Geely EC718, EC718RV, EC715, EC715RV. Manual part — 425
Geely EC718, EC718RV, EC715, EC715RV. Manual part - 425
FE11-1811c
6.
Cut the rear window glass adhesive with a thin steel wire.
Note
Wrap both end of the fine steel wire around a wood
handle, operate by with two people to facilitate the
removal.
7.
Removed the adhesive on the rear window glass with a
blade.
8.
Removed the adhesive on the rear window frame with a
blade.
9.
Clean the windshield inner surface with a cloth stained
soaked with industrial ethanol and water mixture with
50/50 volume ratio.
Installation Procedure:
FE11-1806b
1.
Spray the dedicated Geely glass sealant, with 8 mm (0.3
in) width 8 mm (0.3 in) height.
FE11-1807b
2.
With a double-pipe gun evenly apply glass sealant to the
window glass edge to make sure that the sealant width is
even.
3.
With the help of an assistant, install the rear window glass
to the rear window frame.
4.
Press the rear window glass to bond the adhesive to the
seal strip, the rear window glass and the rear window
frame to retain the rear window.
5.
Let adhesive dry 24 h.
6.
Spray water onto the rear window to check for water leaks.
If it leaks, dry the rear window and apply adhesives to the
leaking location. If it still leaks, remove the rear window
and repeat the entire repair procedure.
Body Electric
Glasses / Windows / Mirrors
11-213
7.
Connect the rear window defroster wiring harness
connector.
8.
Install the wiper arms.
9.
Install the hatchback trim panel.
10. Install the high mounted brake lamp.
11. Connect the battery negative cable.
11-214
Glasses / Windows / Mirrors
Body Electric
11.6 Wipers / Washers System
11.6.1 Specifications
11.6.1.1 Fastener Tightening Specifications
Applications
Model
Specifications
Metric (Nm)
US English (lb-ft)
Front Fender Liner Screws
ST4.8
6-8
4.4-6
Washer Fluid Tank Retaining Bolts
M6 × 20
8-11
6-8
Wiper Retaining Bracket
M6 × 20
8-11
6-8
Wiper Motor Bolts
M6 × 20
8-11
6-8
Wiper Arm Connecting Rod Nut
M8
8-9
6-7
Wiper Arm Nut
M8
14-16
10-12
Rear Wiper Motor Bolt
M6 × 20
8-11
6-8
Rear Wiper Arm Nut
M6
8-11
6-8
Body Electric
Wipers / Washers System
11-215
11.6.2 Description and Operation
11.6.2.1 Description and Operation
Wipers / washers system consists of the
following components:
–
Central Controller
–
Wipers / Washers Switch
–
Washer Fluid Tank
–
Washer Pump
–
Wiper Motor
–
Wiper Arm and Connecting Rod Installation
–
IF27 20A Wiper / Washer Switch Fuse
–
Rear Washer Pump (Hatchback)
–
Rear Wiper Motor (Hatchback)
–
Rear Wiper Arm (Hatchback)
–
IF28 10 A Rear Wiper Fuse (Hatchback)
–
Rear Wiper Relay (Hatchback)
Wiper / washer system can achieve high-speed, low speed,
intermittent three kinds of wiper speed, and can wiper switch
off automatically after the reset function.
Front Wiper / Washer System
Front wiper system consists of a wiper motor, linkage, wiper
arm, wiper blades as well as the wiper / washer switch. Front
wiper circuit has a self-cut-off device, which consists of a worm
gear and a cam plate. The device aims at temporarily maintain
the circuit integrity when the wiper / washer switch is off until
the wiper arm is back to the original position. Wiper system
consists of a permanent magnet motor. The front wiper motor
is installed on the front fender and directly connected with the
front wiper rod. The front wiper motor speed has two stages
(high-speed and low speed), and it can operate intermittently.
Wiper switch is a wiper / washer system component. Front
wiper switch is installed on the steering column right side lever.
Windshield Washer System
Windshield washer system consists of a washer fluid tank,
washer pump, hoses, nozzles and wiper / washer switch.
Windshield washer fluid tank is installed below the right front
headlamp assembly, in the front of the right front fender.
Washer pump is retained on the washer fluid tank, which sends
washing liquid through the hose to the two nozzles installed on
the engine hood. Wiper switch is also a washing / washer
switch component.
Rear Wiper / Washer System (Hatchback)
Windshield wiper system consists of a rear wiper motor, wiper
arm and wiper blades. Rear wiper motor is located in the
hatchback, and directly connected to the rear window wiper
arms and equipped with a separate washer pump, hoses and
nozzles. Rear washer system shares the same washer tank
and the same washer pump with the windshield washer
system. Washer pump sends washing fluid through the hose
to the rear nozzle installed on the hatchback. Rear window
washer nozzle passes through the high mounted brake lamp
cover and retained inside this cover.
11-216
Wipers / Washers System
Body Electric
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст