Mitsubishi Outlander GS45X. Manual — part 1364
WINDSHIELD WIPER AND WASHER
TSB Revision
EXTERIOR
51-79
>>C<< WIPER BLADE INSTALLATION
CAUTION
Use a curved backing like that shown for the backing of a
wiper blade to ensure sustained wiper wiping perfor-
mance.
INSPECTION
M1511019101991
WINDSHIELD WIPER MOTOR CHECK
Remove the windshield wiper motor and inspect it at the har-
ness connector.
.
WINDSHIELD WIPER MOTOR AT LOW OR HIGH
SPEED OPERATION
Connect the battery to the windshield wiper motor to inspect
the operation of motor rotation at low or high speed.
AC101090
AE
A
A
Wiper blade
Backing
Backing
Section A – A
Wiper
blade
Backing
4
5
3
1
2
4
5
3
1
2
4
5
3
1
2
AC511727AB
Operation check
Low speed
High speed
WINDSHIELD WIPER AND WASHER
TSB Revision
EXTERIOR
51-80
.
WINDSHIELD WIPER MOTOR AT STOP POSITION
OPERATION
1. Connect the battery to the windshield wiper motor as shown
in the illustration (A).
2. Run the windshield wiper motor at low speed, then
disconnect the battery in the middle of the motor rotation
and check to see that the motor stops.
3. Connect the battery to the windshield wiper motor as shown
in the illustration (B).
4. Connect the terminals of the windshield wiper motor
connector as shown in the illustration (B).
5. Check to see that the windshield wiper motor runs at low
speed and then stops at the automatic stop position.
WINDSHIELD WIPER SWITCH CHECK
Check the windshield wiper switch (mist, intermittent, low
speed and high speed) from the ETACS diagnosis codes for
proper operations.(Refer to GROUP 54A, Diagnostic trouble
code chart
4
5
3
1
2
4
5
3
1
2
AC511728
4
5
3
1
2
AB
+5º
-10º
13º
(B) Automatic stop
(A) Low speed
Stop position check
WINDSHIELD WIPER AND WASHER
TSB Revision
EXTERIOR
51-81
WINDSHIELD WASHER
REMOVAL AND INSTALLATION
M1511008201400
AC809563
1,2
1
3
4
5
6
A
A
A
A
AD
Section A – A
Claw
Claw
Rear washer hose
4.0 ± 2.0 N·m
36 ± 17 in-lb
10.5 ± 2.5 N·m
93 ± 22 in-lb
2
Windshield washer nozzle removal
steps
• Connection of windshield washer
hose
1. Windshield washer nozzle assembly
<LH>
2. Windshield washer nozzle assembly
<RH>
Washer hose removal steps
• Splash shield (RH) mounting clips
• Connection of washer nozzle/washer
motor
3. Windshield washer hose
Washer tank removal steps
• Engine room under cover front (Refer
to
)
• Splash shield (RH) mounting clips
• Connection of front/rear washer hose
4. Windshield washer tank assembly
5. Windshield washer motor
6. Windshield washer tank
Washer motor removal steps
• Engine room under cover front (Refer
to
)
• Connection of front/rear washer hose
5. Windshield washer motor
WINDSHIELD WIPER AND WASHER
TSB Revision
EXTERIOR
51-82
INSPECTION
M1511019103458
FRONT WASHER MOTOR INSPECTION
.
1. The front washer motor must be checked with the washer
tank installed and the washer fluid filled.
2. Connect the battery to the washer motor connector as
shown. Check that the washer motor delivers washer
strongly to the front washer hose side.
WINDSHIELD WASHER FLUID EJECTION CHECK
NOTE: The splashing point cannot be adjusted by the nozzle. If
the splashing point of the washer fluid is different from the fig-
ure below, replace the nozzle.
NOTE: Use special tool Adjustment tool, washer nozzle
(MB992326) to adjust the splashing points of the nozzle.
.
ADJUSTMENT OF THE MIST TYPE WASHER
NOZZLE INJECTION POSITION
CAUTION
Do not use tools other than the special tool (MB992326) to
adjust the injection angle because the washer nozzle may
get damaged.
CAUTION
Adjust the splashing position within the specified adjust-
ment range, otherwise the windshield cannot be washed
properly.
1. Use special tool Adjustment tool, washer nozzle
(MB992326) to adjust the splashing points of the nozzle.
2. Insert the mist type washer nozzle adjusting side of the
special tool Adjustment tool, washer nozzle (MB992326)
into the injection part of the mist type washer nozzle as
shown in figure (A).
AC506692AB
Front washer
hose
AC900637
AD
MB992326
Mist type
washer nozzle adjusting side
Jet type washer nozzle
adjusting side
Нет комментариевНе стесняйтесь поделиться с нами вашим ценным мнением.
Текст