Toyota Tundra. Manual — part 720
STANDARD RESISTANCE TESTER CONNECTION SPECIFIED CONDITION
NG: REPAIR OR REPLACE HARNESS OR CONNECTOR
OK: Go to Next Step
4. INSPECT FRONT POWER WINDOW REGULATOR MOTOR ASSEMBLY RH
a. Remove the motor (see REMOVAL ).
b. Apply battery voltage to connector terminals 1 and 2.
c. Check that the motor gear rotates smoothly as follows.
OK
MOTOR GEAR MEASUREMENT SPECIFIED CONDITION
Tester Connection
Condition Specified Condition
M2-1 (D) - M3-1
Always
Below 1 ohms
M2-4 (U) - M3-2
M2-1 (D) or M3-1 -Body ground
Always
10 kohms or higher
M2-4 (U) or M3-2 - Body ground
Measurement Condition
Specified Condition
Battery positive (+) --> 1
Battery negative (-) --> 2
Motor gear rotates clockwise
Battery positive (+) --> 2
Battery negative (-) --> 1
Motor gear rotates counterclockwise
2009 Toyota Tundra
2009 ACCESSORIES AND EQUIPMENT Windshield/WindowGlass - Tundra
Fig. 19: Inspecting Front Power Window Regulator Motor Assembly RH
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
NG: REPLACE FRONT POWER WINDOW REGULATOR MOTOR ASSEMBLY RH (see
REMOVAL )
OK: Go to Next Step
5. CHECK HARNESS AND CONNECTOR (MASTER SWITCH - FRONT PASSENGER SIDE
SWITCH)
Fig. 20: Identifying N2 Master Switch And M2 Front Passenger Side Switch Connector Terminals
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
a. Disconnect the N2 master switch connector.
b. Disconnect the M2 switch connector.
c. Measure the resistance according to the value(s) in the table below.
Standard resistance
for Regular Cab:
MASTER SWITCH - FRONT PASSENGER SIDE SWITCH (FOR REGULAR CAB)
for Double Cab:
MASTER SWITCH - FRONT PASSENGER SIDE SWITCH (FOR DOUBLE CAB)
Tester Connection
Condition Specified Condition
N2-16 (U) - M2-5 (SU)
Always
Below 1 ohms
N2-18 (D) - M2-2 (SD)
N2-16 (U) or M2-5 (SU) - Body ground
Always
10 kohms or higher
N2-18 (D) or M2-2 (SD) - Body ground
Tester Connection
Condition Specified Condition
N2-16 (U) - M2-5 (SU)
2009 Toyota Tundra
2009 ACCESSORIES AND EQUIPMENT Windshield/WindowGlass - Tundra
for CrewMax:
MASTER SWITCH - FRONT PASSENGER SIDE SWITCH (FOR CREWMAX)
NG: REPAIR OR REPLACE HARNESS OR CONNECTOR
OK: Go to Next Step
6. CHECK POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY
Fig. 21: Identifying N2 Power Window Regulator Master Switch Assembly Connector Terminals
N2-15 (D) - M2-2 (SD)
Always
Below 1 ohms
N2-16 (U) or M2-5 (SU) - Body ground
Always
10 kohms or higher
N2-15 (D) or M2-2 (SD) - Body ground
Tester Connection
Condition Specified Condition
N2-16 (U) - M2-5 (SU)
Always
Below 1 ohms
N2-15 (D) - M2-2 (SD)
N2-16 (U) or M2-5 (SU) - Body ground
Always
10 kohms or higher
N2-15 (D) or M2-2 (SD) - Body ground
2009 Toyota Tundra
2009 ACCESSORIES AND EQUIPMENT Windshield/WindowGlass - Tundra
Courtesy of TOYOTA MOTOR SALES, U.S.A., INC.
a. Remove the master switch (see REMOVAL ).
b. Reconnect the master switch connector.
c. Measure the voltage according to the value(s) in the table below.
Standard voltage
for Regular Cab:
POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY (FOR REGULAR
CAB)
for Double Cab:
POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY (FOR DOUBLE CAB)
for CrewMax:
POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY (FOR CREWMAX)
NG: REPLACE POWER WINDOW REGULATOR MASTER SWITCH ASSEMBLY (see
REMOVAL )
OK: Go TO POWER WINDOWS DO NOT OPERATE AT ALL
REAR POWER WINDOW LH DOES NOT OPERATE WITH REAR POWER WINDOW SWITCH LH
Tester
Connection
Switch Condition
Specified
Condition
N2-16 (U) - N2-7
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> UP
Below 1 V --> 11
to 14 V
N2-18 (D) - N2-7
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> DOWN
Tester
Connection
Switch Condition
Specified
Condition
N2-16 (U) - N2-1
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> UP
Below 1 V --> 11
to 14 V
N2-15 (D) - N2-1
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> DOWN
Tester
Connection
Switch Condition
Specified
Condition
N2-16 (U) - N2-1
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> UP
Below 1 V --> 11
to 14 V
N2-15 (D) - N2-1
(E)
Ignition switch ON, front passenger side door power
window regulator switch OFF --> DOWN
2009 Toyota Tundra
2009 ACCESSORIES AND EQUIPMENT Windshield/WindowGlass - Tundra
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст