Volkswagen Golf / Golf GTI / Jetta. Manual — part 1117
92-35
Rear window wiper rest
position, adjusting
Special tools and auxiliary items
needed
VAG 1331 Torque wrench (or
equivalent 5 - 50 Nm)
Gap -a- between wiper rubber and
lower edge of windshield must be:
Wiper arm tightening torque: 15 Nm
Golf: 25 mm
Jetta Wagon: 20 mm
- Loosen and adjust wiper arm to
achieve spec. as necessary.
Rear window wiper [amp] washer system
13/2/2005
92-36
Rear window washer jet, replacing
Removing
- Switch ignition on and briefly operate rear wiper
to bring rear wiper to park position.
- Fold open cover cap -1- and pull off from wiper
arm.
Installing
- Pull spray jet out carefully in direction of arrow
using suitable pliers.
- Slide spray jet into wiper arm shaft onto stop
with spray jet opening facing horizontally
upward.
- Check and adjust spray pattern if necessary
Page 92-37
.
- Replace cover cap.
Rear window wiper [amp] washer system
13/2/2005
92-37
Rear window washer jets,
adjusting
Special tools and auxiliary items
needed
CAUTION!
Washer jets must not be cleaned
opposite to the spray direction,
e.g.: blown through from front.
Note:
Replace jet if spray is irregular or
cannot be adjusted to center of
wiped area.
T10127 Window washer jet
adjusting tool (replaces 3125A)
- Adjust washer jet so that spray is
in center of wiped area.
Rear window wiper [amp] washer system
13/2/2005
92-38
Wiper rubber, removing and
installing
- Using a pair of pliers, press
together both steel strips on
enclosed side of rubber, slide
rubber sideways out of upper clip
and remove rubber complete
(slide rubber through remaining
clips).
- Insert new rubber into lower clips
of wiper blade.
- Insert both strips in the first
groove of the rubber so that the
recesses in the strips face the
rubber and engage in the rubber
lugs of the groove.
- Using pliers press both steel
strips and rubber together and
insert in the upper clips so that
the lugs of the clips on both sides
engage in the retaining slots -
arrow- of the wiper blade rubber.
Rear window wiper [amp] washer system
13/2/2005
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст