Infiniti G37 Coupe. Manual — part 1061
GLASS LID
RF-69
< ON-VEHICLE REPAIR >
C
D
E
F
G
H
I
J
L
M
A
B
RF
N
O
P
GLASS LID
Exploded View
INFOID:0000000001746922
1.
Drain hose
2.
Side trim
3.
TORX bolt
4.
Glass lid
5.
TORX bolt
6.
Sunroof motor assembly
7.
Front sunroof bracket (LH/RH)
8.
Rear sunroof bracket (LH/RH)
9.
Sunroof unit assembly
10. Drain connector
JMKIA1266ZZ
RF-70
< ON-VEHICLE REPAIR >
GLASS LID
Removal and Installation
INFOID:0000000001746923
REMOVAL
1.
Remove the side trim.
2.
Remove the TORX bolt (A) and remove glass lid.
INSTALLATION
CAUTION:
After installing the glass lid, peform the leak test and check thet there is no malfunction.
NOTE:
After installation carry out fitting adjustment. Refer to
Install in the reverse order of removal.
Adjustment
INFOID:0000000001826295
Lid Weatherstrip Overlap Adjustment and Surface Mismatch Adjustment
1.
Tilt up glass lid, and then remove side trim.
2.
After loosening glass lid from TORX bolts (left and right), tilt down glass lid.
3.
Adjust glass lid from outside of vehicle so it resembles “A – A”“B – B” "C – C" as shown in the figure.
4.
To prevent glass lid from moving after adjustment, first tighten the TORX bolts of front left, and then
tighten the TORX bolts of rear right.
5.
Tighten remaining TORX bolts, being careful to prevent glass lid from moving.
6.
Tilt glass lid up and down several times to check that it moves smoothly.
NOTE:
JMKIA0029ZZ
PIIB3117J
a
b
A – A
0.6 - 2.2 mm (0.024 - 0.087 in)
-2.3 - 0.7 mm (-0.091 - 0.028 in)
B – B
0.6 - 2.2 mm (0.024 - 0.087 in)
-2.3 - 0.7 mm (-0.091 - 0.028 in)
C – C
0.6 - 2.2 mm (0.024 - 0.087 in)
-2.3 - 0.7 mm (-0.091 - 0.028 in)
GLASS LID
RF-71
< ON-VEHICLE REPAIR >
C
D
E
F
G
H
I
J
L
M
A
B
RF
N
O
P
After adjustment the sunroof unit assembly, perform additional service. Refer to
RF-72
< ON-VEHICLE REPAIR >
SUNROOF MOTOR ASSEMBLY
SUNROOF MOTOR ASSEMBLY
Exploded View
INFOID:0000000001837520
1.
Drain hose
2.
Side trim
3.
TORX bolt
4.
Glass lid
5.
TORX bolt
6.
Sunroof motor assembly
7.
Front sunroof bracket (LH/RH)
8.
Rear sunroof bracket (LH/RH)
9.
Sunroof unit assembly
10. Drain connector
JMKIA1266ZZ
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст