Infiniti EX35. Manual — part 700
EC-542
< ON-VEHICLE REPAIR >
[VQ35HR]
EVAP CANISTER
ASSEMBLY
Assemble in the reverse order of disassembly.
CAUTION:
Always replace O-ring with a new one.
Inspection
INFOID:0000000003133687
Check EVAP canister as follows:
1.
Block port (B).
2.
Blow air into port (A) and check that it flows freely out of port (C).
3.
Release blocked port (B).
4.
Apply vacuum pressure to port (B) and check that vacuum pres-
sure exists at the ports (A) and (C).
5.
Block port (A) and (B).
6.
Apply pressure to port (C) and check that there is no leakage.
PBIB2728E
SERVICE DATA AND SPECIFICATIONS (SDS)
EC-543
< SERVICE DATA AND SPECIFICATIONS (SDS)
[VQ35HR]
C
D
E
F
G
H
I
J
K
L
M
A
EC
N
P
O
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Idle Speed
INFOID:0000000003133688
*: Under the following conditions
• A/C switch: OFF
• Electric load: OFF (Lights, heater fan & rear window defogger)
• Steering wheel: Kept in straight-ahead position
Ignition Timing
INFOID:0000000003133689
*: Under the following conditions
• A/C switch: OFF
• Electric load: OFF (Lights, heater fan & rear window defogger)
• Steering wheel: Kept in straight-ahead position
Calculated Load Value
INFOID:0000000003133690
Mass Air Flow Sensor
INFOID:0000000003133691
*: Engine is warmed up to normal operating temperature and running under no load.
Condition
Specification
No load* (in P or N position)
650
±
50 rpm
4WAS
Condition
Specification
With
No load* (in P or N position)
11
±
5
°
BTDC
Without
No load* (in P or N position)
16
±
5
°
BTDC
Condition
Specification (Using CONSULT-III or GST)
At idle
5 – 35%
At 2,500 rpm
5 – 35%
Supply voltage
Battery voltage (11 – 14 V)
Output voltage at idle
0.8 – 1.1 V*
Mass air flow (Using CONSULT-III or GST)
2.0 – 6.0 g·m/sec at idle*
7.0 – 20.0 g·m/sec at 2,500 rpm*
EM-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
EM
A
EM
N
O
P
CONTENTS
ENGINE MECHANICAL
SYMPTOM DIAGNOSIS . . . . . . . ...
NOISE, VIBRATION AND HARSHNESS
(NVH) TROUBLESHOOTING . . . . . . . .
NVH Troubleshooting - Engine Noise . . . . ....
Use the Chart Below to Help You Find the C
ause of the Symptom . . . . . . . . . . . ..
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precaution for Procedure without Cowl Top Cover
. ..
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . .....
Draining Engine Coolant . . . . . . . . . . ..
Disconnecting Fuel Piping . . . . . . . . . ...
Removal and Disassembly . . . . . . . . . ..
Inspection, Repair and Replacement . . . . . ..
Assembly and Installation . . . . . . . . . ....
Parts Requiring Angle Tightening . . . . . . ...
Liquid Gasket . . . . . . . . . . . . . . ...
Definitions of Bank Names . . . . . . . . . ....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tools . . . . . . . . . . . ..
Commercial Service Tools . . . . . . . . . .
ON-VEHICLE MAINTENANCE . . . . .
DRIVE BELT . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . .
Checking . . . . . . . . . . . . . . . . .
Tension Adjustment . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
AIR CLEANER FILTER . . . . . . . . . ..
Removal and Installation . . . . . . . . . . .
SPARK PLUG . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
CAMSHAFT VALVE CLEARANCE . . . . ..
Inspection and Adjustment . . . . . . . . . ..
COMPRESSION PRESSURE . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
ON-VEHICLE REPAIR . . . . . . . . .
ENGINE COVER . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
DRIVE BELT AUTO TENSIONER AND IDLER
PULLEY . . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
AIR CLEANER AND AIR DUCT . . . . . ...
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
INTAKE MANIFOLD COLLECTOR . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
INTAKE MANIFOLD . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
EXHAUST MANIFOLD . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
EM-2
FUEL INJECTOR AND FUEL TUBE . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
OIL PAN (LOWER) . . . . . . . . . . .
Exploded View (2WD) . . . . . . . . . . ....
Exploded View (AWD) . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
IGNITION COIL, SPARK PLUG AND ROCK-
ER COVER . . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
TIMING CHAIN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
CAMSHAFT . . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
OIL SEAL . . . . . . . . . . . . . . ...
VALVE OIL SEAL . . . . . . . . . . . . . .
VALVE OIL SEAL : Removal and Installation . . .
FRONT OIL SEAL . . . . . . . . . . . . . .
FRONT OIL SEAL : Removal and Installation . ....
REAR OIL SEAL . . . . . . . . . . . . . ...
REAR OIL SEAL : Removal and Installation . . ..
REMOVAL AND INSTALLATION . . . ...
ENGINE ASSEMBLY . . . . . . . . . . .
2WD . . . . . . . . . . . . . . . . . . ...
2WD : Exploded View . . . . . . . . . . . .
2WD : Removal and Installation . . . . . . . .
2WD : Inspection . . . . . . . . . . . . ....
AWD . . . . . . . . . . . . . . . . . . ..
AWD : Exploded View . . . . . . . . . . ....
AWD : Removal and Installation . . . . . . . .
AWD : Inspection . . . . . . . . . . . . ....
DISASSEMBLY AND ASSEMBLY . . . .
ENGINE STAND SETTING . . . . . . . .
Setting . . . . . . . . . . . . . . . . ....
ENGINE UNIT . . . . . . . . . . . . .
Disassembly . . . . . . . . . . . . . . .
Assembly . . . . . . . . . . . . . . . .
REAR TIMING CHAIN CASE . . . . . . .
Exploded View . . . . . . . . . . . . . .
Disassembly . . . . . . . . . . . . . . .
Assembly . . . . . . . . . . . . . . . .
OIL PAN (UPPER) AND OIL STRAINER . . ..
2WD . . . . . . . . . . . . . . . . . . ...
2WD : Exploded View . . . . . . . . . . . .
2WD : Disassembly and Assembly . . . . . . .
2WD : Inspection . . . . . . . . . . . . . .
AWD . . . . . . . . . . . . . . . . . . ..
AWD : Exploded View . . . . . . . . . . ...
AWD : Disassembly and Assembly . . . . . ...
AWD : Inspection . . . . . . . . . . . . ..
CYLINDER HEAD . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ..
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
CYLINDER BLOCK . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ..
Disassembly and Assembly . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . ..
HOW TO SELECT PISTON AND BEARING ...
Description . . . . . . . . . . . . . . .
Piston . . . . . . . . . . . . . . . . .
Connecting Rod Bearing . . . . . . . . . .
Main Bearing . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . .
General Specification . . . . . . . . . . ...
Drive Belt . . . . . . . . . . . . . . . ..
Spark Plug . . . . . . . . . . . . . . .
Intake Manifold . . . . . . . . . . . . . ..
Exhaust Manifold . . . . . . . . . . . . ..
Camshaft . . . . . . . . . . . . . . . ...
Cylinder Head . . . . . . . . . . . . . ..
Cylinder Block . . . . . . . . . . . . . ..
Main Bearing . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст