Volkswagen Golf / Golf GTI / Jetta. Manual — part 743
4. Airbag unit with driver side airbag
igniter -N95-
¡
Because of differing engaging
mechanisms, only steering
wheels and airbag units from
same supplier can be installed.
¡
Removing, three-spoke
steering wheel
69-4, Driver
side airbag unit , removing and
installing (Three-spoke
steering wheel)
¡
Removing, four-spoke steering
wheel
69-4, Driver side
airbag unit , removing and
installing (Four-spoke steering
wheel)
5. Connector
6. Securing plate
Steering wheel, removing and installing
Removing
- Remove driver side airbag unit.
n
Three-spoke steering wheel
69-4, Driver side
airbag unit , removing and installing (Three -spoke
steering wheel)
.
n
Four-spoke steering wheel
69-4, Driver side airbag
unit , removing and installing (Four -spoke steering
wheel)
.
- Turn steering wheel - 1 - to center
position (wheels in straight-ahead
position).
Airbag
13/2/2005
- Remove bolt - 2 - and pull steering
wheel off steering column.
Installing
- Set steering wheel - 1 - on steering
column.
- Center markings for steering wheel and
steering column must align.
- Spiral spring connecting socket and
studs must be positioned into designated
holes in steering wheel base.
- Secure steering wheel with bolt - 2 - ,
tightening torque is 55 Nm.
- Mark bolt with punch indentation after
each loosening procedure.
Airbag
13/2/2005
- If five punch indentations are on bolt, it
must be replaced with a new one.
Airbag spiral spring/return spring with slip
ring -F138-, removing and installing
Note:
n
When removing and installing Airbag spiral
spring/return spring with slip ring -F138- , make sure
that Airbag spiral spring/return spring is set in center
position.
n
A new return ring with slip ring is secured in centered
position with a tie wrap.
Removing
- Remove driver side airbag unit.
Airbag
13/2/2005
n
Three-spoke steering wheel
69-4, Driver side
airbag unit , removing and installing (Three -spoke
steering wheel)
.
n
Four-spoke steering wheel
69-4, Driver side airbag
unit , removing and installing (Four -spoke steering
wheel)
.
- Put wheels in straight-ahead position.
- Remove steering wheel
69-4, Steering wheel, removing
and installing
.
- Remove bolts (Qty. 2) - arrows - .
- Remove upper trim - 1 - for steering column switches.
- Remove bolts (Qty. 3) - arrows - .
- Loosen height adjustment - 2 - for steering wheel.
- Remove lower trim for steering wheel switch - 1 - .
Vehicles with Electronic Stability Program (ESP):
In vehicles with ESP, return spring is a component of
"Steering Angle Sensor -G85-"
Airbag
13/2/2005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст