Volkswagen Golf / Golf GTI / Jetta. Manual — part 740
1. Steering wheel
¡
Removing
69-4, Steering
wheel, removing and installing
2. Connector
3. Catches
¡
Are disengaged from back
side of steering wheel
4. Airbag unit (with Airbag igniter,
driver side -N95-)
¡
Because of differing engaging
mechanisms, only steering
wheels and airbag units from
same supplier can be installed.
¡
Removing and installing
69-
Airbag
13/2/2005
4, Driver side airbag unit ,
removing and installing (Four-
spoke steering wheel)
5. Socket-head bolt
¡
55 Nm
¡
Coated with locking compound
¡
May be used up to five times
¡
Press in a punch indentation
after each installation
6. Securing plate
7. Coil spring for airbag/return
spring with slip ring -F138-
¡
Removing
69-4, Airbag
spiral spring/return spring with
slip ring -F138-, removing and
installing
8. Trim
9. Clip
Driver side airbag unit , removing and
installing (Four-spoke steering wheel)
Airbag
13/2/2005
Note:
n
re are two suppliers for four-spoke
steering wheel with airbag unit. Petri
secures airbag unit in steering wheel
with a rectangular stud - 1 - . TRW
secures airbag unit in steering wheel
with a stepped pin - 2 - .
n
Because of differing engaging
mechanisms, only steering wheels
and airbag units from same supplier
can be installed.
n
Always note component supplier
when ordering replacement parts.
Removing
- Disconnect battery Ground (GND) strap
Airbag
13/2/2005
.
Repair Manual, Electrical Equipment, Repair Group 27,
disconnecting and connecting battery
Caution!
Observe safety precautions for working on airbags
69-4, Safety precautions when working on airbags
.
- Release steering column adjustment.
- Turn steering wheel - 1 - until steering
wheel spoke is in a vertical position. Pull
out steering column entirely and push into
lower position.
- Secure steering column adjustment.
- Insert a screwdriver of approx. 175 mm
Airbag
13/2/2005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст