Volkswagen Golf / Golf GTI / Golf Variant. Manual — part 22
8 - Spacer
❑ Quantity: 3
3.2
Wiper Blade, Removing and Installing
Caution
Risk of damaging the wiper blade.
♦ Joint-free windshield wipers are very flexible. Only take
hold of the wiper blades in the wiper blade mounting area
in order to lift them away from the rear window.
Removing
– Remove the wiper arm from the rear window.
– Pivot the wiper blade in the direction of -arrow A- from the
windshield wiper arm.
– Push the release button -2-.
– Remove the wiper blade on the wiper blade mount -1- in the
direction of - arrow B- from the windshield wiper arm.
Installing
Install in the reverse order of removal while paying attention to
the following:
The wiper blade must audibly engage in the wiper arm.
3.3
Windshield Wiper Arm, Removing and
Installing
Special tools and workshop equipment required
♦ Puller - Wiper Arm Kit - T10369-
♦ Torque Wrench 1331 5-50Nm - VAG1331-
Removing
– Turn on the ignition.
– Activate “rear wiper” and let the wiper arm run to end position.
– Switch off the ignition and remove the ignition key, if equipped.
– Push together the rear window wiper cap -1- in the direction
of -arrow A-.
– Fold the cap in the direction of -arrow B- and unclip.
– Loosen the nut but do not remove it.
– Install the -T10369/5- on the windshield wiper arm -2-.
– Position the thrust piece -3- on the wiper arm shaft.
– Rotate the bolt -1- clockwise until the wiper arm is removed
from the wiper arm shaft.
– Completely remove the nut -4- and remove the windshield
wiper arm.
Installing
Install in the reverse order of removal while paying attention to
the following:
– Adjust the wiper arm. Refer to
⇒ “3.4 Wiper Arm, Adjusting”, page 78
.
3.4
Wiper Arm, Adjusting
Special tools and workshop equipment required
♦ Torque Wrench 1331 5-50Nm - VAG1331-
Procedure
– Remove the wiper arm. Refer to
⇒ “3.3 Windshield Wiper Arm, Removing and Installing”, page
– Turn on the ignition.
– Activate “rear wipe” and let wiper arm shaft run to end position.
– Turn off the ignition.
– Position the wiper arm with wiper blade installed at the wiper
arm shaft.
– Align the wiper blade on the rear window as follows.
The dimension is the gap between tip of wiper blade and lower
edge of window.
♦ Dimension -a- = 33 + 5 mm.
– Tighten the wiper arm nut.
– Turn on the ignition.
– Activate “rear wiper” and let the wiper arm run to end position.
– Check the wiper arm adjustment again and correct if neces‐
sary.
Tightening Specifications
♦ Refer to
⇒ “3.1 Overview - Rear Window Wiper System”, page 76
3.5
Rear Window Wiper Motor - V12- , Re‐
moving and Installing
Special tools and workshop equipment required
♦ Torque Wrench 1331 5-50Nm - VAG1331-
Removing
– Turn off the ignition and all electrical equipment.
– Remove the ignition key, if equipped.
– Remove the wiper arm. Refer to
– Remove the lower rear lid trim panel. Refer to ⇒ Body Interior;
Rep. Gr. 70 ; Luggage Compartment Trim Panels; Rear Lid
Lower Trim Panel, Removing and Installing .
– Release and disconnect the connector -1-.
– Remove the nuts -2, 3, and 5-.
– Remove the Rear Window Wiper Motor - V12- -4-.
Installing
Install in the reverse order of removal while paying attention to
the following:
– Coat the inside of the seal in the rear window with a rubber-
and plastic-compatible lubricant (polyethylene glycol).
– Make sure the seal fits correctly in the rear window opening.
Marking -1- of seal must align with marking -2- on rear window.
– Adjust the wiper arm. Refer to
⇒ “3.4 Wiper Arm, Adjusting”, page 78
Tightening Specifications
♦ Refer to
4
Rear Window Washer System
⇒ “4.1 Overview - Rear Window Washer System”, page 80
⇒ “4.2 Washer Fluid Reservoir, Removing and Installing”,
page 82
⇒ “4.3 Rear Window Washer Pump, Removing and Installing”,
page 82
⇒ “4.4 Spray Nozzle, Removing and Installing”, page 83
⇒ “4.5 Spray Nozzle, Adjusting”, page 84
4.1
Overview - Rear Window Washer Sys‐
tem
⇒ “4.1.1 Overview - Rear Window Washer System, Sedan, Ex‐
cept GTI”, page 80
⇒ “4.1.2 Overview - Rear Window Washer System, Sedan, GTI”,
page 81
⇒ “4.1.3 Overview - Rear Window Washer System, Wagon”, page
4.1.1
Overview - Rear Window Washer System, Sedan, Except GTI
1 - High-Mounted Brake Lamp
2 - Washer Hose Connection
❑ For the rear window
washer system
3 - Spray Nozzle
❑ Removing and instal‐
ling. Refer to
❑ Adjusting. Refer to
4 - Washer Fluid Hose
❑ In the right side panel to
the rear window washer
system spray nozzle
5 - Washer Fluid Hose
❑ In the engine compart‐
ment to the rear window
washer system spray
nozzle
6 - Windshield and Rear Win‐
dow Washer Pump - V59-
❑ Removing and instal‐
ling. Refer to
❑ With grommet, replace if
damaged.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст