Chery A15. Manual — part 145
Continued
Insufficient
cooling or
air flow
(10) Excessive coolant
(11) Air in cooling system
(12)
Condenser fin blocked or deformed
(13) Radiator fan defect
(14) Water in cooling system
(15) Throttle blocked (CCOT valve)
(16) Low compressor speed
(17) Compressor not working
(18) High-pressure pipe flattened or
part blockage
(10) Drain some coolant
(11) Vacuumize system and add new coolant
(12) Clean or replace condenser
(13) Check fan motor and circuit to eliminate fault
(14) Replace coolant tank and repeat vacuumizing
(15) Replace throttle
(16) Check and adjust driving belt M
(17) Check compressor, electromagnetic clutch and
high pressure, low pressure protection switch
and eliminate fault
(18) Clean or replace part
Abnormal
sound of
compressor
(1) Electromagnetic clutch skidding
or damage
(2) Insufficient or excessive coolant
(3) Compressor bearing loose or
worn out
(4) Low cooling oil level in compressor
(5) Internal wear or damage
(1) Adjust electromagnetic clutch clearance and
check electromagnetic clutch coil
(2) Add coolant as required
(3) Replace compressor bearing
(4) Add cooling oil
(5) Replace compressor part or the whole assembly
Section Ten: Special Tools
Air conditioner maintenance tool pack
Service valve for coolant drainage
Coolant adding gauge
Coolant adding hose
Green
Coolant adding hose
Blue
Coolant adding hose
Orange
Disconnecting valve
Adding hose set with disconnecting valves
Please order the whole
set for disconnecting
valves
Electromagnetic clutch removal tool
Electromagnetic clutch retainer
Spring ring pliers
Spring ring pliers
Sealing lip protection
Section Eleven: Introduction to Cooling System Parts
(I). Compressor
Chery A15 car equipped with electric-controlled fuel injection engine uses SD7V16
compressor, whose performance parameters are listed in the table below.
Structure Swashplate
Number of cylinders
7
Cylinder diameter (mm)
29.3
Stroke (mm)
max
min
34.2
2.2
Displacement (cm³/r)
max
min
161.3
10.4
Max. instantaneous rotation speed allowed (r/min)
8000
Max. continuous rotation speed allowed (r/min)
7000
Coolant R134a
Cooling oil volume (cm³)
115±15
Electromagnetic clutch mass (kg)
2.2
Rated voltage (V)
12
Rated power (W)
48
Compressor is driven by engine crankshaft belt wheel through belt M. When the shift lever on
air conditioning control mechanism is placed at cooling position, the electromagnetic clutch
of compressor is engaged, and the main shaft and swashplate are rotated by compressor belt
wheel to activate rocking plate, which rocks to motivate piston and compress low-temperature
and low-pressure gas coolant into high-pressure and high-temperature gas coolant.
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст