Isuzu Rodeo UE. Manual — part 614
8F–29
BODY STRUCTURE
4. Remove upper and lower hinge bolts.
f
Position a wood block under the door for protection
and support the door assembly with hands during
removal or installation.
635RW003
5. Remove door harness connection.
f
Pull the door harness grommet out in order to
disconnect the harness connection.
630RW004
6. Remove front door assembly.
Installation
To install, follow the removal steps in the reverse order,
noting the following points:
1. Align the door fitting to the body by referring to Engine
Hood and Fender.
2. Tighten the door hinge bolts to the specified torque.
Torque : 34 N·m (25 lb ft)
3. Apply chassis grease to the door check arm pin and
the door hinge moving surface.
8F–30
BODY STRUCTURE
Rear Door Assembly
Parts Location
650RW003
Legend
(1) Rear Door Assembly
(2) Lower Hinge Bolt
(3) Door Harness Connection
(4) Door Check Arm Pin
(5) Upper Hinge Bolt
Removal
1. Disconnect the battery ground cable.
2. Apply a setting mark on the body side hinge.
3. Remove door check arm pin.
630RW003
4. Remove upper and lower hinge bolts.
f
Position a wood block under the door for protection
and support the door assembly with hands during
removal or installation.
650RW001
8F–31
BODY STRUCTURE
5. Remove door harness connection.
f
Pull the door harness grommet out in order to
disconnect the door harness connection.
630RW004
6. Remove rear door assembly.
Installation
To install, follow the removal steps in the reverse order,
noting the following points:
1. Align the door fitting to the body by refer to Engine
Hood and Fender in this section.
2. Tighten the door hinge bolts to the specified torque.
Torque : 34 N·m (25 lb ft)
3. Apply chassis grease to the check arm pin and the
door hinge moving surface.
8F–32
BODY STRUCTURE
Front Window Regulator, Glass and Glass Run
Parts Location
635RW005
Legend
(1) Glass Run
(2) Glass
(3) Window Regulator
(4) Waist Seal
(5) Outside Handle
(6) Locking Link
(7) Door Lock Assembly
(8) Waterproof Sheet
(9) Door Trim Panel
(10) Courtesy Light Lens
(11) Speaker Grille
(12) Grip Cover
(13) Inside Handle
(14) Power Window Switch/Window Regulator
Handle
(15) Speaker Assembly
(16) Tweeter
(17) Door Mirror Cover
(18) Door Mirror Assembly
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст