Nissan Qashqai J11. Manual — part 149
LU-56
< REMOVAL AND INSTALLATION >
[R9M]
OIL PUMP
INSTALLATION
CAUTION:
• Before crank the engine, rotate crankshaft by hand to be sure that oil pump chain is correctly install
on the oil pump sprocket.
1.
Install oil pump with the following procedure:
a.
Install oil pump.
CAUTION:
Check that oil pump chain is correctly install on the oil
pump sprocket.
b.
Tighten oil pump mounting bolts (B) in two steps.
c.
Install oil strainer.
CAUTION:
Never reuse oil strainer gasket.
d.
Tighten oil stainer bolt (B).
2.
Install oil pan (lower). Refer to
EM-396, "Removal and Installation"
a.
1st step: 5.0 N·m (0.51 kg-m, 44 in-lb)
2nd step: 25.0 N·m (2.6 kg-m, 18 ft-lb)
: 10.0 N·m (1 kg-m, 7 ft-lb)
E1BIA0659ZZ
SERVICE DATA AND SPECIFICATIONS (SDS)
LU-57
< SERVICE DATA AND SPECIFICATIONS (SDS)
[R9M]
C
D
E
F
G
H
I
J
K
L
M
A
LU
N
P
O
SERVICE DATA AND SPECIFICATIONS (SDS)
SERVICE DATA AND SPECIFICATIONS (SDS)
Periodical Maintenance Specification
INFOID:0000000010284232
ENGINE OIL CAPACITY (APPROXIMATE)
Unit:
(lmp qt)
Engine Oil Pressure
INFOID:0000000010284233
Unit: kPa (bar, kg/cm
2
, psi)
*: Engine oil temperature at 80
°
C (176
°
F)
Drain and refill
With oil filter change
5.5 (4-7/8)
Without oil filter change
5.1 (4-1/2)
Dry engine (Overhaul)
6.6 (5-7/8)
Engine speed
Approximate discharge pressure*
Idle speed
More than 70 (0.7, 0.7, 10)
1,750 rpm
More than 150 (1.5, 1.5 , 22)
4,000 rpm
More than 360 (3.6, 3.7 , 52)
CO-1
ENGINE
C
D
E
F
G
H
I
J
K
L
M
SECTION
CO
A
CO
N
O
P
CONTENTS
ENGINE COOLING SYSTEM
HRA2DDT
PRECAUTION . . . . . . . . . . . ...
PRECAUTIONS . . . . . . . . . . . . ...
Precautions Necessary for Steering Wheel Rota-
tion After Battery Disconnection . . . . . . . ....
Precautions for Removing Battery Terminal . . .....
PREPARATION . . . . . . . . . . .
PREPARATION . . . . . . . . . . . . ...
Special Service Tool . . . . . . . . . . . .....
SYSTEM DESCRIPTION . . . . . . . ..
DESCRIPTION . . . . . . . . . . . . .
Engine Cooling System . . . . . . . . . . .....
SYMPTOM DIAGNOSIS . . . . . . . ...
OVERHEATING CAUSE ANALYSIS . . . . ..
Troubleshooting Chart . . . . . . . . . . . ...
PERIODIC MAINTENANCE . . . . . . .
ENGINE COOLANT . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
Draining . . . . . . . . . . . . . . . . ...
Refilling . . . . . . . . . . . . . . . . ...
Flushing . . . . . . . . . . . . . . . . ...
RESERVOIR TANK CAP . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
RADIATOR . . . . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . ...
RADIATOR . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
COOLING FAN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
WATER PUMP . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
THERMOSTAT . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
WATER OUTLET . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . .
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Periodical Maintenance Specification . . . . . ..
Radiator . . . . . . . . . . . . . . . . ...
Thermostat . . . . . . . . . . . . . . . ..
MR20DD
PRECAUTION . . . . . . . . . . . ..
PRECAUTIONS . . . . . . . . . . . . .
CO-2
PREPARATION . . . . . . . . . . ...
PREPARATION . . . . . . . . . . . . .
Commercial Service Tools . . . . . . . . ....
Lubricant or/and Sealant . . . . . . . . . ....
SYSTEM DESCRIPTION . . . . . . .
DESCRIPTION . . . . . . . . . . . . ...
Engine Cooling System . . . . . . . . . . ..
Engine Cooling System Schematic . . . . . ....
SYMPTOM DIAGNOSIS . . . . . . . .
OVERHEATING CAUSE ANALYSIS . . . .
Troubleshooting Chart . . . . . . . . . . ....
PERIODIC MAINTENANCE . . . . . .
ENGINE COOLANT . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . ...
Draining . . . . . . . . . . . . . . . . ..
Refilling . . . . . . . . . . . . . . . . ...
Flushing . . . . . . . . . . . . . . . . ..
RESERVOIR TANK CAP . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . ...
RADIATOR . . . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . ...
REMOVAL AND INSTALLATION . . . ...
RADIATOR . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
COOLING FAN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Disassembly and Assembly . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
WATER PUMP . . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
THERMOSTAT . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
WATER OUTLET . . . . . . . . . . . ...
Exploded View . . . . . . . . . . . . . ....
Removal and Installation . . . . . . . . . ....
Inspection . . . . . . . . . . . . . . . ...
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . ...
SERVICE DATA AND SPECIFICATIONS
(SDS) . . . . . . . . . . . . . . . . .
Periodical Maintenance Specification . . . . . .
Radiator . . . . . . . . . . . . . . . . ..
Thermostat . . . . . . . . . . . . . . . ..
Water Control Valve . . . . . . . . . . . .
K9K
PRECAUTION . . . . . . . . . . .
PRECAUTIONS . . . . . . . . . . . . .
Precautions for Removing Battery Terminal . . ...
Precaution Necessary for Steering Wheel Rota-
tion after Battery Disconnect . . . . . . . . ...
Precaution for Liquid Gasket . . . . . . . . ...
PREPARATION . . . . . . . . . . ..
PREPARATION . . . . . . . . . . . . .
Special Service Tool . . . . . . . . . . . ...
SYSTEM DESCRIPTION . . . . . . ...
DESCRIPTION . . . . . . . . . . . . ...
Cooling Circuit . . . . . . . . . . . . . . .
SYMPTOM DIAGNOSIS . . . . . . .
OVERHEATING CAUSE ANALYSIS . . . .
Troubleshooting Chart . . . . . . . . . . .
PERIODIC MAINTENANCE . . . . . ...
ENGINE COOLANT . . . . . . . . . . ...
Inspection . . . . . . . . . . . . . . . .
Draining . . . . . . . . . . . . . . . . ...
Refilling . . . . . . . . . . . . . . . . ...
Flushing . . . . . . . . . . . . . . . . ..
RESERVOIR TANK CAP . . . . . . . . ..
Inspection . . . . . . . . . . . . . . . .
RADIATOR . . . . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
REMOVAL AND INSTALLATION . . . ..
RADIATOR . . . . . . . . . . . . . .
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
COOLING FAN . . . . . . . . . . . . ..
Exploded View . . . . . . . . . . . . . .
Removal and Installation . . . . . . . . . . .
Disassembly and Assembly . . . . . . . . .
Inspection . . . . . . . . . . . . . . . .
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст