Chrysler Pacifica. Manual — part 813
(8) Install screw inside arm rest pull cup and close
remote handle trim plug (Fig. 27).
(9) Raise door glass.
(10) Close door.
WATERSHIELD
REMOVAL
(1) Remove door trim panel. (Refer to 23 - BODY/
DOORS - REAR/TRIM PANEL - REMOVAL).
NOTE: Care must be taken when routing electrical
wiring & cables thorough access holes to prevent
tearing of liner material.
(2) Route wiring, window switch, and remote han-
dle cables through watershield.
(3) Pull courtesy light wiring through watershield.
(4) Peel watershield away from adhesive around
perimeter of inner door panel (Fig. 32).
(5) Remove watershield.
INSTALLATION
(1) Place watershield into position (Fig. 32).
NOTE: Care must be taken when routing electrical
wiring & cables thorough access holes to prevent
tearing of liner material.
(2) Pull courtesy light wiring through watershield.
(3) Route wiring, switch bezel, window switch, and
remote handle cables through watershield.
(4) Insure
that
enough
adhesive
remains
to
securely retain the watershield to inner door panel.
Replace as necessary
(5) Install door trim panel. (Refer to 23 - BODY/
DOORS - REAR/TRIM PANEL - INSTALLATION).
Fig. 31 REAR DOOR TRIM PANEL MECHANICAL CONNECTIONS
1 - MECHANICAL CABLE
2 - FERRULE END OF CABLE
3 - DOOR TRIM PANEL
4 - CABLE SLOT
5 - REMOTE HANDLE CABLE END
6 - REMOTE HANDLE CABLE
Fig. 32 DOOR WATERSHIELD
1 - REAR DOOR ASSEMBLY
2 - DOOR HEADER WEATHERSTRIP
3 - PUSH PINS ATTACHING WEATHERSTRIP
4 - PAPER BACKING
5 - DOOR WATERSHIELD
CS
DOORS - REAR
23 - 47
TRIM PANEL (Continued)
WINDOW REGULATOR
REMOVAL
(1) Remove door trim panel. (Refer to 23 - BODY/
DOORS - REAR/TRIM PANEL - REMOVAL).
(2) Remove watershield. (Refer to 23 - BODY/
DOORS - REAR/WATERSHIELD - REMOVAL).
(3) Remove inner belt molding. (Refer to 23 -
BODY/WEATHERSTRIP/SEALS/REAR
DOOR
INNER BELT WEATHERSTRIP - REMOVAL).
(4) Disconnect door glass from lift plate bracket
and tape glass in the up position (Fig. 33). (Refer to
23
-
BODY/DOORS
-
REAR/DOOR
GLASS
-
REMOVAL).
(5) Disconnect wire connector from power window
motor (Fig. 34).
(6) Loosen screws attaching regulator and window
motor to inner door panel (Fig. 35).
(7) Remove regulator from inner door panel (Fig.
36).
Fig. 33 REGULATOR LIFT PLATE AND SPRING CLIP
1 - INSERT FLAT TOOL TO HOLD GLASS IN THE UP POSITION
2 - DOOR GLASS
3 - ATTACHING REGULATOR SCREW(S) TO INNER DOOR
PANEL
4- REAR DOOR REGULATOR LIFT PLATE BRACKET
5 - REGULATOR LIFT PLATE
Fig. 34 POWER WINDOW REGULATOR
1 - DOOR ASSEMBLY
2 - ATTACHING SCREW(S)
3 - REAR DOOR POWER WINDOW REGULATOR
4 - DOOR WIRE HARNESS AND WIRE CONNECTOR TO MOTOR
23 - 48
DOORS - REAR
CS
INSTALLATION
(1) Place regulator into inner door panel (Fig. 36).
(2) Tighten screws attaching regulator and window
motor to inner door panel (Fig. 35). Tighten screws to
9 N·m (80 in. lbs.) torque.
(3) Connect wire connector to power window motor
(Fig. 34).
(4) Connect door glass to lift plate bracket (Fig.
33). (Refer to 23 - BODY/DOORS - REAR/DOOR
GLASS - INSTALLATION).
(5) Install inner belt molding. (Refer to 23 - BODY/
WEATHERSTRIP/SEALS/REAR
DOOR
INNER
BELT WEATHERSTRIP - INSTALLATION).
(6) Install watershield. (Refer to 23 - BODY/
DOORS - REAR/WATERSHIELD - INSTALLATION).
(7) Install door trim panel. (Refer to 23 - BODY/
DOORS - REAR/TRIM PANEL - INSTALLATION).
REAR DOOR QUARTER GLASS
REMOVAL
(1) For rear door quarter glass removal (Refer to
23 - BODY/DOORS - REAR/GLASS RUN CHANNEL
- REMOVAL).
INSTALLATION
(1) For rear door quarter glass installation (Refer
to 23 - BODY/DOORS - REAR/GLASS RUN CHAN-
NEL - INSTALLATION).
Fig. 35 POWER WINDOW REGULATOR AND MOTOR
1 - DOOR ASSEMBLY
2 - DOOR BELT INNER REINFORCEMENT
3 - REGULATOR TO INNER DOOR PANEL ATTACHING SCREWS
4 - DOOR INNER PANEL
5 - DOOR WIRING HARNESS
6 - WINDOW LIFT MOTOR CONNECTOR
7 - WINDOW REGULATOR
Fig. 36 REAR DOOR WINDOW REGULATOR
1 - REAR DOOR WINDOW REGULATOR
2 - WINDOW MOTOR
CS
DOORS - REAR
23 - 49
WINDOW REGULATOR (Continued)
EXTERIOR
TABLE OF CONTENTS
page
page
ACCESSORY DRIVE SPLASH SHIELD
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
. . . . . . . . . . . . . . . . . . . . . . . . . 51
A-PILLAR MOLDING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
. . . . . . . . . . . . . . . . . . . . . . . . . 51
APPLIQUE - OUTSIDE SILL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
. . . . . . . . . . . . . . . . . . . . . . . . . 52
APPLIQUE - ROOF SIDE APERTURE
. . . . . . . . . . . . . . . . . . . . . . . . . 53
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
. . . . . . . . . . . . . . . . . . . . . . . . . 54
BODY SIDE CLADDING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
. . . . . . . . . . . . . . . . . . . . . . . . . 54
COWL PLENUM GRILLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
. . . . . . . . . . . . . . . . . . . . . . . . . 56
EXHAUSTER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
. . . . . . . . . . . . . . . . . . . . . . . . . 56
EXTERIOR NAME PLATES - ADHESIVE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
. . . . . . . . . . . . . . . . . . . . . . . . . 57
EXTERIOR NAME PLATES - TAPE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
. . . . . . . . . . . . . . . . . . . . . . . . . 57
FRONT FENDER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
. . . . . . . . . . . . . . . . . . . . . . . . . 58
FUEL FILL DOOR
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
. . . . . . . . . . . . . . . . . . . . . . . . . 59
GRILLE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
. . . . . . . . . . . . . . . . . . . . . . . . . 60
FRONT WHEELHOUSE SPLASH SHIELD
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
. . . . . . . . . . . . . . . . . . . . . . . . . 61
LUGGAGE RACK
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
. . . . . . . . . . . . . . . . . . . . . . . . . 62
LUGGAGE RACK CROSSBAR
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
. . . . . . . . . . . . . . . . . . . . . . . . . 62
SIDE RAIL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
. . . . . . . . . . . . . . . . . . . . . . . . . 62
RADIATOR CROSSMEMBER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
. . . . . . . . . . . . . . . . . . . . . . . . . 63
RADIATOR CLOSURE PANEL
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
. . . . . . . . . . . . . . . . . . . . . . . . . 64
REAR WHEELHOUSE SPLASH SHIELD
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
. . . . . . . . . . . . . . . . . . . . . . . . . 65
SIDE VIEW MIRROR
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
. . . . . . . . . . . . . . . . . . . . . . . . . 66
SIDE VIEW MIRROR GLASS
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
. . . . . . . . . . . . . . . . . . . . . . . . . 67
SPOILER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
. . . . . . . . . . . . . . . . . . . . . . . . . 67
SILENCER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
. . . . . . . . . . . . . . . . . . . . . . . . . 68
23 - 50
EXTERIOR
CS
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст