Chrysler Sebring, Stratus sedan, Sebring Convertible. Manual — part 113
Symptom:
*HEADLAMPS INOPERATIVE WITH ALARM TRIPPED (IF EN-
ABLED)
POSSIBLE CAUSES
LOW BEAM HEADLAMPS INOPERATIVE
BODY CONTROL MODULE INTERNAL MALFUNCTION
BODY CONTROL MODULE INTERNAL MALFUNCTION
HEADLAMP DELAY RELAY
JUNCTION BLOCK - OPEN FUSED B(+) CIRCUIT
JUNCTION BLOCK - OPEN HEADLAMP DELAY RELAY CONTROL CIRCUIT
HEADLAMP DELAY RELAY
TEST
ACTION
APPLICABILITY
1
Turn the Low Beam Headlamps on.
Do the Low Beam Headlamps operate properly?
All
Yes
→ Go To 2
No
→ Refer to symptom LOW BEAM HEADLAMPS WILL NOT TURN
ON in the EXTERIOR LIGHTING category.
2
Turn the Headlamps off.
With the DRBIII
t, actuate the Headlamp Delay Relay.
Do the Headlamps flash while actuating the Headlamp Delay Relay?
All
Yes
→ Replace the Body Control Module.
No
→ Go To 3
3
Remove the Headlamp Delay Relay from the Junction Block.
Temporarily remove the Horn Relay from the Junction Block.
Reinstall the Horn Relay in place of the Headlamp Delay Relay.
With the DRBIII
t, actuate the Headlamp Delay Relay.
Do the Headlamps flash while actuating the Headlamp Delay Relay?
All
Yes
→ Replace the Headlamp Delay Relay.
No
→ Go To 4
4
Remove the Horn Relay from the Headlamp Delay Relay location in the Junction
Block.
Reinstall the Horn Relay to its original location.
Measure the voltage of the Fused B(+) circuits at the Headlamp Delay Relay
connector.
Is the voltage above 10.0 volts at each cavity?
All
Yes
→ Go To 5
No
→ Refer to symptom HEADLAMP TIME DELAY INOPERATIVE in
the EXTERIOR LIGHTING category.
437
VEHICLE THEFT/SECURITY
TEST
ACTION
APPLICABILITY
5
Remove the Headlamp Delay Relay from the junction block.
Remove the BCM from the junction block.
Connect a jumper wire between the Fused B(+) circuit and the Headlamp Delay
Relay Control circuit at the Headlamp Delay Relay connector.
Measure the voltage of the Headlamp Delay Relay Control circuit (cavity 5) in the
BCM internal connector.
Is the voltage above 10.0 volts?
All
Yes
→ Go To 6
No
→ Replace the Junction Block.
Perform VTSS VERIFICATION TEST - 1A.
6
Disconnect the jumper wire.
Reinstall the Headlamp Delay Relay in the Junction Block.
Remove the BCM from the junction block.
Measure the voltage of the Headlamp Delay Relay Control circuit (cavity 5) in the
BCM internal connector.
Is the voltage above 10.0 volts?
All
Yes
→ Replace the Body Control Module.
Perform VTSS VERIFICATION TEST - 1A.
No
→ Replace the Headlamp Delay Relay.
Perform VTSS VERIFICATION TEST - 1A.
438
VEHICLE THEFT/SECURITY
*HEADLAMPS INOPERATIVE WITH ALARM TRIPPED (IF ENABLED) —
Continued
Symptom:
*HORNS FAIL TO SOUND WITH ALARM TRIPPED (IF ENABLED)
POSSIBLE CAUSES
HORN CIRCUIT MALFUNCTION
OPEN DOOR AJAR CIRCUIT
BODY CONTROL MODULE INTERNAL MALFUNCTION
TEST
ACTION
APPLICABILITY
1
A failure in the Horn Relay Control circuit, Horn Relay Output circuit, or the Door
Ajar circuits could cause this failure. The Horn Relay Control circuit will be
diagnosed first.
Continue to the Horn Functional Test for further diagnosis.
All
Horn Functional Test.
2
With the DRBIII
t, actuate the HORN RELAY.
Do the Horns sound while actuating the Horn Relay.
All
Yes
→ Go To 3
No
→ Refer to HORNS FAIL TO SOUND symptom in the VTSS cat-
agory.
3
With the DRBIII
t, in Inputs/Outputs, read the following Door/Decklid Ajar Switch
states.
DRV DR AJAR SW
PAS DR AJAR SW
LR DR AJAR SW (4 Door)
RR DR AJAR SW (4 Door)
DECKLID AJAR SW
Do the Door/Decklid Ajar Switch states appear correct?
All
Yes
→ Replace the Body Control Module.
Perform VTSS VERIFICATION TEST - 1A.
No
→ Refer to the appropriate DOOR AJAR test in the DOOR AJAR
catagory.
439
VEHICLE THEFT/SECURITY
Symptom:
*VTSS DOES NOT TRIP FROM DRIVER DOOR
POSSIBLE CAUSES
BODY CONTROL MODULE
INVALID DOOR AJAR INPUT
TEST
ACTION
APPLICABILITY
1
With the DRBIII
t, read the DRV DR AJAR SW status.
Open the driver door.
Does the DRBIII
t display CLOSED?
All
Yes
→ Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
No
→ Refer to symptom DRIVER DOOR AJAR CKT OPEN in the
DOOR AJAR category.
440
VEHICLE THEFT/SECURITY
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст