Ford Falcon. Manual — part 424
501-10-29 Seating 501-10-29
DISASSEMBLY AND ASSEMBLY (Continued)
3. Disconnect wiring plug(s).
7. Undo pre-tensioner mounting bolt.
4. Remove switch assembly from side cover housing
8. Remove pretensioner wiring loom connector
using a flat bladed instrument to dislodge the
through space on top of seat track.
switch assembly.
Memory Module
Disassembly and Assembly
1. Remove Seat from vehicle (Refer to Seats in this
section).
2. Unclip underseat wiring loom retention protecting
cover.
9. Remove
pretensioner
assembly.
Seat Operating Switch
Disassembly and Assembly
1. Remove outer side trims.
3. Unplug the white memory module plugs.
2. Remove outer side cover (Refer to Outer Side
Cover in this section).
G73271 en
501-10-30 Seating 501-10-30
DISASSEMBLY AND ASSEMBLY (Continued)
4. Undo two retaining mounting screws.
4. Turn seat over and undo four cushion retaining
nuts.
5. Remove memory module.
5. Remove front seat cushion from track.
CAUTION: Take care during removal
6. Undo three black J clips (rear and sides).
process not to break off top mounting boss.
Front Seat Cushion (2-way)
Disassembly and Assembly
1. Remove seat from vehicle (Refer to Seats in this
section).
WARNING: Wait at least one minute after
disconnecting the battery ground cable before
disconnecting any supplemental restraint
system electrical connector. Failure to follow
this warning could cause premature
deployment and may result in personal injury.
2. Remove pre-tensioner cable fir tree clips.
NOTE: Leave pretensioner fitted to track.
7. Undo front white J clip.
NOTE: White clip is glued to seat.
3. Remove front seat back (Refer to Front Seat Back
in this section).
8. Remove cover from foam as per seat back foam
disassembly instructions.
Front Seat Cushion (4-way & 6-way
non-memory)
Disassembly and Assembly
1. Perform steps 1,2,3 from 2-way front seat cushion
disassembly.
G73271 en
501-10-31 Seating 501-10-31
DISASSEMBLY AND ASSEMBLY (Continued)
2. Remove three fir tree clips.
3. Perform steps 4,5,6,7,8,9 of front seat cushion
(2-way) disassembly.
Front Seat Cushion (6-way memory)
Disassembly and Assembly
1. Remove seat from vehicle (Refer to Seats in this
section).
2. Unclip wiring loom retention nappy.
3. Remove pre-tensioner cable fir tree clips.
4. Remove front seat back (Refer to Front Seat Back
in this section).
5. Unclip wiring loom clip from cushion frame using
long nose pliers.
6. Undo two memory module mounting screws.
7. Undo the memory module.
8. Per step 3 above on 4-way seat (Refer to Front
Seat Back in this section).
CAUTION: Be careful not to break off top
lug during removal process.
G73275 en
501-11-1
Glass, Frames and Mechanisms
501-11-1
SECTION : 501-11 Glass, Frames and Mechanisms
VEHICLE APPLICATION : 2003.0 BA Falcon
CONTENTS
PAGE
DESCRIPTION AND OPERATION
Glass, Frames and Mechanisms . . . . . . . . . . . . . . . . . . . . . . ..501-11-2
DIAGNOSIS AND TESTING
Glass, Frames and Mechanisms . . . . . . . . . . . . . . . . . . . . . . ..501-11-3
REMOVAL AND INSTALLATION
Window Control Switch . . . . . . . . . . . . . . . . . . . . . . . . . . .501-11-4
Front Door Window Glass . . . . . . . . . . . . . . . . . . . . . . . . . .501-11-4
Rear Door Window Glass — Moveable . . . . . . . . . . . . . . . . . . . . 501-11-5
Rear Door Quarter Window Glass — Sedan . . . . . . . . . . . . . . . . . . 501-11-5
Rear Quarter Glass — Wagon . . . . . . . . . . . . . . . . . . . . . . . ..501-11-6
Rear Door Quarter Glass — LWB . . . . . . . . . . . . . . . . . . . . . . 501-11-7
Rear Door Quarter Glass — Ute . . . . . . . . . . . . . . . . . . . . . . ...501-11-7
Front Door Window Regulator . . . . . . . . . . . . . . . . . . . . . . . ..501-11-8
Rear Door Window Regulator . . . . . . . . . . . . . . . . . . . . . . . ...501-11-8
Fixed (Stationary) Glass Replacement . . . . . . . . . . . . . . . . . . . . .501-11-9
Front Windshield Glass . . . . . . . . . . . . . . . . . . . . . . . . . . .501-11-9
Rear Windshield Glass — Sedan . . . . . . . . . . . . . . . . . . . . . ...501-11-12
Liftgate Glass — Wagon . . . . . . . . . . . . . . . . . . . . . . . . . .501-11-13
Rear Windshield Glass — Ute . . . . . . . . . . . . . . . . . . . . . . . 501-11-13
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст