Chery B11. Manual — part 231
Chery·Maintenance Manual for Oriental Son
Automatic Transmission
Checking Sequence 14
Poor acceleration
Possible cause
Acceleration ability is poor even if the car is
geared down during traveling. The reason is
possibly trouble in engine, brake or clutch.
Engine trouble
Clutch or brake trouble
Checking Sequence 15
ibration
Possible cause
Check the engine
Check the ignition system,
fuel system and main
machine sy tem
Repair, replace
s
V
There is vibration during constant-speed
traveling or acceleration/deceleration at highest
ear. In that case, the reason is possibly
normal pressure of damp clutch or trouble in
engine, damp clutch control solenoid valve,
hydraulic torque converter or valve body.
Abnormal pressure of damp clutch
Engine trouble
Damp clutch control solenoid valve trouble
Hydraulic torque converter trouble
Valve body trouble
g
ab
检查顺序 16
Checking Sequence 16
Check the brake or clutch
Check if there are any
surface burns, damages of
piston seals and interference
by the jacket.
Norma
Abnormal
l
MUT-Ⅱ Actuator test
Serial No. 6 damp clutch control
solenoid valve
Normal: actuation noise can be
heard
Replace damp clutch control solenoid
valve
Does the same problem occur
after the oil temperature sensor is
detached?
Check the engine
Check the control system, ignition
system, fuel system and main machine
system
Oil pressure test (refer to Page 23-
51)
Measure damp clutch pressure
Standard value: refer to Page 23-
52
Disassemble, clean and reassemble the
valve body
Pay special attention to loosened bolts and
damaged O-rings and valve body
Replace the valve body assembly in the
case of damage that can’t be repaired
Replace hydraulic torque
converter assembly
Abnormal
Norma
No
Abnormal
Yes
Normal
l
92
Chery·Maintenance Manual for Oriental Son
Automatic Transmission
Manual-gear-shifting-protective switchgear
Possible cause
system
The reason is possibly trouble in manual-gear-
shifting-protective switchgear circuit, ignition
switch or A/T-ECU.
Manual-gear-shifting-protective switch trouble
Ignition switch trouble
Connector switch
A/T-ECU trouble
Checking Sequence 18
le speed position switchgear system
Possible cause
Id
The reason is possibly trouble in idle speed
osition switch or A/T-ECU.
Idle speed position switch trouble
Connector trouble
A/T-ECU trouble
p
Check the manual-gear-shifting-
protective switch (refer to Page 23-45)
Check the voltage of manual-gear-
shifti
ective switch connector
B-72
Detach the connector and measure
voltage between wiring side Terminal
8 and ground circuit
ng-prot
Normal: storage battery voltage
Check the following
connectors: C-49, C-
56, C-83, C-131, C-
134
Check the following connectors
B-72, C-30
Check the electric wiring
Between manual-gear-
shifting-protective switch
and medium connector
Between medium
connector and the
ignition switch
Check the electric wiring
Between manual-gear-shifting-
protective switch and A/T-ECU
connector
Check fault symptoms
Check the ignition switch
Check fault symptoms
Replace A/T-ECU
Abnormal
Normal
Normal
Abnormal
Abnorm l
a
Normal
Normal
Abnormal
Abnormal
Abnormal
Abnormal
Repair
Repair
Repair
Replace
Repair
Check the idle speed position switch
Replace the throttle position
sensor
Check the following connectors:
B-07 B-29 B-47
Check electric wiring
Bad contact between idle speed
position and A/T-ECU
Check fault symptoms
Replace A/T-ECU
Abnormal
Abnormal
Repair
Repair
Abnormal
Normal
Normal
Normal
93
Chery·Maintenance Manual for Oriental Son
Automatic Transmission
Checking Sequence 19
Double pressure switchgear system
Possible cause
The reason is possibly trouble in double
pressure switch circuit or bad contact of A/T-
ECU
ouble
A/C system trouble
A/T-ECU trouble
Double pressure switch tr
Connector trouble
Checking Sequence 20
Check the double
pressure switch
Check the voltage
between A/T-ECU and
connector C-28
Detach the connector
and check the wiring
side
Ignition switch: ON
A/C switch: ON
Voltage between
Terminal 10 and
ground ci
t
rcui
Normal: storage
battery vo
e
ltag
Check A/C system
Check the following
connectors: A-35,
C-14, C-28, C-67,
C-116
Check fault symptoms
Check A/C system
Replace A/T-ECU
Abnormal
Normal
Abnormal
Normal
Abnormal
Normal
Normal
Abnormal
Abnormal
Repair
Repair
Replace
94
Chery·Maintenance Manual for Oriental Son
Automatic Transmission
95
Car speed sensor system
Possible cause
The reason is possibly car sped sensor circuit
trouble or bad contact of A/T-ECU
Car speed sensor trouble
Connector trouble
A/T-ECU trouble
Check the car speed sensor
Measure at Terminal B-67 of the car
speed sensor
Detach the connector and measure the
wiring side
Voltage between 1 and the ground
circuit (ignition switch: ON)
Normal: storage battery
Voltage between 3 and the ground
circuit (ignition switch: ON)
Normal: 4.8-5.2V
Connection between 2 and the ground
circuit
Normal: connected
Check the following connector: B-67
Check fault symptoms
Check the wiring
between engine-
ECU and car
speed sensor
Replace engine-ECU
Check the following
connectors: C-90, C-
131 C-135
Check fault symptoms
Check wiring between
car speed sensor and
ignition switch connector
Check the ignition switch
Check the following
connector: C-30, C-47
Check fault symptoms
Check the wiring between
engine-ECU and car speed
sensor connector
Replace engine-ECU
Check wiring between car speed sensor
and grounding, and repair if necessary.
Abnormal
Abnormal
Abnormal
Abnormal
Abnormal
Abnormal
Normal
Normal
Abnormal
Normal
Abnormal
Normal
Abnormal
Normal
Abnormal
Abnormal
Normal
Abnormal
Normal
Repair
Repair
Repair
Repair
Repair
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст