Mitsubishi L200. Manual — part 776
RV METER
CHASSIS ELECTRICAL
54A-471
STEP 10. Check the harness wire between
ignition switch (ACC) and C-171 RV meter
connector terminal No.11.
NOTE:
Prior to the wiring harness inspection, check joint
connector C-127, junction block connectors C-207
and C-208, and repair if necessary.
• Check the IG (ACC) power supply open circuit
and short circuit.
Q: Is the check result normal?
YES :
Refer to ignition switch (
NO :
Retest the system.
AC903856
Connector: C-171 <LHD>
AY
Harness side
C-171 (GR)
AC903868
Connector: C-171 <RHD>
BQ
Harness side
C-171 (GR)
AC903853
Connector: C-127 <LHD>
AE
C-127 (GR)
AC903865
Connector: C-127 <RHD>
AD
C-127 (GR)
AC509934
Connectors: C-207, C-208 <LHD>
Junction block (Front view)
C-207
C-208
C-208
C-207
AB
Harness side
Harness side
AC509936
Connectors: C-207, C-208 <RHD>
C-207
C-208
C-207
Harness side
Harness side
C-208
AB
Junction block
(Front view)
RV METER
CHASSIS ELECTRICAL
54A-472
STEP 11. Measure the voltage at C-171 RV meter
connector.
(1) Disconnect the connector, and measure at the
wiring harness side.
(2) Ignition switch: ON position
(3) Measure the voltage between C-171 RV meter
connector terminal No.26 and body earth
OK: System voltage
Q: Is the check result normal?
YES :
Go to Step 13
NO :
AC903856
Connector: C-171 <LHD>
AY
Harness side
C-171 (GR)
AC903868
Connector: C-171 <RHD>
BQ
Harness side
C-171 (GR)
AC402679
Connector C-171
(Harness side)
GY
RV METER
CHASSIS ELECTRICAL
54A-473
STEP 12. Check the harness wire between
ignition switch (IG1) and C-171 RV meter
connector terminal No.26.
NOTE:
Prior to the wiring harness inspection, check joint
connectors C-132, C-138 and C-137, junction block
connectors C-207 and C-209, and repair if neces-
sary.
• Check the IG (IG1) power supply open circuit and
short circuit.
Q: Is the check result normal?
YES :
Refer to ignition switch (
NO :
Retest the system.
AC903856 AZ
Connectors: C-137, C-138, C-171 <LHD>
C-138 (L)
C-137, C-138
C-171
C-137 (L)
Harness side
C-171 (GR)
AC903868
Connectors: C-137, C-138, C-171 <RHD>
BS
C-138 (L)
C-137, C-138
C-137 (L)
Harness side
C-171
C-171 (GR)
AC903853
Connector: C-132 <LHD>
AC
C-132 (GR)
AC903865
Connector: C-132 <RHD>
AB
C-132 (GR)
AC509934 AS
Connectors: C-207, C-209 <LHD>
Harness side
C-209
C-207
Harness side
C-209
C-207
Junction block (Front view)
AC509936 AN
Connectors: C-207, C-209 <RHD>
Harness side
C-209
C-207
Harness side
C-209
C-207
Junction block (Front view)
RV METER
CHASSIS ELECTRICAL
54A-474
STEP 13. Replace the RV meter temporarily and
retest the system.
Check that the RV meter shows the drive information
when the RV meter is replaced temporarily.
Q: Is the check result normal?
YES :
Replace the RV meter.
NO :
Go to Step 14
STEP 14. Retest the system.
Check that the RV meter RV meter shows the drive
information.
Q: Is the check result normal?
YES :
The procedure is complete.
NO :
Return to Step 1.
Inspection Procedure 2: The drive information is not displayed normally.
CIRCUIT OPERATION
The RV meter calculates, from the calculation value
of the following information, the drive information that
consists of average fuel consumption, possible cruis-
ing distance, and average vehicle speed. If the func-
tion type is set as 2 or 4 by mistake, the RV meter
does not communicate with the engine-ECU. Also,
the RV meter does not display the drive information.
• The vehicle speed signal is calculated from the
vehicle speed pulse received from the vehicle
speed sensor.
• The remaining fuel amount is calculated from the
data received from the fuel gauge unit.
• The fuel injection quantity is calculated from the
fuel injection quantity data received from the
engine-ECU by CAN communication.
COMMENTS ON TROUBLE SYMPTOM
CAN bus line, harness between RV meter and fuel
gauge unit, harness between RV meter and fuel
gauge unit, RV meter, engine-ECU, vehicle speed
sensor, or fuel gauge unit may be faulty.
PROBABLE CAUSES
• Malfunction of the CAN bus line
• Malfunction of the RV meter
• Malfunction of the Engine- ECU
• Malfunction of the fuel gauge unit
RV Meter Drive Information Circuit
RV METER
FUEL
GAUGE
UNIT
Wire colour code
B : Black LG : Light green G : Green L : Blue W : White Y : Yellow SB : Sky blue
BR : Brown O : Orange GR : Grey R : Red P : Pink V : Violet PU : Purple SI : Silver
ENGINE
CONTROL
RELAY
VEHICLE
SPEED
SENSOR
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст