . . . . . . . . . . 8W-30
Cluster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40
Coil-Ignitions . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Control-A/C-Heater . . . . . . . . . . . . . . . . . . . . 8W-42
Data Link Connector . . . . . . . . . . . . . . . . . . . 8W-18
Fan Module-Radiator Cooling . . . . . . . . . . . . 8W-30
Fuse/Relay Block . . . . . . . . . . . . . . . . . . . . . . 8W-11
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-11, 13
Fusible Link . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20
Generator . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-20
Glow Plugs . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Grounds . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-15
Heater-Cabin . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42
Heater-PCV . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Heaters-Seat . . . . . . . . . . . . . . . . . . . . . . . . . 8W-63
Horns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-41
Injectors-Fuel . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Lamp-Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44
Lamp-Cup Holder . . . . . . . . . . . . . . . . . . . . . 8W-44
Lamp-Dome . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-44
Lamp-High Mounted Stop . . . . . . . . . . . . . . . 8W-51
Lamp-License . . . . . . . . . . . . . . . . . . . . . . . . 8W-51
Lamp-Turn Front . . . . . . . . . . . . . . . . . . . . . 8W-52
Lamp-Vanity-Left . . . . . . . . . . . . . . . . . . . . . 8W-44
Lamps-Backup . . . . . . . . . . . . . . . . . . . . . . . 8W-51
Lamps-Fog Front . . . . . . . . . . . . . . . . . . . . . . 8W-50
Lamps-Headlamp . . . . . . . . . . . . . . . . . . . . . 8W-50
Lamps-Park/Turn Front . . . . . . . . . . . . . . 8W-50, 52
Lamps-Side Repeater . . . . . . . . . . . . . . . . . . 8W-52
Lamps-Tail Turn . . . . . . . . . . . . . . . . . . . . . . 8W-52
Lamps-Tail/Stop . . . . . . . . . . . . . . . . . . . . . . 8W-51
Lamps-Tail/Stop/Fog . . . . . . . . . . . . . . . . . . . 8W-51
Latches-Doors . . . . . . . . . . . . . . . . . . . . . . . . 8W-61
Mirror-Inside Rearview . . . . . . . . . . . . . . 8W-49, 55
Mirrors-Outside Rearview . . . . . . . . . . . . . . . 8W-62
Module-All Wheel Drive Control . . . . . . . . . . 8W-31
Component
Page
Module-Anti-Lock Brakes . . . . . . . . . . . . . . . 8W-35
Module-Compass . . . . . . . . . . . . . . . . . . . . . . 8W-40
Module-Electronic Overhead . . . . . . . . . . . . . 8W-49
Module-Engine Control . . . . . . . . . . . . . . . . . 8W-30
Module-Fuel Pump . . . . . . . . . . . . . . . . . . . . 8W-30
Module-Glow Plug . . . . . . . . . . . . . . . . . . . . . 8W-30
Module-Hands Free . . . . . . . . . . . . . . . . . . . . 8W-55
Module-Heated Seats . . . . . . . . . . . . . . . . . . 8W-63
Module-Intrusion Transceiver . . . . . . . . . . . . 8W-39
Module-Inverter . . . . . . . . . . . . . . . . . . . . . . 8W-41
Module-Occupant Classification . . . . . . . . . . 8W-43
Module-Occupant Restraint Controller . . . . . 8W-43
Module-Powertrain Control . . . . . . . . . . . . . . 8W-30
Module-Sentry Key Remote Entry . . . . . . . . . 8W-39
Module-Steering Control . 8W-33, 41, 43, 44, 47, 50,
Module-Totally Integrated Power . . . . . . . . . 8W-13
Module-Transmission Control . . . . . . . . . . . . 8W-31
Modules-Headlamp Leveling . . . . . . . . . . . . . 8W-50
Motor-Blower . . . . . . . . . . . . . . . . . . . . . . . . . 8W-42
Motor-Sunroof . . . . . . . . . . . . . . . . . . . . . . . . 8W-64
Motors-Windows . . . . . . . . . . . . . . . . . . . . . . 8W-60
Motors-Wiper . . . . . . . . . . . . . . . . . . . . . . . . . 8W-53
Power Outlets . . . . . . . . . . . . . . . . . . . . . . . . 8W-41
Pump-Washer-Windshield . . . . . . . . . . . . . . . 8W-53
Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47, 55
Receiver-Satellite . . . . . . . . . . . . . . . . . . . . . 8W-47
Relay-Cabin Heaters . . . . . . . . . . . . . . . . . . . 8W-42
Relay-Main . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-11
Relays-Radiator Fan . . . . . . . . . . . . . . . . . . . 8W-11
Resistor-Blower Motor . . . . . . . . . . . . . . . . . . 8W-42
Seat Belt-Tensioners . . . . . . . . . . . . . . . . . . . 8W-43
Sensor-Accelerator Pedal Position . . . . . . . . . 8W-30
Sensor-Ambient Air Temperature . . . . . . . . . 8W-42
Sensor-Brake Fluid Level . . . . . . . . . . . . . . . 8W-30
Sensor-Crankshaft Position . . . . . . . . . . . . . . 8W-30
Sensor-Dynamics . . . . . . . . . . . . . . . . . . . . . . 8W-35
Sensor-Engine Coolant Temperatures . . . . . . 8W-30
Sensor-Evaporator Temperature . . . . . . . . . . 8W-42
Sensor-Fuel Temperature . . . . . . . . . . . . . . . 8W-30
Sensor-Intake Air Temperature . . . . . . . . . . . 8W-30
Sensor-Intake Air Temperature/Boost
Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Sensor-Knock . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Sensor-MAP . . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Sensor-Mass Air Flow . . . . . . . . . . . . . . . . . . 8W-30
Sensor-Oil Temperature . . . . . . . . . . . . . . . . 8W-30
Sensor-Steering Angle . . . . . . . . . . . . . . . 8W-35, 65
Sensor-Transmission Range . . . . . . . . . . . . . . 8W-31
PM
8W-02 COMPONENT INDEX
8W - 02 - 1
Component
Page
Sensor-Vehicle Speed . . . . . . . . . . . . . . . . . . . 8W-30
Sensor-Wheel Speed-ABS-Left Front . . . . . . . 8W-35
Sensor-Wheel Speed-ABS-Left Rear . . . . . . . 8W-35
Sensor-Wheel Speed-ABS-Right Front . . . . . . 8W-35
Sensor-Wheel Speed-ABS-Right Rear . . . . . . 8W-35
Sensors Impact . . . . . . . . . . . . . . . . . . . . . . . 8W-43
Sensors Speed . . . . . . . . . . . . . . . . . . . . . . . . 8W-31
Sensors-Camshaft Position . . . . . . . . . . . . . . 8W-30
Sensors-Oxygen . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Sensors-Seat . . . . . . . . . . . . . . . . . . . . . . . . . 8W-43
Siren . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-39
Solenoid-A/C Compressor . . . . . . . . . . . . . . . 8W-42
Solenoid-EVAP Purge . . . . . . . . . . . . . . . . . . 8W-30
Solenoid-Electronically Controlled Clutch . . . 8W-31
Solenoids-Camshaft Position . . . . . . . . . . . . . 8W-30
Speakers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-47
Splices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-70
Starter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-21
Switch-Backup Lamp . . . . . . . . . . . . . . . . . . 8W-51
Switch-Bank . . . . . . . . . . . . . . 8W-35, 43, 50, 52, 63
Component
Page
Switch-Clutch Interlock . . . . . . . . . . . . . . . . . 8W-30
Switch-EVAP System Monitor . . . . . . . . . . . . 8W-30
Switch-Engine Oil Pressure . . . . . . . . . . . . . . 8W-30
Switch-Horn . . . . . . . . . . . . . . . . . . . . . . . . . 8W-41
Switch-Ignition . . . . . . . . . . . . . . . . . . . . . . . 8W-13
Switch-Mirror . . . . . . . . . . . . . . . . . . . . . . . . 8W-62
Switch-Oil Pressure . . . . . . . . . . . . . . . . . . . . 8W-30
Switch-Parking Brake . . . . . . . . . . . . . . . . . . 8W-40
Switch-Security Hood . . . . . . . . . . . . . . . . . . 8W-39
Switch-Speed Control . . . . . . . . . . . . . . . . . . 8W-33
Switch-Stop Lamp . . . . . . . . . . . . . . . . . . . . . 8W-30
Switches-Power Windows . . . . . . . . . . . . 8W-60, 61
Switches-Remote Radio . . . . . . . . . . . . . . . . . 8W-47
Switches-Seat Belt . . . . . . . . . . . . . . . . . . . . 8W-43
Throttle Body . . . . . . . . . . . . . . . . . . . . . . . . 8W-30
Transducer-A/C Pressure . . . . . . . . . . . . . . . . 8W-42
Transponders-Tire Pressure . . . . . . . . . . . . . 8W-40
Valve-EGR Air Flow Control . . . . . . . . . . . . . 8W-30
Valve-Manifold Flow . . . . . . . . . . . . . . . . . . . 8W-30
8W - 02 - 2
8W-02 COMPONENT INDEX
PM
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст