Acura CSX. Manual — part 331
*03
*01
02
SNR9A00E16236500000KCAT00
16-27
16-27
Intermediate Shaft Installation
PRESS
B
C
07GAD-PH70201
A
07JAF-SH20400
07965-SD90100
A
B
A
B
6. Install a new outer seal (A) flush with the bearing
support (B) using the support base attachment, the
support base, the 64 mm oil seal driver (C), and a
press.
1. Install a new set ring (A) onto the set ring groove
(B) of the intermediate shaft.
2. Clean the areas where the intermediate shaft
contacts the differential thoroughly with solvent or
brake cleaner, and dry with compressed air.
NOTE: Do not wash the rubber parts with solvent.
3. Insert the intermediate shaft (A) into the differential
until the set ring locks in the groove.
NOTE: Insert the intermediate shaft carefully to
prevent damaging the oil seal (B).
Pack the interior
of the outer seal.
Replace.
Replace.
08/08/21 14:51:48 61SNR030_160_0027
03
04
16-28
Driveline/Axle
A
10 x 1.25 mm
39 N·m (4.0 kgf·m, 29 lbf·ft)
B
10 x 1.25 mm
39 N·m
(4.0 kgf·m,
29 lbf·ft)
8 x 1.25 mm
22 N·m
(2.2 kgf·m,
16 lbf·ft)
4. Install the flange bolt (A) and two shoulder bolts (B).
5. Install the heat shield, and tighten and three bolts.
6. Install the right driveshaft (see page 16-20).
7. Refill the transmission with the recommended
transmission fluid:
• 5-speed manual transmission (see page 13-5)
• 6-speed manual transmission (see page 13-82)
• Automatic transmission (see page 14-232)
8. Check the wheel alignment, and adjust it if
necessary (see page 18-5).
9. Test-drive the vehicle.
08/08/21 14:51:48 61SNR030_160_0028
SNR9A000000000J1601ZAAT00
08/08/21 14:51:48 61SNR030_160_0029
SNR9A000000000J1701ZCAT00
Steering
Steering
EPS (Electrical Power Steering) Components
. . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . ..
. . . . . . . . . . . . . .
. . . .
. . . . . . . . . . .
. . . ...
. . . . . . . . . .
. . . . ...
. . . ..
. . . . . . . . . ...
. . . . . . . . . .
. . . . . . . . . . . ..
. . . . .
. . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . ..
. . . . . . . . . . . . . .
. . . .
. . . . . . . . . . .
. . . ...
. . . . . . . . . .
. . . . ...
. . . ..
. . . . . . . . . ...
. . . . . . . . . .
. . . . . . . . . . . ..
. . . . .
. . . . . .
Special Tools
. 17-2
Component Location Index
. 17-3
Steering Wheel Rotational Play Check
. 17-4
Power Assist Check
. 17-4
Steering Linkage and Gearbox Inspection
. 17-5
Steering Wheel Removal
. 17-6
Steering Wheel Disassembly/Reassembly
. 17-7
Steering Wheel Installation
. 17-8
Column Cover Removal and Installation
. 17-9
Steering Column Removal and Installation
. 17-10
Steering Column Inspection
. 17-14
Steering Lock Replacement
. 17-14
Rack Guide Adjustment
. 17-15
Tie-rod End Ball Joint Boot Replacement
. 17-16
Gearbox Mount Cushion Replacement
. 17-17
. . . . . . . . . .
. . . . . ..
. .
. . . . . . . . . ...
. . . . . . . ..
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . ..
. . . . . . . . . .
. . . . . . .
. . . .
. . . . . . ...
. . . . . . . ...
. . . . . ..
. . . . . . . . . .
. . . . . ..
. .
. . . . . . . . . ...
. . . . . . . ..
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . ..
. . . . . . . . . .
. . . . . . .
. . . .
. . . . . . ...
. . . . . . . ...
. . . . . ..
Component Location Index
. 17-18
General Troubleshooting Information
. 17-19
Memorizing the Torque Sensor Neutral Position
. 17-22
DTC Troubleshooting Index
. 17-23
Symptom Troubleshooting Index
. 17-25
System Description
. 17-26
Circuit Diagram
. 17-30
DTC Troubleshooting
. 17-33
Symptom Troubleshooting
. 17-60
EPS Motor Removal and Installation
. 17-63
Steering Gearbox Removal and Installation
. 17-65
Rack End Removal and Installation
. 17-79
Rack Guide Removal/Installation
. 17-83
EPS Control Unit Removal/Installation
. 17-84
08/08/21 14:53:09 61SNR030_170_0002
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст