Geely EC718, EC718RV, EC715, EC715RV. Manual part — 286
Geely EC718, EC718RV, EC715, EC715RV. Manual part - 286
4.4.5 Removal and Installation
4.4.5.1 Wheel Replacement
Removal Procedure:
4
5
1
2
3
FE04-0001b
1.
Loosen wheel nut.
2.
Lift and support the vehicle.
3.
Remove the wheel nut.
4.
Remove the wheel.
Installation Procedure:
1.
Install the wheel.
2.
Install the wheel nuts according to the sequence 1-5-2-4-3
as shown in the graphic, slightly tighten the nuts.
3.
Lower the vehicle.
4.
Tighten the wheel nuts according to the sequence
1-5-2-4-3 as shown in the graphic.
Torque: 110 Nm (Metric) 81.4 lb-ft (US English)
4.4.5.2 Front Toe Adjustment
Note
Make sure that the vehicle is parked on a even ground.
Make sure that the front wheels are in the straight
position.
Suspension System
Wheels and Tires
4-73
1
2
FE04-0002b
1.
Check both ends of toe settings.
Equipment: Wheel Positioning System
2.
Lift and support the vehicle.
3.
Release rod retaining nuts at both ends.
4.
Clockwise or counter-clockwise rotate the same amount
at both ends to adjust the front toe setting (2).
5.
Tighten the rod retaining nuts at both ends.
4-74
Wheels and Tires
Suspension System
5 Transmission / Axle
5.1 Warnings and Notices. . . . . .5-2
5.1.1 Warnings and Notices. . . . . . . . . . ...5-2
5.2 Differential. . . . . . . . . ...5-3
5.2.1 Specifications. . . . . . . . . . ...5-3
5.2.1.1 Fastener Tightening Specifications. . . . . 5-3
5.2.2 Disassemble View. . . . . . . . . 5-4
5.2.2.1 Disassemble View. . . . . . . . . . . ..5-4
5.2.3 Diagnostic Information and Procedures. .5-
5
5.2.3.1 Fault Symptom Table. . . . . . . . . . .5-5
5.2.4 Removal and Installation. . . . . . ..5-6
5.2.4.1 Differential Disassemble and Assemble. . . .5-6
5.3 Drive Shaft System. . . . . ...5-12
5.3.1 Specifications. . . . . . . . . . .5-12
5.3.1.1 Fastener Tightening Specifications. . . . ..5-12
5.3.2 Disassemble View. . . . . . . . ..5-13
5.3.2.1 Disassemble View. . . . . . . . . . . 5-13
5.3.3 Diagnostic Information and Procedures. .5-
14
5.3.3.1 Fault Symptom Table. . . . . . . . . ...5-14
5.3.4 Removal and Installation. . . . . . 5-15
5.3.4.1 Drive Shaft Replacement. . . . . . . . .5-15
5.3.4.2 Drive Shaft Oil Seal Replacement. . . . . 5-19
5.3.5 Special Tools and Equipment. . . . .5-21
5.3.5.1 Special Tool List. . . . . . . . . . . ...5-21
Transmission / Axle
Table of Contents
5-1
5.1 Warnings and Notices
5.1.1 Warnings and Notices
Assistant Driving Warning
Warning!
Warning: An assistant should drive the vehicle while the
technician checks for the location of the reported
condition. Otherwise, personal injury could result.
Battery Disconnect Warning
Warning!
Warning: Unless directed otherwise, the ignition and
start switch must be in the OFF or LOCK position, and
all electrical loads must be OFF before servicing any
electrical component. Disconnect the negative battery
cable to prevent an electrical spark should a tool or
equipment come in contact with an exposed electrical
terminal. Failure to follow these precautions may result
in personal injury and/or damage to the vehicle or its
components.
Road Test Warning
Warning!
Warning: Road test a vehicle under safe conditions and
while obeying all traffic laws. Do not attempt any
maneuvers that could jeopardize vehicle control. Failure
to adhere to these precautions could lead to serious
personal injury and vehicle damage.
Engine Lifting Notice
Note
Notice: When raising or supporting the engine for any
reason, do not use a jack under the oil pan, any sheet
metal, or the crankshaft pulley. Lifting the engine in an
unapproved manner may cause component damage.
5-2
Warnings and Notices
Transmission / Axle
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст