Volkswagen Golf / Golf GTI / Jetta. Manual — part 724
- Fasten spoiler using a screw on each of outer holes
drilled.
Tightening torque (1.5 Nm)
- Pass cable through center rectangular hole inside rear lid
- 1 -
- Apply electrical terminals and connectors following Wiring
harness repair kit VAS 1978 instructions
- Insert wiring into hose - 2 -
- Attach cable into clip - 3 -
- Connect terminal into harness connector and attach into
connector holder - 4 -
Note:
To complete rear lid instalation observe following
information:
Repair Manual, Body Interior, Repair Group 70, Rear lid
trim, Rear lid trim, removing and installing
Rear spoiler with integrated stoplight
13/2/2005
Repair Manual, Body Exterior, Repair Group 55, Hood,
Lids; Rear lid (Jetta)
Removing
Note:
To remove observe instructions on
66-7, Removing
Rear spoiler without rear lid change,
removing and installing
Removing
- Pull cutting wire sideways underneath spoiler as well as
into two pulling handles from Cutting tool V.A.G1351
- Cut spoiler free following direction of - arrows - , until
cutter reaches screws on external drilled holes
- On center of spoiler base, cut without restraints
- Remove attaching screws
Installing
Note:
When reusing an undamaged rear lid, avoid removing all
adhesive residual material on lid
Residual material acts as an adhesive base for newly
applied adhesive sealant
Rear spoiler with integrated stoplight
13/2/2005
- Install stoplight into spoiler
66-7, Stoplight, removing
and installing
- Install spoiler
66-7, Installing
Rear spoiler with integrated stoplight
13/2/2005
66 - 8
Special components of Golf "GTI 337
Edition"/Jetta GLI Sport and Golf R32
Safety precautions
These components have been developed specifically for
technical requirements of Golf "GTI 337 Edition" and Jetta
GLI Sport and R32. Each of these components must be
replaced in any case with corresponding original part.
Without these components, vehicle may not be driven in
open traffic.
Tools
Special tools, testers and auxiliary items
required
Cutting tools for glass V.A.G1351
Special components of Golf "GTI 337 Edition"/Jetta GLI Sport and Golf R32
13/2/2005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст