Infiniti I30 (A33). Manual — part 557
I30 2001 – Quick Reference – Engine
1
I30 2001
Quick Reference
Engine
VQ30DE
Engine Oil
SAE 5W-30 viscosity oil is preferred for all temperatures.
(API grade SG/SH, Energy Conserving I & II or API grade SJ, Energy Conserving)
(ILSAC grade GF-I & GF-II)
With Oil Filter
4 1/4 qt
Without Oil Filter
3 7/8 qt
Tune up
Spark Plugs
(Double Platinum Tip)
Standard Type
PFR5G-11
Hot Type
PFR4G-11
Cold Type
PFR6G-11
Plug Gap
0.043 in. (1.1mm)
Ignition Timing
15
°
±
5
°
btdc
Curb Idle
700
±
50 rpm
Idle Mixture Ratio
3 - 11 % CO
Valve Clearance
Intake
Exhaust
cold
0.010 - 0.013 in
0.011 - 0.015 in
(0.26 - 0.34 mm)
(0.29 - 0.37 mm)
hot
0.012 - 0.016 in
0.012 - 0.017 in
(0.304 - 0.416 mm)
(0.308 - 0.432 mm)
T/Position Sensor
T/V Closed
0.15 - 0.85 V
T/V Open
3.5 - 4.7 V
Idle Voltage
Approx. 0.5 V
Radiator Fill
Coolant Type
Ethylene Glycol
Coolant Capacity
8 1/8 qt
Compression
Standard
185 psi
Minimum
142 psi
Diff Between Cyl.
14 psi
Fuel System
Fuel Pressure @ Idle
Vacuum applied at fuel pressure regulator:
34 psi
Vacuum released at fuel pressure regulator:
43 psi
Recommended Fuel
91 Octane
Fuel Pump
Ω
At 77
°
F (25
°
C)
0.2 - 5.0
Ω
Fuel Injector
Ω
At 68
°
F (20
°
C)
13.5 – 17.5
Ω
Sensors
Mass Air Flow Sen
Supply Volt.
11 - 14 V
Output Volt. Idle
1.2 - 1.8 V
2500 rpm
1.6 - 2.2 V
I30 2001 – Quick Reference – Engine
2
Mass Air Flow
At Idle
2.0 - 6.0 gm/sec
2500 rpm
7.0 -20.0 gm/sec
Coolant Temp Sensor
Ω
68
°
F (20
°
C)
2.1 - 2.9 k
Ω
122
°
F (50
°
C)
0.68 - 1.00 k
Ω
194
°
F (90
°
C)
0.236 - 0.260 k
Ω
HO2S1 Heater
Ω
At 77
°
F (25
°
C)
2.3 - 4.3
Ω
HO2S2 Heater
Ω
At 77
°
F (25
°
C)
2.3 - 4.3
Ω
Intake Air Temp Sensor
68
°
F (20
°
C)
2.1 - 2.9 k
Ω
176
°
F (80
°
C)
0.27 - 0.38 k
Ω
Cam P/Sen Phase
Hitachi
Mitsubishi
At 68
°
F (20
°
C)
1440 - 1760
Ω
2090 - 2550
Ω
Fuel Tank Temp Sensor
68
°
F (20
°
C)
2.3 - 2.7 k
Ω
122
°
F (50
°
C)
0.79 - 0.90 k
Ω
IACV-AAV Valve
Ω
At 68
°
F (20
°
C)
Approx. 22
Ω
Electrical
Ignition System
Firing Order
1-2-3-4-5-6
Battery Specs.
Type USA
80D26L
Capacity (V/AH)
12 V/ 55 AH
Cold Crank Current
582 A
Charging System
Alternator Type
LR1110-725C
Nom. Rated Out
12 V/ 110 A
Reg. Volt
14.1 - 14.7 V
Hot Out Amp
More than 33 A /1300 rpm
More than 81 A /2500 rpm
More than 93 A /5000 rpm
EPA Mileage Estimate
(city/highway)
20/28
I30 2001 – Quick Reference – Engine
3
I30 2001
Quick Reference
Engine
PREPARATION
Make sure that the following parts are in order.
1. Battery
2. Ignition system
3. Engine oil and coolant levels
4. Fuse
5. ECM harness connector
6. Vacuum hoses
7. Air intake system (Oil filler cap, oil level, etc.)
8. Fuel pressure
9. Engine compression
10. Throttle valve
11. Evaporative emission canister purge control valve.
Note:
•
On A/C equipped vehicles, turn A/C "Off" for testing.
•
Transmission should be in "Park" or "Neutral".
•
"CO" probe should be inserted into exhaust approximately 16 inches.
•
Turn off headlamps, heater blower, rear defogger, etc.
•
Front wheels pointed straight.
•
Perform inspection with cooling fans "Off".
I30 2001 – Quick Reference – A/T
4
I30 2001
Quick Reference
A/T
RE4F04B & RE4F04W
A/T Fluid Type
Nissan Matic ’D’
Fluid Capacity
10 qt
A/T Cooler Type
Fin Type Structure
Up-Shift Schedule Range (at normal operating temp.)
Comfort
Half Throttle
Full Throttle
D1
→
D2
24 - 29 mph
36 - 41 mph
D2
→
D3
43 - 48 mph
67 - 72 mph
D3
→
D4
82 - 87 mph
105 - 110 mph
Auto power
D1
→
D2
25 - 30 mph
36 - 41 mph
D2
→
D3
48 - 53 mph
67 - 72 mph
D3
→
D4
82 - 87 mph
105 - 110 mph
Lock-Up Clutch ON
31 - 36 mph (Approx. 1/8 Throttle)
Stall Rpm
R, D, 2, 1 position
2150 - 2450 rpm
Line Pressure
At Curb idle
At Stall rpm
R - Position
112 psi (7.9 kg/cm2)
277 psi (19.5 kg/cm2)
D, 2, 1 - Position
73 psi (5.1 kg/cm2)
178 psi (12.5 kg/cm2)
Shift Solenoids
Gear
Solenoid A
Solenoid B
1st
ON (Closed)
ON (Closed)
2nd
OFF (Open)
ON (Closed)
3rd
OFF (Open)
OFF (Open)
4th
ON (Closed)
OFF (Open)
Solenoid Valves
Resistance
Pin Number
Shift Solenoid A
20 - 40
Ω
2
Shift Solenoid B
5 - 20
Ω
1
Ovr. Clutch Sol.
20 - 30
Ω
3
Line Pres. Sol.
2.5 - 5
Ω
4
T/Conv. Clutch Sol.
5 - 20
Ω
5
ATF Temp Sensor
68
°
F (20
°
C)
1.5 V
176
°
F (80
°
C)
0.5 V
Rev Sensor
At 12 MPH (20 km/h)
450 Hz
Drop Resistor
10 - 15
Ω
Brake Band
Anchor end pin torque
35 - 52 in-lbs.
Number of return turns
2.5
Lock nut torque
23 - 27 ft-lbs.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст