Volkswagen Golf / Golf GTI / Jetta. Manual — part 741
length into bore of steering wheel pan
from rear (insert screwdriver approx. 45
mm).
- Press screwdriver in direction of - arrow
- . In this case, clamp - 10 - will be
pressed back and catch - 3 - of airbag unit
will reby release.
- Turn steering wheel back 180 and
disengage second catch on opposite side.
- Turn steering wheel - 1 - to center
position (wheels in straight-ahead
position).
Caution!
Electrostatic charges may result in
involuntary deployment of airbag.
Therefore, mechanic must be
electrostatically discharged before
disconnecting ignition- and Ground
(GND) wires. This is done e.g. by
briefly grasping chassis or door
striker.
Airbag
13/2/2005
- Disconnect harness connector from
airbag unit.
Installing
- Connect harness connector for airbag module to steering
wheel pan and press airbag unit into steering wheel.
Note:
n
Only steering wheels and airbag units of same
manufacturer can be installed.
n
Check wher all catches for airbag unit are locked in
steering wheel.
- Switch ignition on.
Caution!
Make sure no one is in vehicle.
Airbag
13/2/2005
- Connect battery Ground (GND) strap
.
Repair Manual, Electrical Equipment, Repair Group 27,
disconnecting and connecting battery
Note:
n
If engine Electronic Control Module (ECM) is subject
to low voltage with ignition on, DTC memory and
Readiness code must be checked
⇒ Repair Manual,
On Board Diagnostic Fuel Injection Ignition, Repair
Group 01.
Drivers side airbag unit, assembly overview
(Three-spoke steering wheel)
Airbag
13/2/2005
1. Steering wheel
¡
Removing
69-4, Steering
wheel, removing and installing
2. Connector
3. Catches
¡
are disengaged from back side
of steering wheel
4. Airbag unit (with Airbag igniter,
driver side -N95-)
¡
Removing
69-4, Driver side
airbag unit , removing and
installing (Three-spoke
steering wheel)
5. Socket-head bolt
¡
55 Nm
¡
coated with locking compound
¡
may be used up to five times
¡
press in a punch indentation
after each installation
6. Securing plate
7. Airbag spiral spring/return spring
with slip ring -F138-
¡
Removing
69-4, Airbag
spiral spring/return spring with
slip ring -F138-, removing and
installing
8. Trim
9. Clip
Driver side airbag unit , removing and
installing (Three-spoke steering wheel)
Removing
Airbag
13/2/2005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст